2005 Ford E-450: complaints, problems and recalls

TRUCK LOST POWER AND STOPPED RUNNING. HAD TO BE TOWED INTO DEALERSHIP. THEY FOUND A SMALL PIN THAT LETS THE GEARS CHANGE BROKE AND ALSO THE TORQUE CONVERTER WENT OUT. FORD WOULD NOT SEND THEM A NEW TRANSMISSION AND MADE THEM REBUILD THE OLD ONE. TORQUE CONVERTER ON BACK ORDER - ESTIMATED DELIVERY DATE WAS FEBRUARY 25. OUR PROBLEM OCCURRED ON JANUARY 12. THE TRUCK ONLY HAD 3,600 MILES ON IT WHEN THIS HAPPENED. THIS IS TOTALLY UNACCEPTABLE. *NM

Owner-reported narrative. 3,688 miles reported. Look up ODI 10107673 at NHTSA ↗

2005 FORD CROWN VICTORIA (POLICE VEHICLE) PURCHASED JANUARY 14, 2005 WITH 600 MILES SUDDENLY ACCELLERATED WHILE THE OFFICER WAS STOPPED WITH HIS FOOT FIRMLY ON THE BRAKE. TOOK CRUISER OUT OF SERVICE AND HAD TOWED TO DEALER WHERE PURCHASED. A SECOND 2005 FORD CROWN VICTORIA PURCHASED ON JANUARY 14, 2005 (APPROX. 550 MILES)DID THE SAME THING BY ACCELLERATING WITHOUT PUTTING FOOT ON THE ACCELLERATOR PEDAL. IN THE SECOND INCIDENT, THE VEHICLE LURCHED CAUSING DAMAGE TO THE LEFT FRONT DRIVERS DOOR. TOND VEHICLE WAS ALSO PUT OUT OF SERVICE AND TO…

Owner-reported narrative. 550 miles reported. Look up ODI 10108367 at NHTSA ↗

I OWN A 2005 F350 POWER STROKE DIESEL PICKUP AND HAVE BEEN THROUGHLY DISCOURAGED BY FORD LACK OF ADMISSION TO THE ENGINE PROBLEMS. I HAVE NOT BEEN INVOLVED IN AN ACCIDENT, HOWEVER, I FEEL THAT THE CONSUMER NEEDS TO KNOW THE PROBLEMS WITH THE 6.0 LITRE POWERSTROKE. I HAVE HEARD MANY STORIES OF CONSUMER PROBLEMS AND YET FORD DENIES THE PROBLEMS. I THINK THAT FORD IS TRYING TO MAKE A "SILENT RECALL" BECAUSE A FULL RECALL WILL HURT THEM FINANCIALLY. PLEASE INVESTIGATE AS TO THE PROBLEMS WITH THIS ENGINE.*AK

Owner-reported narrative. 7,500 miles reported. Look up ODI 10114264 at NHTSA ↗

DT: THIS IS MOTOR HOME, HAD A STEERING PROBLEM. TURNED LEFT AND ABOUT 5 MINUTES LATER THE STEERING PULLED TO THE LEFT, HAD TO TURN HARD RIGHT IN ORDER TO GET IT TO GO STRAIGHT. IT DID THIS FOR ABOUT 3 MILES. SUDDENLY SOMETHING IN THE STEERING LET IT JERK VIOLENTLY TO THE LEFT, ALMOST CONSUME R LOST CONTROL OF THE VEHICLE BUT IT WENT BACK TO NORMAL FOR THE NEXT 400 MILES. THIS HAPPENED ON JULY 26, 2005. THE FORD DEALERWAS GOING TO LOOK AT THIS ON MONDAY.*AK

Owner-reported narrative. 5,000 miles reported. Look up ODI 10130554 at NHTSA ↗

VEHICLE LOST POWER AND STOPPED RUNNING WHILE MOVING AT A SPEED OF 55 MPH. VEHICLE DANGEROUSLY SKID TO A COMPLETE STOP IN THE MIDDLE OF A BUSY HIGHWAY, UNABLE TO DRIVE ONTO SHOULDER. HAD TO BE TOWED INTO DEALERSHIP. VEHICLE PURCHASED ON 06/14/2005 FOR $58,000, INCIDENT HAPPENED 07/08/2005, AND VEHICLE IS STILL IN SHOP AS OF 08/01/2005. THE VEHICLE ONLY HAD 3,700 MILES ON IT WHEN THIS HAPPENED. DEALERSHIP SAID THE TORQUE CONVERTER WENT OUT. THIS VEHICLE WAS TO BE USED TO TRANSPORT TOURIST SAFELY TO AND FROM OUR TOUR LOCATION. I PURCHASED THIS NEW…

Owner-reported narrative. 3,700 miles reported. Look up ODI 10130747 at NHTSA ↗

FORD F150 2005 REAR AXLE OR DRIVE TRAIN SLIPS AND KNOCKS ON ACCELERATION AND AROUND CORNERS. DEALER SAID PROBLEM WAS FIXED WITH MORE GREASE IN REAR AXLE. PROBLEM STILL EXSISTS.*JB

Owner-reported narrative. Look up ODI 10131192 at NHTSA ↗

WE RENTED A 2005 MERCURY MOUNTAINEER FROM HERTZ RENTAL. WHILE DRIVING, THE REAR WINDOW IN THE HATCHBACK KEPT OPENING. WE STOPPED REPEATEDLY TO CLOSE THE WINDOW. WE WERE ON VACATION TRAVELING FROM SOUTHERN CALIFORNIA TO YELLOWSTONE NATIONAL PARK. EVENTUALLY, WE BOUGHT SOME DUCT TAPE AND TAPED THE WINDOW SHUT SO THAT IT WOULD NOT OPEN ANYMORE; HOWEVER, IT DID BECOME AJAR, BUT LUCKILY THE TAPE HELD THE WINDOW CLOSED. WE WERE FORTUNATE THAT NOTHING FLEW OUT THE WINDOW (WHAT IF A PERSON WAS SITTING IN THE REAR SEAT AND GOT INJURED...????).*JB

Owner-reported narrative. Look up ODI 10134401 at NHTSA ↗

2005 E450 SUPER DUTY VAN STALLED RESULTING IN A AUTO CRASH WITH SERIOUS INJURIES. *TS ATTORNEY IS INVESTIGATING AN ACCIDENT ON BEHALF OF AN INJURED PASSENGER WHO WAS RIDING IN THE VEHICLE THAT CRASHED HEAD ON INTO A LIGHT POLE AFTER THE VEHICLE STALLED AND LOST POWER STEERING. THE ATTORNEY FOUND RECALL 05S34 WHICH INDICATED THAT THE FUEL INJECTOR CONTROL MODULE (FICM) WIRE HARNESS MAY CHAFE ON ENGINE BOLT POTENTIALLY RESULTING IN ELECTRIC SHORT. THE ATTORNEY IS TRYING TO DETERMINE IF THE PREVIOUS OWNER OR OPERATOR EVER RECEIVED THE RECALL, …

Owner-reported narrative. Look up ODI 10148705 at NHTSA ↗

Reported: 2004-12-20 (December 20, 2004)

CERTAIN CUT-AWAY INCOMPLETE TRUCKS EQUIPPED WITH LT225/75R16E TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES.

Consequence: AT THE INCORRECTLY STATED PRESSURE, THE REAR TIRES ARE UNABLE TO SUPPORT THE GROSS AXLE WEIGHT RATING (GAWR) FOR THE REAR AXLE.

Remedy: OWNERS AND DEALERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT REAR TIRE INFLATION INFORMATION. THE RECALL BEGAN ON JANUARY 11, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.

Reported: 2005-06-10 (June 10, 2005)

CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.

Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.

Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Reported: 2008-10-06 (October 6, 2008)

MOBILITYWORKS IS RECALLING 133 MY 2005-2006 FORD E250, MY 2000, 2004-2006 E350, MY 2000, 2005 E450, MY 2005-2006 GMC 2500, GMC 3500, AND MY 2006 DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: MOBILITYWORKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITYWORKS AT 1-800-769-8267.

Reported: 2008-12-04 (December 4, 2008)

NEW YORK BUS SALES IS RECALLING 1 RICON WHEELCHAIR LIFT WHICH IT INSTALLED ON A FORD SCHOOL BUS, MODEL E450. THE VEHICLE FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: NEW YORK BUS SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW YORK BUS SALES AT 1-315-687-3969.

Reported: 2008-12-05 (December 5, 2008)

NEW YORK BUS SALES IS RECALLING 1 RICON WHEELCHAIR LIFT WHICH IT INSTALLED ON A FORD SCHOOL BUS, MODEL E450. THE VEHICLE FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: NEW YORK BUS SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW YORK BUS SALES AT 1-315-687-3969.

Reported: 2019-05-29 (May 29, 2019)

VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.

Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.

Remedy: VCI Emergency Vehicle Specialists will work with ASA to notify the owners, and remedy the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics at 1-800-384-4400.