2011 Ford E-450: complaints, problems and recalls

MY 2011 F450 WITH 60,000 MILES ON IT, WOULD NOT START AFTER JUST RUNNING. IT HAD NEVER GIVEN ANY INDICATIONS OF ANY PROBLEMS PRIOR TO NOT STARTING. THE DEALERSHIP WHERE IT WAS TAKEN WORKED ON IT FOR 9 DAYS HAND IN HAND WITH FORD WARRANTY DEPT AND CAME UP WITH FAILURE OF THE FUEL SYSTEM. ACCORDING TO FORD INSPECTORS, FUEL WAS CONTAMINATED. FUEL PUMP HAD METAL SHAVINGS IN FILTER SYSTEM. FUEL PUMP WAS RUSTED AND HAD NO LUBRICANT. BUMPER TO BUMPER WARRANTY DID NOT COVER THIS. WE ARE OUT OVER $5,000 (DON'T HAVE THE FINAL $$$$$ AMOUNT AT THIS …

Owner-reported narrative. 60,000 miles reported. Look up ODI 10479939 at NHTSA ↗

SIDEWALL CRACKING. *TR

Owner-reported narrative. 4,000 miles reported. Look up ODI 10565910 at NHTSA ↗

AS INSTRUCTED BY NHTSA 13T-012 TIRE RE CALL MICHELIN HAS FAILED TO PROVIDED REPLACEMENT TIRES THRU ITS FORD AND DEALER NETWORK TO ME. *TT

Owner-reported narrative. 45,000 miles reported. Look up ODI 10582805 at NHTSA ↗

THIS VEHICLE WAS CONVERTED TO AN AMBULANCE BY WHEELD COACH. THE AMBULANCE CAUGHT FIRE AND SPREAD TO THE BUILDING IN WHICH IT WAS PARKED AND UNOCCUPIED. A PARAMEDIC SMELLED SOMETHING COMING FROM THE BAY, AND, WHEN HE WENT TO INVESTIGATE, HE SAW SMOKE AND FIRE DRIPPING FROM UNDERNEATH THE AMBULANCE. AN INVESTIGATOR DETERMINED THAT THE LUG CONNECTION AT THE ALTERNATOR WAS IMPROPERLY INSTALLED BY WHEELED COACH. THE CONNECTION PRODUCED A HIGH RESISTANCE CONNECTION, PRODUCING TEMPERATURES SUFFICIENT TO IGNITE A COMPETENT FUEL SOURCE AND/OR CAUSED THE…

Owner-reported narrative. Look up ODI 10671038 at NHTSA ↗

ON TWO OCCASIONS, OVER THE PAST 2 YEARS, WHILE DRIVING ON AN INTERSTATE, I HAVE HAD THE "WRENCH" LIGHT COME ON, ON THE DASH DISPLAY. THIS IS CAUSED BY ME USING THE CRUISE CONTROL, BUT WHEN I HIT THE BRAKE TO RELEASE THE CRUISE CONTROL, THEN STEP ON THE GAS PEDAL TO BRING IT BACK UP TO SPEED, THE LIGHT APPEARS AND I GO INTO "LIMP MODE". ONCE I PULL OVER AND STOP THE ENGINE, APPARENTLY THIS RE-SETS THE SYSTEM, AND THE VEHICLE DRIVES OKAY. I HAVE BEEN TOLD BY A FORD TECH THAT THIS IS THE ELECTRONIC THROTTLE CONTROL AND THAT IT MAY BE NORMAL, BUT I…

Owner-reported narrative. 14,500 miles reported. Look up ODI 10874818 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 FORD E-450. THE CONTACT STATED THAT THE AIR FILTER FAILED TO FUNCTION PROPERLY. THE PLASTIC CAP BECAME UNGLUED AND WAS SUCKED INTO THE INTAKE, PREVENTING AIR FROM ENTERING THE ENGINE. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. THE CONTACT, AN INDEPENDENT MECHANIC, REMOVED THE FRAM AIR FILTER TO DIAGNOSE AND REPAIR THE VEHICLE. THE AIR FILTER MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

Owner-reported narrative. 65,000 miles reported. Look up ODI 11091397 at NHTSA ↗

WHILE DRIVING STRAIGHT ON A CITY STREET AND AGAIN ON AN INTERSTATE, THE VEHICLE SHUT OFF. A DIAGNOSTIC REPORT DETERMINED THAT THE FUEL PUMP CIRCUIT WIRING HARNESS WAS BAD. THE VEHICLE HAS 23,000.

Owner-reported narrative. 22,500 miles reported. Look up ODI 11377857 at NHTSA ↗

Reported: 2011-04-20 (April 20, 2011)

FORD IS RECALLING CERTAIN MODEL YEAR 2011 E-150, E-250, E-350 AND E-450 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." IT MAY BE POSSIBLE THAT UNDER UNUSUALLY HIGH LOADS, SUCH AS DURING A CRASH, THE DRIVER POWER SEAT TRACK WORM GEAR MAY FRACTURE.

Consequence: IN THE EVENT OF A CRASH OR OTHER CIRCUMSTANCES OF SEVERE LOADING, THE WORM GEAR COULD FRACTURE AND ALLOW THE SEAT TO SHIFT UNRESTRAINED FORWARD OR BACKWARD INCREASING THE RISK AND/OR SEVERITY OF INJURIES TO THE DRIVER.

Remedy: DEALERS WILL INSPECT THE DRIVER'S SEAT TRACK ASSEMBLY, AND IF NECESSARY, REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Reported: 2011-05-31 (May 31, 2011)

ROUSH PERFORMANCE PRODUCTS IS RECALLING CERTAIN 2011 FORD E-SERIES VANS EQUIPPED WITH 5.4 OR 6.8 LITER ENGINES THAT HAVE BEEN ALTERED BY ROUSH TO OPERATE USING THE ROUSH LIQUID PROPANE AUTOGAS FUEL SYSTEM. A VALVE IN THE SYSTEM MAY HAVE BEEN MISMACHINED ALLOWING A PROPANE LEAK.

Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A VEHICLE FIRE.

Remedy: ROUSH WILL REPLACE THE DEFECTIVE VALVE WITH A CORRECTLY MACHINED ONE. ALL THE AFFECTED VEHICLES HAVE BEEN REPAIRED, THEREFORE, AN OWNER NOTIFICATION LETTER WILL NOT BE ISSUED FOR THIS CAMPAIGN. OWNERS MAY CONTACT ROUSH AT 1-734-466-6255.

Reported: 2011-08-26 (August 26, 2011)

Ford Motor Company (Ford) is recalling certain model year 2011 Ford E-150, E-250, E-350, and E-450 vehicles built from May 12, 2011, through May 26, 2011. Due to improper manufacturing conditions, some of the windshields may form bubbles after an extended time in hot temperatures. As such, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 205, "Glazing Materials."

Consequence: The presence of bubbles may hinder driver's visibility thereby increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect and replace the windshield if bubbles are present, free of charge. The recall began in January 2014. Owners may contact the Ford customer relationship center at 1-866-436-7332. Ford's recall campaign number is 11C20.

Reported: 2011-08-31 (August 31, 2011)

ROUSH IS RECALLING CERTAIN MODEL YEAR 2009-2011 FORD E-150, E-250, AND E-350 5.4L ENGIN VANS/WAGONS/CUTAWAYS, AND MODEL YEAR 2010-2011 FORD E-450 6.8L ENGINE CUTAWAY VEHICLES ALTERED BY ROUCH TO OPERATE USING THE ROUSH BRANDED CLEANTECH PROPANE AUTOGAS FUEL SYSTEM. THE FUEL RAILS INCLUDED IN THE KITS CONTAIN IMPROPERLY SEATED INJECTOR RETENTION CLIPS. THIS COULD RESULT IN LEAKAGE OF PROPANE AUTOGAS.

Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: ROUSH WILL NOTIFY OWNERS OF THE VEHICLES OF WHICH THE KITS WERE INSTALLED IN ORDER TO ARRANGE FOR FREE REPLACEMENT OF THE INJECTOR RETENTION CLIPS. THE SAFETY RECALL BEGAN ON SEPTEMBER 26, 2011. OWNERS MAY CONTACT ROUSH AT 1-734-466-6255.

Reported: 2012-12-12 (December 12, 2012)

Creative Bus Sales, Inc is recalling certain model year 2006-2011 Chevrolet and GMC C5500, and Ford E450, and Econoline 350 vehicles equipped with Braun wheelchair lifts. Over time, or with frequent use, the roll stop latches on the outer barrier of the lifts may become bent or misaligned.

Consequence: A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.

Remedy: Braun is conducting this recall on behalf of Creative Bus Sales. Braun will notify owners, and dealers will repair the vehicles free of charge. The recall began on November 23, 2012. Owners may contact Creative Bus at 1-888-633-8380 or Braun at 1-800-488-0359.

Reported: 2014-07-10 (July 10, 2014)

Roush Performance Products, Inc. (Roush) is recalling certain model year 2010-2012 Ford E-150 Wagons and Cargo Vans, E-250 Cargo Vans and Extended Cargo Vans, E-350 Wagons, Extended Wagons, Cargo Vans, and Extended Vans, and E-450 Cutaway models. These models were modified by Roush to be equipped with certain propane fuel system conversion kits manufactured January 2011 to August 2012 with an aluminum fuel line fitting. Due to a reaction between the different metals, the affected kits may develop a propane leak where the aluminum fuel line fitting contacts the brass supply valve housing.

Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.

Remedy: Roush will notify owners and will replace the aluminum fuel line fittings with new stainless steel fittings, free of charge. The recall began on September 1, 2014. Owners may contact Roush customer service at 1-800-597-6874.

Reported: 2014-09-24 (September 24, 2014)

Elkhart Coach (Elkhart) is recalling certain model year 2006-2014 Ford E-350 and Ford E-450 vehicles manufactured January 1, 2006, to May 1, 2014 and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Elkhart will notify owners to take the vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 1, 2014. Owners may contact Ricon customer service at 1-800-322-2884. Owners may also contact Elkhart customer service at 1-574-264-5179. This recall has been superseded by campaign 15V-768.

Reported: 2015-02-25 (February 25, 2015)

Farber Specialty Vehicles (Farber) is recalling various specialty vehicles modified by Farber and equipped with model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Farber will notify owners to take their vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on March 24, 2015. Owners may contact Farber customer service at 1-800-331-3188, or Ricon customer service at 1-800-322-2884. Farber's number for this recall is 14E-041.