Chevrolet IMPALA recalls by model year

Reported: 1967-10-23 (October 23, 1967) · Model years: 1965

Reported: 1969-02-28 (February 28, 1969) · Model years: 1965, 1966, 1967, 1968, 1969

EXHAUST EMISSIONS (CARBON MONOXIDE) MAY ENTER THE INTERIOR OF THE VEHICLE WHEN THE EXHAUST PIPE IS SUBSTANTIALLY OUT THE DESIGN POSITION, DETERIORATED FROM USE, OR WHEN AN OPENING IN THE BODY DEVELOPS NEAR THE EXHAUST OUTLET AND, AT THE SAME TIME, A NEGATIVE AIR PRESSURE OCCURS IN THE VEHICLE INTERIOR.

Consequence: UNDER THESE CONDITIONS, VEHICLE OCCUPANTS MAY EXPERIENCECARBON MONOXIDE POISONING.

Remedy: RESEAL NEARBY BODY JOINTS AND REPLACE THE DRAW PLUG IN THE BODY WHICH WAS USED TO REMOVE SURPLUS BONDERIZING SOLUTION DURING MANUFACTURE.

Reported: 1971-12-29 (December 29, 1971) · Model years: 1965, 1966, 1967, 1968, 1969

THERE IS A POSSIBILITY THAT A SEPARATED MOTOR MOUNT MAY ALLOW THE ENGINE TO LIFT, WHICH MAY AFFECT THE THROTTLE LINKAGE, MOMENTARILY INCREASING THROTTLE, POSSIBLY TO FULL THROTTLE.

Consequence: UNEXPECTED LOSS OF THROTTLE CONTROL MAY CAUSE LOSS OFVEHICLE CONTROL AND AN ACCIDENT.

Remedy: INSPECT ENGINE MOUNTS AND INSTALL RESTRAINTS WHICH WILL LIMIT ENGINE LIFT AND ELIMINATE POSSIBLE SECONDARY EFFECTS TO THE THROTTLE LINKAGE DUE TO ENGINE MOUNT SEPARATION.

Reported: 1969-02-20 (February 20, 1969) · Model years: 1969

Reported: 1969-07-09 (July 9, 1969) · Model years: 1969

Reported: 1970-12-03 (December 3, 1970) · Model years: 1971

Reported: 1971-07-20 (July 20, 1971) · Model years: 1971

Reported: 1971-07-26 (July 26, 1971) · Model years: 1971

Reported: 1973-01-24 (January 24, 1973) · Model years: 1971, 1972

THE POSSIBILITY EXISTS THAT DRIVING ON UNPAVED ROAD SURFACES, PARTICULARLY ROADS WHICH ARE HEAVILY GRAVELED AND WHICH ARE EXTREMELY WAVY OR FILLED WITH CHUCKHOLES, AT SPEEDS WHICH CAUSE THE CAR TO PITCH EXCESSIVELY, THE FRONT CROSSMEMBER MAY SCOOP UP LOOSE STONES OR GRAVEL AND COULD BE THROWN INTO THE ENGINE COMPARTMENT. IT IS POSSIBLE FOR ONE OF THESE STONES TO LODGE BETWEEN THE STEERING COUPLING AND THE FRAME AND CAUSE INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERING CONTROL OF THE CAR WHEN STEERING WHEEL IS TURNED TO THE LEFT.

Consequence: INCREASED STEERING EFFORT OR INTERFERENCE WITH STEERINGCONTROL MAY LEAD TO LOSS OF VEHICLE CONTROL AND AN ACCIDENT.

Remedy: INSPECT AND INSTALL SHIELD ON AFFECTED VEHICLES.

Reported: 1972-07-19 (July 19, 1972) · Model years: 1972

Reported: 1974-02-15 (February 15, 1974) · Model years: 1973, 1974

Reported: 1973-12-19 (December 19, 1973) · Model years: 1974

Reported: 1973-12-27 (December 27, 1973) · Model years: 1974

Reported: 1975-12-19 (December 19, 1975) · Model years: 1976

Reported: 1976-09-07 (September 7, 1976) · Model years: 1977

Reported: 1976-11-03 (November 3, 1976) · Model years: 1977

Reported: 1979-07-02 (July 2, 1979) · Model years: 1977, 1978, 1979

A CHILD COULD OPEN THE REAR SIDE COMPARTMENT DOOR AND ENTER THIS COMPARTMENT. THE CHILD COULD BECOME ENTRAPPED IF THE DOOR WERE TO CLOSE, AS IT CANNOT BE UNLATCHED FROM THE INSIDE.

Remedy: DEALER WILL REPLACE THE ORIGINAL COMPARTMENT DOOR LATCH, WHICH CAN BE LATCHED WITHOUT A KEY, WITH A NEW ASSEMBLY THAT REQUIRES A KEY TO LATCH AS WELL AS LOCK THE DOOR.

Reported: 1977-11-16 (November 16, 1977) · Model years: 1978

THE REAR WHEEL MOUNTING BOLTS ON THE AFFECTED VEHICLES, ARE BRITTLE AND THEREFORE MAY FRACTURE. THIS BRITTLENESS IS DUE TO IMPROPER HEAT TREATMENT DURING MANUFACTURE. IF THE BOLTS BREAK, THE TIRE AND WHEEL ASSEMBLY MAY SEPARATE FROM THE VEHICLE.

Remedy: DEALER WILL INSPECT AND, IF NECESSARY, WILL REPLACE DEFECTIVE BOLTS ON ALL AXLES AND THE TEN REAR AXLE WHEEL MOUNTING BOLTS, FREE OF CHARGE.

Reported: 1978-08-16 (August 16, 1978) · Model years: 1978

THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "ANCHORAGE OF SEATS", IN THAT THE FRONT SEAT ADJUSTER ASSEMBLIES HAVE LOCK BARS WHICH MAY NOT REMAIN ENGAGED WHEN TEST PROCEDURE FORCES ARE APPLIED TO THE SEAT.

Remedy: DEALER WILL INSTALL AN ADDITIONAL LOCK BAR RETURN SPRING WITHOUT CHARGE TO OWNER.

Reported: 1979-06-06 (June 6, 1979) · Model years: 1979

ON THE INVOLVED VEHICLES THE BRAKE STOPLIGHT AND CRUISE CONTROL SWITCH WHICH IS OPERATED BY THE BRAKE PEDAL MAY HAVE BEEN ASSEMBLED WITH AN INCORRECT LUBRICANT ON THE ACTUATING PLUNGER. THIS CAN CAUSE THE REAR BRAKE STOPLIGHTS TO BECOME INOPERATIVE AND THE CRUISE CONTROL, IF ACTIVATED, TO STAY ELECTRICALLY ENGAGED.

Remedy: DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE BRAKE STOPLIGHT AND CRUISE CONTROL SWITCH AT NO COST TO OWNER.

Reported: 1979-11-13 (November 13, 1979) · Model years: 1979

THE HEADS MAY BREAK OFF THE FRONT OUTBOARD SEAT BELT ANCHOR BOLTS DURING NORMAL VEHICLE OPERATION EVEN UNDER NO LOAD CONDITIONS. THIS IS DUE TO THE COMBINATION OF BOLTS USED, HIGH INSTALLATION TORQUE AND ARRANGEMENT OF THE BODY ANCHORAGE.

Remedy: DEALER WILL REPLACE ALL ORIGINAL EQUIPMENT FRONT OUTBOARD SEAT BELT ANCHOR BOLTS ON THE AFFECTED VEHICLES AT NO COST TO OWNER.

Reported: 1980-10-14 (October 14, 1980) · Model years: 1980

VEHICLES MAY NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS". THE TIRE RIM SIZE WAS OMITTED ON THE EXISTING LABEL.

Remedy: THE OWNER HAS THE OPTION OF AFFIXING THE CORRECT INFORMATION LABEL HIM/HERSELF OR HAVING THE DEALER DO IT AT NO CHARGE TO OWNER.

Reported: 1980-10-15 (October 15, 1980) · Model years: 1980

THE INVOLVED VEHICLES MAY HAVE INSUFFICIENT CLEARANCE BETWEEN THE FRONT BRAKE PIPE AND THE ENGINE OIL PAN. THIS CONDITION COULD CAUSE THE BRAKE PIPE TO CONTACT THE LEFT HAND FRONT EDGE OF THE OIL PAN, RESULTING IN WEAR AND, EVENTUALLY, DAMAGE TO THE BRAKE PIPE. THIS COULD LEAD TO A LOSS OF BRAKE FLUID AND SUBSEQUENT LOSS OF BRAKES.

Remedy: DEALER WILL REPLACE THE BRAKE PIPE, IF NECESSARY, FREE OF CHARGE.

Reported: 1983-08-19 (August 19, 1983) · Model years: 1980, 1981, 1982, 1983

ACCELERATOR PUMP LEVER RETAINING PIN MAY LOOSEN AFTER REPEATED HEAVY ACCELERATOR PEDAL APPLICATIONS. THIS COULD CAUSE THE THROTTLE TO BECOME STUCK IN THE OPEN POSITION.

Remedy: DEALER WILL INSTALL A SPECIAL COTTER PIN, TO RETAIN THE ACCELERATOR PUMP PIN, AND A SPRING CLIP THRUST WASHER ON THE ACCELERATOR PUMP LINK.

Reported: 1980-09-25 (September 25, 1980) · Model years: 1981

THE INVOLVED VEHICLES MAY HAVE BEEN ASSEMBLED WITH A BRAKE PEDAL SUPPORT BRACKET WHICH WAS DESIGNED FOR USE IN DIESEL ENGINE VEHICLES. THE INCORRECT BRACKET MAY CAUSE THE SERVICE BRAKES TO REMAIN PARTIALLY APPLIED, RESULTING IN BRAKE OVERHEATING AND REDUCED BRAKING EFFECTIVENESS.

Remedy: DEALER WILL INSPECT VEHICLES AND, IF NECESSARY, REPLACE THE PEDAL SUPPORT BRACKET AT NO CHARGE TO OWNER.

Reported: 1982-01-03 (January 3, 1982) · Model years: 1982

UNDER CERTAIN VEHICLE OPERATING CONDITIONS, THE GOVERNOR WEIGHT RETAINER IN THE INJECTION PUMP MAY FAIL. THE THROTTLE VALVE COULD STICK, PREVENTING RETURN TO IDLE AND SHUT DOWN OF THE ENGINE BY THE DRIVER.

Remedy: DEALER WILL REPLACE THE GOVERNOR WEIGHT ASSEMBLY IN THE INJECTION PUMP AT NO COST TO OWNER.

Reported: 2000-08-07 (August 7, 2000) · Model years: 2000, 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.

Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.

Reported: 2000-11-13 (November 13, 2000) · Model years: 2000, 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.

Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.

Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.

Reported: 2001-04-24 (April 24, 2001) · Model years: 2000, 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.

Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.

Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.

Reported: 2004-02-24 (February 24, 2004) · Model years: 2000

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.

Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.

Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.

Reported: 2009-04-08 (April 8, 2009) · Model years: 2000, 2001, 2002, 2003

GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.

Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL REPLACE THE ENGINE’S FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINE’S PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

Reported: 2014-07-03 (July 3, 2014) · Model years: 2000, 2001, 2002, 2003, 2004, 2005

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

Reported: 2015-10-26 (October 26, 2015) · Model years: 2000, 2001, 2002, 2003, 2004

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Reported: 2000-08-29 (August 29, 2000) · Model years: 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.

Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.

Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.

Reported: 2002-08-09 (August 9, 2002) · Model years: 2002, 2003

CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Reported: 2003-02-14 (February 14, 2003) · Model years: 2003

ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.

Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.

Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.

Reported: 2004-06-23 (June 23, 2004) · Model years: 2004

CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.

Consequence: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.

Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.

Reported: 2015-04-06 (April 6, 2015) · Model years: 2004

General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.

Consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.

Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.

Reported: 2014-06-23 (June 23, 2014) · Model years: 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.

Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 23, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), and 1-800-222-1020 (Chevrolet). GM's number for this recall is 14299.

Reported: 2006-10-31 (October 31, 2006) · Model years: 2007

ON CERTAIN VEHICLES, THE FUEL TANK IS MISSING THE ADHESIVE LAYER THAT BONDS THE BARRIER LAYER TO THE OUTER SHELL OF THE FUEL TANK.

Consequence: WITH THIS CONDITION, FUEL AND/OR FUEL VAPORS COULD SEEP OUT BETWEEN THE LAYERS, INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL INSPECT THE SERIAL NUMBER ON THE FUEL TANK AND REPLACE THE FUEL TANK IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 13, 2006. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, OR PONTIAC AT 1-800-620-7668.

Reported: 2012-08-03 (August 3, 2012) · Model years: 2008, 2009, 2010, 2011, 2012

General Motors (GM) is recalling certain model year 2008-2012 Chevrolet Impala police vehicles because the front lower control arms may fracture. This safety recall does not include non-police Chevrolet Impala vehicles.

Consequence: A broken control arm can result in the loss of control of the vehicle, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will replace both front lower control arms, free of charge. The safety recall began on August 21, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546.

Reported: 2008-10-06 (October 6, 2008) · Model years: 2009

GM IS RECALLING 79 MY 2009 CHEVROLET IMPALA VEHICLES. SOME OF THESE VEHICLES HAVE A PASSENGER-SIDE FRONT AIR BAG INFLATOR THAT COULD FRACTURE AT AN INFLATOR TUBE DURING A DEPLOYMENT.

Consequence: DURING A PASSENGER-SIDE AIR BAG DEPLOYMENT, PIECES OF THE INFLATOR TUBE COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE PASSENGER.

Remedy: DEALERS WILL INSTALL A NEW PASSENGER-SIDE FRONT AIR BAG. THE RECALL BEGAN ON OCTOBER 10, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .

Reported: 2010-10-13 (October 13, 2010) · Model years: 2009, 2010

GM IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET IMPALAS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE FRONT SAFETY BELT WEBBING MAY NOT HAVE BEEN PROPERLY SECURED TO THE LAP BELT ANCHOR PRETENSIONER MOUNTED TO THE SIDE OF THE SEAT NEAREST THE DOOR.

Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, WHICH COULD RESULT IN INJURY TO THE OCCUPANT.

Remedy: DEALERS WILL INSPECT BOTH FRONT SAFETY BELTS FOR PROPER INSTALLATION OF THE ANCHORS TO THE PRETENSIONERS AND, IF NECESSARY, REINSTALL THE ANCHORS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 5, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Reported: 2016-07-05 (July 5, 2016) · Model years: 2009, 2010

General Motors LLC (GM) is recalling certain model year 2009-2010 Chevrolet Impala vehicles manufactured April 25, 2008 through February 16, 2010. The front passenger seat frame may contact and damage the wires of the passenger presence sensor module.

Consequence: If the wires are damaged, the passenger presence sensory system may fail to recognize that the passenger seat is occupied, disabling the air bag. Damage may also cause the air bag fuse to short resulting in a loss of all air bags and seat belt pretensions. Both conditions increase the risk of injury during a crash.

Remedy: GM will notify owners, and dealers will double wrap the wires with anti-abrasion tape and replace damaged wires as necessary, free of charge. The recall began on August 1, 2016. Owners may contact Chevrolet customer service at 1-800-521-7300. GM's recall campaign number is 36110.

Reported: 2011-08-05 (August 5, 2011) · Model years: 2012

GM IS RECALLING CERTAIN MODEL YEAR 2012 CHEVROLET IMPALA VEHICLES MANUFACTURED FROM APRIL 19, 2011, THROUGH JULY 29, 2011. THE UPPER POWER STEERING HOSE MAY HAVE BEEN MISROUTED SO THAT IT CAN COME IN CLOSE PROXIMITY TO AND/OR CONTACT THE CATALYTIC CONVERTER. WITH THE ENGINE ON, HEAT FROM THE CATALYTIC CONVERTER MAY MELT THE POWER STEERING HOSE.

Consequence: POWER STEERING FLUID COULD FLOW ONTO THE CATALYTIC CONVERTER, AND AN ENGINE COMPARTMENT FIRE COULD OCCUR.

Remedy: GM DEALERS WILL INSPECT TO ENSURE THAT THE UPPER POWER STEERING HOSE IS ROUTED CORRECTLY AND MAKE THE NECESSARY REPAIRS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 5, 2011. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.

Reported: 2013-05-24 (May 24, 2013) · Model years: 2014

General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."

Consequence: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.

Reported: 2014-02-21 (February 21, 2014) · Model years: 2014

General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."

Consequence: If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy: General Motors will notify owners, and dealers will inspect and replace any affected transmission shift cable adjusters, free of charge. The recall began on April 10, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Buick owners at 1-800-521-7300, and GMC owners at 1-800-462-8782. General Motors' number associated with this recall is 14048.

Reported: 2014-07-02 (July 2, 2014) · Model years: 2014

General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, Cadillac XTS, Chevrolet Camaro and Chevrolet Impala vehicles. Improperly torqued fasteners may cause the steering intermediate shaft and the steering gear and/or the lower control arm and the lower ball joint to separate.

Consequence: If any of the components separate, the vehicle may have a loss of steering, increasing the risk of a crash.

Remedy: GM began to notify owners on June 27, 2014, and dealers will inspect the fasteners for correct torque, correcting them as necessary, free of charge. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac) or 1-800-222-1020 (Chevrolet). GM's number for this recall is 14378.

Reported: 2014-07-23 (July 23, 2014) · Model years: 2014

General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured November 5, 2012, to December 20, 2013. Due to a poor electrical ground connection to the Power Steering Control Module (PSCM), the affected vehicles may have a loss of power steering assist during start up or while driving.

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will clean paint from behind the ground stud nut and update the PSCM software, free of charge. Owners may contact Chevrolet customer service at 1-800-222-1020. The recall began on August 21, 2014. GM's number for this recall is 14330.

Reported: 2014-08-08 (August 8, 2014) · Model years: 2014, 2015

General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Impala vehicles manufactured May 7, 2014, to July 28, 2014. In the event of an accident, the center storage console may not stay latched. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 201, "Occupant Protection In Interior Impact."

Consequence: The storage compartment door may not remain closed in the event of a crash, increasing the risk of occupant injury.

Remedy: Parts to remedy this condition are not currently available. GM will send owners an interim notification in early October 2014, and will send a second letter when parts are available. At that time dealers will inspect, and if necessary, replace the console storage compartment door inertia latch, free of charge. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14476.

Reported: 2014-08-28 (August 28, 2014) · Model years: 2014

General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac XTS vehicles manufactured April 11, 2013, to June 27, 2013, and 2014 Chevrolet Impala vehicles manufactured May 13, 2013, to November 5, 2013. The affected vehicles may have left the factory with the sensing and diagnostic module (SDM) set to "manufacturing mode."

Consequence: In manufacturing mode, the vehicle's air bags will not deploy in the event of a crash, increasing the risk of occupant injury.

Remedy: GM will notify owners, and dealers are to reprogram the SDM to the correct mode, free of charge. The recall is expected to begin in September 2014. Owners may contact Cadillac customer service at 1-800-458-8006 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14532.

Reported: 2014-09-09 (September 9, 2014) · Model years: 2014, 2015

General Motors LLC (GM) is recalling certain model year 2013-2015 Cadillac XTS vehicles manufactured February 14, 2012, to August 22, 2014, and 2014-2015 Chevrolet Impala vehicles manufactured November 5, 2012, to September 2, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged.

Consequence: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.

Remedy: GM will notify owners, and dealers will update the electronic parking brake software, free of charge. The recall began on October 28, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14471.

Reported: 2014-10-01 (October 1, 2014) · Model years: 2014

General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.

Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GM’s number for this recall is 14515.

Reported: 2015-02-11 (February 11, 2015) · Model years: 2014

General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured November 15, 2012, to May 30, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Systems (FMVSS) No. 135 "Light Vehicle Brake Systems."

Consequence: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.

Remedy: GM will notify owners, and dealers will reprogram the electronic parking brake control module with new software, free of charge. The recall began March 5, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 (Chevrolet). GM's number for this recall is 15100. Note: This recall covers a limited population of vehicles that were remedied incorrectly under recall 14V-541.

Reported: 2015-04-06 (April 6, 2015) · Model years: 2014

General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured March 22, 2013, to May 22, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Systems (FMVSS) No. 135 "Light Vehicle Brake Systems."

Consequence: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.

Remedy: GM has notified owners, and dealers will reprogram the electronic parking brake control module with new software, free of charge. The recall began on May 6, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15259. Note: The vehicles covered by this campaign were previously remedied incorrectly under campaigns 14V541 or 15V085.

Reported: 2015-07-24 (July 24, 2015) · Model years: 2014, 2015

General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Impala vehicles manufactured April 15, 2013, to June 19, 2015, equipped with front vented-heated passenger seats. Accordingly, the Automatic Occupant Sensing (AOS) system may fail to suppress the front passenger air bag if a child seat is in the front passenger seat. These vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection."

Consequence: If the front passenger air bag deploys with a child seat in the front passenger seat, it increases the risk of injury to the child.

Remedy: GM will notify owners, and dealers will correct the calibration-learning error by preconditioning the empty seat, and also resetting the ECU to a seat zero-value, free of charge. The recall began on August 25, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15400.

Reported: 2018-08-30 (August 30, 2018) · Model years: 2018, 2019

General Motors LLC (GM) is recalling certain 2018-2019 Chevrolet Equinox, Impala, Cruze, Volt and Bolt EV vehicles, GMC Terrain vehicles, Buick Lacrosse and Regal vehicles, Cadillac XTS and XTS Professional vehicles and 2018 Chevrolet Malibu vehicles. The rear brake caliper pistons may have an insufficient coating causing gas pockets to form, potentially reducing rear brake performance.

Consequence: A reduction of braking performance can increase the risk of a crash.

Remedy: GM will notify owners, and dealers will bleed the vehicle's brake system, free of charge. The recall began October 11, 2018. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18279.