Ford E-450 recalls by model year

Reported: 2009-10-13 (October 13, 2009) · Model years: 1992, 1993, 1994, 1995, 1996, 1997, 1998, 1999, 2000, 2001, 2002, 2003

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 2006-08-01 (August 1, 2006) · Model years: 1996, 1997, 1998, 1999, 2000, 2001, 2002

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Reported: 2004-09-13 (September 13, 2004) · Model years: 2003, 2004

ON CERTAIN VANS, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.

Consequence: THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.

Remedy: DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.

Reported: 2004-09-13 (September 13, 2004) · Model years: 2003, 2004

ON CERTAIN VANS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.

Consequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.

Remedy: DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. THE RECALL BEGAN SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.

Reported: 2007-08-03 (August 3, 2007) · Model years: 2003

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 2005-06-10 (June 10, 2005) · Model years: 2004, 2005

CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.

Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.

Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Reported: 2004-12-20 (December 20, 2004) · Model years: 2005

CERTAIN CUT-AWAY INCOMPLETE TRUCKS EQUIPPED WITH LT225/75R16E TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES.

Consequence: AT THE INCORRECTLY STATED PRESSURE, THE REAR TIRES ARE UNABLE TO SUPPORT THE GROSS AXLE WEIGHT RATING (GAWR) FOR THE REAR AXLE.

Remedy: OWNERS AND DEALERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT REAR TIRE INFLATION INFORMATION. THE RECALL BEGAN ON JANUARY 11, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2008-10-06 (October 6, 2008) · Model years: 2005

MOBILITYWORKS IS RECALLING 133 MY 2005-2006 FORD E250, MY 2000, 2004-2006 E350, MY 2000, 2005 E450, MY 2005-2006 GMC 2500, GMC 3500, AND MY 2006 DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: MOBILITYWORKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITYWORKS AT 1-800-769-8267.

Reported: 2008-12-04 (December 4, 2008) · Model years: 2005

NEW YORK BUS SALES IS RECALLING 1 RICON WHEELCHAIR LIFT WHICH IT INSTALLED ON A FORD SCHOOL BUS, MODEL E450. THE VEHICLE FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: NEW YORK BUS SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW YORK BUS SALES AT 1-315-687-3969.

Reported: 2008-12-05 (December 5, 2008) · Model years: 2005

NEW YORK BUS SALES IS RECALLING 1 RICON WHEELCHAIR LIFT WHICH IT INSTALLED ON A FORD SCHOOL BUS, MODEL E450. THE VEHICLE FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: NEW YORK BUS SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW YORK BUS SALES AT 1-315-687-3969.

Reported: 2019-05-29 (May 29, 2019) · Model years: 2005, 2006, 2009, 2010, 2014, 2016

VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.

Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.

Remedy: VCI Emergency Vehicle Specialists will work with ASA to notify the owners, and remedy the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics at 1-800-384-4400.

Reported: 2005-11-09 (November 9, 2005) · Model years: 2006

ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.

Reported: 2008-09-25 (September 25, 2008) · Model years: 2006, 2007

LA BOIT IS RECALLING 8 MY 2006-2007 FORD E-450, GMC 5500, AND WORKHORSE SPECIALTY VEHICLES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: LA BOIT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR LA BOIT AT 1-614-231-7640.

Reported: 2008-09-25 (September 25, 2008) · Model years: 2006, 2007

LA BOIT IS RECALLING 8 MY 2006-2007 FORD E-450, GMC 5500, AND WORKHORSE SPECIALTY VEHICLES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: LA BOIT IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR LA BOIT AT 1-614-231-7640.

Reported: 2008-10-06 (October 6, 2008) · Model years: 2006

MOBILITYWORKS IS RECALLING 224 MY 2007-2008 FORD E150, MY 2006-2008 E250, MY 2004-2007 E350, MY 2006 E450, MY 2005-2007 CHEVROLET 2500, MY 2007 CHEVROLET 1500, AND MY 2006 DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: MOBILITYWORKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITY WORKS AT 1-800-769-8267.

Reported: 2008-12-18 (December 18, 2008) · Model years: 2006, 2007, 2008

COLONIAL IS RECALLING 50 MY 2006-2008 FORD E350, E450, AND CHEVROLET G-VAN CUTAWAY CHASSIS VEHICLES AND EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: COLONIAL IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COLONIAL AT 1-301-698-5100.

Reported: 2008-12-18 (December 18, 2008) · Model years: 2006, 2007, 2008

COLONIAL IS RECALLING 50 MY 2006-2008 FORD E350, E450, AND CHEVROLET G-VAN CUTAWAY CHASSIS VEHICLES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: COLONIAL IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR COLONIAL AT 1-301-698-5100.

Reported: 2009-11-13 (November 13, 2009) · Model years: 2006, 2007, 2008, 2009

E-N-G MOBILE SYSTEM IS RECALLING CERTAIN MODEL YEAR 2008 CHEVROLET W5500, MODEL YEAR 2007-2009 DODGE 3500, MODEL YEAR 2009 MIGHTY MOVER, MODEL YEAR 2006-2009 FORD E-250, E-350 AND E-450, MODEL YEAR 2008-2009 GMC W4500, MODEL YEAR 2007 INTERNATIONAL 4300, MODEL YEAR 2009 TOYOTA LAND CRUISER VEHICLES EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

Consequence: THIS DEFECT COULD RESULT IN A FIRE.

Remedy: E-N-G MOBILE SYSTEM WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2009. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR E-N-G MOBILE SYSTEM AT 1-925-798-4060.

Reported: 2012-12-12 (December 12, 2012) · Model years: 2006, 2007, 2009, 2010, 2011

Creative Bus Sales, Inc is recalling certain model year 2006-2011 Chevrolet and GMC C5500, and Ford E450, and Econoline 350 vehicles equipped with Braun wheelchair lifts. Over time, or with frequent use, the roll stop latches on the outer barrier of the lifts may become bent or misaligned.

Consequence: A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.

Remedy: Braun is conducting this recall on behalf of Creative Bus Sales. Braun will notify owners, and dealers will repair the vehicles free of charge. The recall began on November 23, 2012. Owners may contact Creative Bus at 1-888-633-8380 or Braun at 1-800-488-0359.

Reported: 2014-09-24 (September 24, 2014) · Model years: 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014

Elkhart Coach (Elkhart) is recalling certain model year 2006-2014 Ford E-350 and Ford E-450 vehicles manufactured January 1, 2006, to May 1, 2014 and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Elkhart will notify owners to take the vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 1, 2014. Owners may contact Ricon customer service at 1-800-322-2884. Owners may also contact Elkhart customer service at 1-574-264-5179. This recall has been superseded by campaign 15V-768.

Reported: 2015-02-25 (February 25, 2015) · Model years: 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013

Farber Specialty Vehicles (Farber) is recalling various specialty vehicles modified by Farber and equipped with model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Farber will notify owners to take their vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on March 24, 2015. Owners may contact Farber customer service at 1-800-331-3188, or Ricon customer service at 1-800-322-2884. Farber's number for this recall is 14E-041.

Reported: 2009-11-19 (November 19, 2009) · Model years: 2007, 2008

CUES, INC. IS RECALLING CERTAIN MODEL YEAR 2007-2009 SERVICE VEHICLES BUILT ON VARIOUS CHASSIS EQUIPPED WITH CARRIER AIRV CEILING UNITS, MODEL NOS. 68RV0010BA, 68RV0012CA, AND 68RV0010EA. THE HEATER ELEMENT IN THESE ASSEMBLIES MAY BE DEFECTIVE WHICH COULD CAUSE THE UNIT TO CREATE SMOKE OR SPARKS.

Consequence: THIS DEFECT COULD RESULT IN A FIRE.

Remedy: CUES IS WORKING WITH CARRIER TO REMEDY THE AFFECTED VEHICLES. REPAIRS WILL BE MADE BY CARRIER FREE OF CHARGE. PLEASE SEE CARRIER'S DEFECT REPORT 09E-053. THE SAFETY RECALL BEGAN ON JANUARY 5, 2010. OWNERS MAY CONTACT CARRIER AT 1-877-584-7059 OR CUES AT 1-407-849-0190.

Reported: 2010-04-02 (April 2, 2010) · Model years: 2007, 2008, 2009

ELKHART COACH HAS NOTIFIED NHTSA OF A DEFECT IN CERTAIN TRANSIT BUSES FITTED WITH RICON PUBLIC USE LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE WITHOUT THE RESTRAINT BELT PROPERLY BUCKLED.

Remedy: ELKHART COACH IS WORKING WITH RICON AND RICON WILL BE HANDLING THE REMEDY FOR THIS CAMPAIGN. PLEASE SEE RICON'S DEFECT REPORT 09E-060. RICON WILL PROVIDE CUSTOMERS WITH A WARNING DECAL AND A DVD-BASED TRAINING AID. THE SAFETY RECALL BEGAN ON JULY 27, 2010. OWNERS MAY CONTACT RICON CUSTOMER SERVICE AT 800-322-2884, EMAILING AT WWW.DMATA@WABTEC.COM.

Reported: 2010-04-02 (April 2, 2010) · Model years: 2007, 2008, 2009

ELKHART COACH HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN TRANSIT BUSES EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS, DUE TO A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION. IF THE "UP" SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

Consequence: WHEN THE PLATFORM OVERRUNS THE VEHICLE FLOOR LEVEL AND STOPS AT AN ANGLE FROM 15-20 DEGREES, IT IS POSSIBLE FOR A PERSON IN A WHEELCHAIR TO TIP OVER AND FOR SOMEONE STANDING ON THE PLATFORM TO FALL, POSSIBLY RESULTING IN INJURIES.

Remedy: ELKHART COACH WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY AUTHORIZED RICON DEALERS FREE OF CHARGE. CURRENTLY RICON IS DEVELOPING A SOFTWARE SOLUTION AND IS NOT AVAILABLE. UNTIL THE SOFTWARE SOLUTION IS AVAILABLE, RICON WILL PROVIDE OWNERS WITH A BULLETIN OUTLINING PROPER WHEELCHAIR LIFT OPERATION AND WILL SHIP OWNERS A DVD-BASED TRAINING AID TO PROMOTE PROPER LIFT OPERATION AT NO COST. THE SAFETY RECALL BEGAN ON JULY 27, 2010. OWNERS MAY CONTACT RICON CUSTOMER SERVICE AT 800- 322-2884, EMAILING AT WWW.DMATA@WABTEC.COM.

Reported: 2009-04-07 (April 7, 2009) · Model years: 2009

FORD MOTOR COMPANY IS RECALLING 429 MY 2009 FORD ECONOLINE E-350 AND E-450 CUTAWAY SCHOOL BUS PREP PACKAGE VEHICLES MANUFACTURED FROM APRIL 22, 2008 THROUGH MARCH 2, 2009, TO REPOSITION THE UPPER FUEL TANK PROTECTION BRACKET ON THE FRAME RAIL.

Consequence: IN CERTAIN TYPES OF VERY SEVERE CRASHES, THE FUEL TANK MAY BE DAMAGED AND RESULT IN A LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: FORD WILL NOTIFY OWNERS AND DEALERS WILL REPOSITION THE UPPER FUEL TANK PROTECTION BRACKET FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 14, 2009. OWNERS MAY CONTACT FORD TOLL-FREE AT 1-866-436-7332 OR CONTACT A LOCAL FORD OR LINCOLN/MERCURY DEALER FOR MORE INFORMATION.

Reported: 2009-06-23 (June 23, 2009) · Model years: 2009

FORD IS RECALLING 65 MY 2008-2009 E-350 AND MY 2009 E450 CUTAWAY VEHICLES EQUIPPED WITH SCHOOL BUS PREP PACKAGES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." THESE VEHICLES MAY NOT HAVE BEEN ASSEMBLED WITH THE FUEL TANK PROTECTION BRACKETS THAT ARE REQUIRED FOR SCHOOL BUS APPLICATIONS.

Consequence: IN CERTAIN TYPES OF VERY SEVERE CRASHES, THE FUEL TANK MAY BE DAMAGED AND RESULT IN A LEAK. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT FOR PROPER FUEL TANK PROTECTION BRACKET INSTALLATION AND INSTALL BRACKETS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 26, 2009. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR THROUGH THE INTERNET AT WWW.OWNERCONNECTION.COM.

Reported: 2011-08-31 (August 31, 2011) · Model years: 2010, 2011

ROUSH IS RECALLING CERTAIN MODEL YEAR 2009-2011 FORD E-150, E-250, AND E-350 5.4L ENGIN VANS/WAGONS/CUTAWAYS, AND MODEL YEAR 2010-2011 FORD E-450 6.8L ENGINE CUTAWAY VEHICLES ALTERED BY ROUCH TO OPERATE USING THE ROUSH BRANDED CLEANTECH PROPANE AUTOGAS FUEL SYSTEM. THE FUEL RAILS INCLUDED IN THE KITS CONTAIN IMPROPERLY SEATED INJECTOR RETENTION CLIPS. THIS COULD RESULT IN LEAKAGE OF PROPANE AUTOGAS.

Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: ROUSH WILL NOTIFY OWNERS OF THE VEHICLES OF WHICH THE KITS WERE INSTALLED IN ORDER TO ARRANGE FOR FREE REPLACEMENT OF THE INJECTOR RETENTION CLIPS. THE SAFETY RECALL BEGAN ON SEPTEMBER 26, 2011. OWNERS MAY CONTACT ROUSH AT 1-734-466-6255.

Reported: 2014-07-10 (July 10, 2014) · Model years: 2010, 2011, 2012

Roush Performance Products, Inc. (Roush) is recalling certain model year 2010-2012 Ford E-150 Wagons and Cargo Vans, E-250 Cargo Vans and Extended Cargo Vans, E-350 Wagons, Extended Wagons, Cargo Vans, and Extended Vans, and E-450 Cutaway models. These models were modified by Roush to be equipped with certain propane fuel system conversion kits manufactured January 2011 to August 2012 with an aluminum fuel line fitting. Due to a reaction between the different metals, the affected kits may develop a propane leak where the aluminum fuel line fitting contacts the brass supply valve housing.

Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.

Remedy: Roush will notify owners and will replace the aluminum fuel line fittings with new stainless steel fittings, free of charge. The recall began on September 1, 2014. Owners may contact Roush customer service at 1-800-597-6874.

Reported: 2011-04-20 (April 20, 2011) · Model years: 2011

FORD IS RECALLING CERTAIN MODEL YEAR 2011 E-150, E-250, E-350 AND E-450 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." IT MAY BE POSSIBLE THAT UNDER UNUSUALLY HIGH LOADS, SUCH AS DURING A CRASH, THE DRIVER POWER SEAT TRACK WORM GEAR MAY FRACTURE.

Consequence: IN THE EVENT OF A CRASH OR OTHER CIRCUMSTANCES OF SEVERE LOADING, THE WORM GEAR COULD FRACTURE AND ALLOW THE SEAT TO SHIFT UNRESTRAINED FORWARD OR BACKWARD INCREASING THE RISK AND/OR SEVERITY OF INJURIES TO THE DRIVER.

Remedy: DEALERS WILL INSPECT THE DRIVER'S SEAT TRACK ASSEMBLY, AND IF NECESSARY, REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Reported: 2011-05-31 (May 31, 2011) · Model years: 2011

ROUSH PERFORMANCE PRODUCTS IS RECALLING CERTAIN 2011 FORD E-SERIES VANS EQUIPPED WITH 5.4 OR 6.8 LITER ENGINES THAT HAVE BEEN ALTERED BY ROUSH TO OPERATE USING THE ROUSH LIQUID PROPANE AUTOGAS FUEL SYSTEM. A VALVE IN THE SYSTEM MAY HAVE BEEN MISMACHINED ALLOWING A PROPANE LEAK.

Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A VEHICLE FIRE.

Remedy: ROUSH WILL REPLACE THE DEFECTIVE VALVE WITH A CORRECTLY MACHINED ONE. ALL THE AFFECTED VEHICLES HAVE BEEN REPAIRED, THEREFORE, AN OWNER NOTIFICATION LETTER WILL NOT BE ISSUED FOR THIS CAMPAIGN. OWNERS MAY CONTACT ROUSH AT 1-734-466-6255.

Reported: 2011-08-26 (August 26, 2011) · Model years: 2011

Ford Motor Company (Ford) is recalling certain model year 2011 Ford E-150, E-250, E-350, and E-450 vehicles built from May 12, 2011, through May 26, 2011. Due to improper manufacturing conditions, some of the windshields may form bubbles after an extended time in hot temperatures. As such, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 205, "Glazing Materials."

Consequence: The presence of bubbles may hinder driver's visibility thereby increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and replace the windshield if bubbles are present, free of charge. The recall began in January 2014. Owners may contact the Ford customer relationship center at 1-866-436-7332. Ford's recall campaign number is 11C20.

Reported: 2014-08-06 (August 6, 2014) · Model years: 2012

Adrian Steel Company (Adrian) is recalling certain model year 2012 Ford E-150, E-250 and E-350 Commercial Cargo Vans modified by Adrian between September 21, 2012, to September 24, 2012. The affected vehicles are equipped with certain propane fuel system conversion kits with an aluminum fuel line fitting manufactured by Roush CleanTech. Due to a reaction between the different metals, the affected kits may develop a propane leak where the aluminum fuel line fitting contacts the brass supply valve housing.

Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.

Remedy: Adrian will notify owners, and dealers will replace the aluminum fuel line fittings with stainless steel fittings, free of charge. The recall began during July 2014. Owners may contact Adrian customer service at 1-800-677-2726.

Reported: 2019-04-18 (April 18, 2019) · Model years: 2014, 2015

Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.

Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.

Remedy: MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1-734-453-6452.

Reported: 2015-10-27 (October 27, 2015) · Model years: 2016

Ford Motor Company (Ford) is recalling certain model year 2016 E-350 and E-450 vehicles manufactured November 3, 2014, to September 1, 2015, and equipped with a 6.8L engine and an optional trailer brake controller. In the affected vehicles, the trailer brake controller may not actuate the trailer brakes.

Consequence: If the trailer brakes are not activated when the towing vehicle is slowing down, the distance needed to stop the vehicle may be lengthened, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began on November 10, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S32.

Reported: 2016-01-28 (January 28, 2016) · Model years: 2016

Ford Motor Company (Ford) is recalling certain model year 2016 E-350 and E-450 vehicles manufactured November 3, 2014, to December 10, 2015 and equipped with a 6.8L engine and an optional trailer brake controller. The trailer braking system may fail, increasing the distance needed to stop the vehicle.

Consequence: If the vehicle unexpectedly needs an extended braking distance, there would be an increased risk of a crash.

Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module, free of charge. The recall began on February 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S01. Note: This recall supersedes 15V-710. Any vehicle previously repaired under 15V-710 will need to be repaired again.

Reported: 2017-04-21 (April 21, 2017) · Model years: 2016

National Fleet Services of Ohio (National Fleet) is recalling certain 2016 Ford E-450 vehicles equipped with Roush, Generation 4, Propane Conversion Kits. The fuel control valve solenoid may short circuit, shutting off the flow of propane to the engine, causing the engine to shut off.

Consequence: An engine stall while driving increases the risk of a crash.

Remedy: National Fleet will notify owners, and Roush dealers will replace the defective fuel control valve solenoid, free of charge. The recall began on April 21, 2017. Owners may contact National Fleet customer service at 1-440-903-5177, or Roush customer service at 1-800-597-6874. National Fleet's number for this recall is VR.

Reported: 2019-05-03 (May 3, 2019) · Model years: 2017, 2018

Taylor Made Ambulances is recalling certain 2017-2018 Ford E-350, F-450, E-450, F-550, and GMC G3500-based ambulances equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.

Consequence: If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.

Remedy: Taylor Made will notify owners and Whelen will replace the brake lights, free of charge. The recall began June 5, 2019. Owners may contact Taylor Made Ambulances customer service at 1-800-468-1310.

Reported: 2019-06-18 (June 18, 2019) · Model years: 2017, 2018

SVO Group Inc. (SVO Group) is recalling certain 2017-2018 Ford E-350 and E-450-based shuttle buses equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The affected monitors may revert back to the factory default settings which may cause the camera image to be reversed.

Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.

Remedy: SVO Group will work with ASA to notify owners, and ASA will provide a harness relay capacitor module to eliminate the image reversal, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics customer service at 1-800-384-4400.

Reported: 2018-06-01 (June 1, 2018) · Model years: 2018

MORryde International, Inc. (MORryde) is recalling certain 2018 Ford E-450 chassis modified for transit bus use. The U-bolts on the rear axle that hold the leaf spring and rear axle together may have been insufficiently tightened.

Consequence: The loose U-bolts may further loosen or break allowing the axle to separate and cause a loss of control, increasing the risk of a crash.

Remedy: MORryde will notify the chassis purchasers, and dealers for those companies will inspect the tightness of the U-bolts, replacing or tightening the U-bolts as necessary, free of charge. The recall began on June 28, 2018. Owners may contact MORryde customer service at 1-574-293-1581.

Reported: 2019-03-26 (March 26, 2019) · Model years: 2018

Excellance, Inc. (Excellance) is recalling certain 2018 Ambulances and Emergency Vehicles built on Ford E-350, E-450, F-650, F-550 4x4, Chevrolet G4500, G4500 Diesel, C3500, G3500, Freightliner M2, International 4300, and Dodge 4500 chassis and equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.

Remedy: Excellance has notified owners, instructing them to contact Whelen to have the brake lights replaced, free of charge. The recall began on March 21, 2019. Owners may contact Whelen customer service at 1-860-718-2331 or Execellance at 1-256-772-9321.

Reported: 2020-02-21 (February 21, 2020) · Model years: 2021

Ford Motor Company (Ford) is recalling certain 2020 F-550 and 2021 E-350 and E-450 vehicles. The rear axle differential fluid may be below the minimum level, possibly resulting in a failure of the rear axle assembly and driveshaft separation.

Consequence: If the driveshaft separates, there may be a loss of drive, increasing the risk of crash. Additionally, if the parking brake is not applied, unintended vehicle movement can occur and increase the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will inspect the rear axle differential fluid level and adjust it, or replace the rear axle as necessary, free of charge. The recall began March 19, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S09.

Reported: 2020-03-23 (March 23, 2020) · Model years: 2021

Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. A wire harness in the rear of the vehicle may contact the vehicle frame, resulting in damage to the circuits that support the fuel pump and the anti-lock braking system (ABS).

Consequence: Damage to the fuel pump circuit in the wiring harness could result in an unexpected engine stall. Damage to the ABS wiring can lead to reduction of ABS functionality and a loss of roll stability control (RSC) functionality. These scenarios increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect the wire harness for damage. If no damage is found, dealers will apply anti-abrasion tape over the area and ensure clearance to surrounding components. If damage is found, dealers will splice in new wire and apply anti-abrasion tape over the area and ensure clearance to surrounding components. All services will be performed free of charge. The recall began May 18, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S13.

Reported: 2020-12-17 (December 17, 2020) · Model years: 2021

Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles. The underside of the engine cover may have mispositioned insulation, allowing the cover to get excessively hot.

Consequence: Direct and continuous contact with certain areas of engine cover surface in the passenger compartment may increase the risk of injury or burns to the skin of the driver or front seat passenger.

Remedy: Ford will notify owners, and dealers will inspect the engine cover for gaps between the rubber seal and the insulation. If gaps are present, the dealer will install engine cover insulation patches in the right hand and left hand inner lower corners of the engine cover. The dealer will also update the powertrain calibration for heat management under elevated idle conditions should a vehicle be equipped with SEIC or BCP, free of charge. The recall began February 15, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S73.

Reported: 2022-02-16 (February 16, 2022) · Model years: 2021, 2022

Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake Hydroboost unit may result in a sudden loss of power steering fluid.

Consequence: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.

Remedy: Dealers will inspect the connection between the power steering lines and the Hydroboost unit, and replace the power steering lines, as necessary, free of charge. Owner notification letters were mailed on March 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S08.

Reported: 2024-02-09 (February 9, 2024) · Model years: 2021, 2022

Ford Motor Company (Ford) is recalling certain 2021-2022 E-350 and E-450 vehicles equipped with dual rear wheels. An inadequate connection between the power steering pressure line and the brake hydroboost unit may result in a sudden loss of power steering fluid.

Consequence: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.

Remedy: Dealers will replace the power steering pressure line and the hydroboost jumper line, free of charge. Vehicles in this recall were previously recalled under 22V-089 and owners will need to have the new remedy completed even if their vehicle was remedied under the prior recall. Owner notification letters were mailed on June 21, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S07.

Reported: 2025-11-17 (November 17, 2025) · Model years: 2021

Ford Motor Company (Ford) is recalling certain 2021 E-350 and E-450 vehicles that received an incomplete software update under recall 20V795. The engine cover may become excessively hot.

Consequence: Direct contact with certain areas of engine cover surface in the passenger compartment may increase the risk of injury or burns to the skin of the driver or front seat passenger.

Remedy: Dealers will update the powertrain calibration for heat management under elevated idle conditions, free of charge. Owner notification letters were mailed January 7, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SC7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning December 22, 2025.

Reported: 2022-12-14 (December 14, 2022) · Model years: 2022, 2023

Ford Motor Company (Ford) is recalling certain 2022-2023 E-350, E-450, and 2021-2022 F-59 vehicles. The paint along the weld seam of the fuel tank may peel and lead to corrosion of the exposed metal, which can result in a fuel leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect the fuel tank and replace, if necessary, free of charge. Owner notification letters were mailed on April 14, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S76.

Reported: 2022-05-27 (May 27, 2022) · Model years: 2023

Ford Motor Company (Ford) is recalling certain 2022 F-Super Duty F-250, F-350, F-450, F-550, F600, and 2023 E-Series vehicles. In addition, certain 2016 E-Series, 2017 and 2019 F-450, 2021 F-350, and 2021 Transit vehicles that received a reprinted label are also included in this recall. The Safety Certification Labels are missing the tire size, rim type, and tire pressure values for both the front and rear axles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 110, "Tire Selection and Rim", and 120, "Wheels and Rims-Other Than Passenger Cars."

Consequence: Missing tire information could lead to an incorrect tire or rim being installed, or incorrect tire pressure, increasing the risk of a crash.

Remedy: Dealers will replace the Safety Certification Label, free of charge. Owner notification letters were mailed July 6, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22C09.

Reported: 2022-10-20 (October 20, 2022) · Model years: 2023

Ford Motor Company (Ford) is recalling certain 2023 E450 vehicles. The bolt that secures the rear axle rotor to the wheel-hub may be improperly tightened, possibly resulting in wheel separation.

Consequence: Wheel separation from the vehicle increases the risk of a crash.

Remedy: Dealers will inspect the rear axle serial number, and if necessary, remove and inspect the rear axle rotor and hub assembly. If any bolts are found to be loose, the rotor and hub assembly will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed April 18, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S68.

Reported: 2026-03-03 (March 3, 2026) · Model years: 2026, 2027

Ford Motor Company (Ford) is recalling certain 2026-2027 E-350 and E-450 vehicles. The backup alarm connector may become loose and detach, preventing the alarm from sounding when the vehicle is backing up.

Consequence: A backup alarm that fails to alert pedestrians and other vehicles of a reversing vehicle, increases the risk of crash or injury.

Remedy: Dealers will replace the exterior sound connector on the frame wiring harness, free of charge. Owner notification letters were mailed March 17, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S12. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.