Cadillac DEVILLE recalls by model year

Reported: 1973-11-23 (November 23, 1973) · Model years: 1971, 1972

Reported: 1972-09-11 (September 11, 1972) · Model years: 1972

Reported: 1974-06-21 (June 21, 1974) · Model years: 1974

Reported: 1978-08-30 (August 30, 1978) · Model years: 1977, 1978

IF PAPER OR OTHER COMBUSTIBLE MATERIALS ARE PLACED IN THE INSTRUMENT PANEL ASHTRAY RECEPTACLE, THEY COULD BECOME IGNITED AND FLAMES FROM THE FIRE MAY REACH THE INTERIOR OF THE INSTRUMENT PANEL.

Remedy: OWNER WILL BE SENT A METAL HEAT SHIELD TO BE INSTALLED ABOVE THE INSTRUMENT PANEL, EITHER BY THE OWNER OR BY THE DEALER.

Reported: 1979-05-04 (May 4, 1979) · Model years: 1977, 1978

THE INVOLVED VEHICLES WERE BUILT WITH AN ACCELERATOR PEDAL HAVING AN EXTENSION, OR RUBBER FLAP, AT THE BOTTOM OF THE PEDAL. THIS PEDAL FLAP COULD BE INADVERTENTLY DISPLACED BY A FLOOR COVERING AND WEDGED UNDER THE ACCELERATOR PEDAL IN A MANNER THAT CAN INFLUENCE THE THROTTLE SETTING AND INCREASE THE ENGINE IDLE RPM.

Remedy: THE DEALER WILL REMOVE THE RUBBER FLAP FROM THE ACCELERATOR.

Reported: 1977-09-26 (September 26, 1977) · Model years: 1978

SOME OF THE INVOLVED VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS". THE WINDSHIELD WASHER BOTTLE ON THE INVOLVED VEHICLES MAY CRACK AND ALLOW WASHER FLUID TO DRAIN OUT.

Remedy: DEALER WILL INSPECT THE WASHER BOTTLE AND, IF NECESSARY, REPLACE IT WITHOUT CHARGE TO OWNER.

Reported: 1977-11-16 (November 16, 1977) · Model years: 1978

THE REAR WHEEL MOUNTING BOLTS ON THE AFFECTED VEHICLES, ARE BRITTLE AND THEREFORE MAY FRACTURE. THIS BRITTLENESS IS DUE TO IMPROPER HEAT TREATMENT DURING MANUFACTURE. IF THE BOLTS BREAK, THE TIRE AND WHEEL ASSEMBLY MAY SEPARATE FROM THE VEHICLE.

Remedy: DEALER WILL INSPECT AND, IF NECESSARY, WILL REPLACE DEFECTIVE BOLTS ON ALL AXLES AND THE TEN REAR AXLE WHEEL MOUNTING BOLTS, FREE OF CHARGE.

Reported: 1979-11-13 (November 13, 1979) · Model years: 1979

THE HEADS MAY BREAK OFF THE FRONT OUTBOARD SEAT BELT ANCHOR BOLTS DURING NORMAL VEHICLE OPERATION EVEN UNDER NO LOAD CONDITIONS. THIS IS DUE TO THE COMBINATION OF BOLTS USED, HIGH INSTALLATION TORQUE AND ARRANGEMENT OF THE BODY ANCHORAGE.

Remedy: DEALER WILL REPLACE ALL ORIGINAL EQUIPMENT FRONT OUTBOARD SEAT BELT ANCHOR BOLTS ON THE AFFECTED VEHICLES AT NO COST TO OWNER.

Reported: 1982-01-03 (January 3, 1982) · Model years: 1982

UNDER CERTAIN VEHICLE OPERATING CONDITIONS, THE GOVERNOR WEIGHT RETAINER IN THE INJECTION PUMP MAY FAIL. THE THROTTLE VALVE COULD STICK, PREVENTING RETURN TO IDLE AND SHUT DOWN OF THE ENGINE BY THE DRIVER.

Remedy: DEALER WILL REPLACE THE GOVERNOR WEIGHT ASSEMBLY IN THE INJECTION PUMP AT NO COST TO OWNER.

Reported: 1984-05-21 (May 21, 1984) · Model years: 1985

OMISSION OF THE CERTIFICATION LABELS AS REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 110 "TIRE SELECTION AND RIMS".

Remedy: DEALER WILL INSTALL REQUIRED CERTIFICATION LABELS.

Reported: 1986-04-28 (April 28, 1986) · Model years: 1986

THE PUSH-PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING. NOTE: ALSO, SEE NHTSA CAMPAIGN NUMBER 86V131000.

Remedy: REPLACE HEADLIGHT SWITCH AS NECESSARY.

Reported: 1987-06-23 (June 23, 1987) · Model years: 1986, 1987

THE ANTI LOCK BRAKE SYSTEM (ABS) PRESSURE/WARNING SWITCH MAY EXHIBIT BRAKE FLUID SEEPAGE WHICH EVENTUALLY CAN LEAD TO LOSS OF THE BRAKE SYSTEM HYDRAULIC PUMP MOTOR. ADDITIONALLY, THE HYDRAULIC PUMP MOTOR AND ABS ELECTRICAL RELAYS MAY HAVE BEEN EXPOSED TO WATER CONTAMINATION DURING VEHICLE ASSEMBLY. THIS CONDITION CAN CAUSE LOSS OF THE HYDRAULIC PUMP MOTOR AND/OR LOSS OF THE ABS FUNCTION.

Consequence: LOSS OF THE HYDRAULIC PUMP MOTOR WOULD RESULT IN A TOTALLOSS OF REAR BRAKES AS WELL AS POWER ASSIST TO THE FRONT BRAKES. THE RED BRAKEWARNING LIGHT WOULD ILLUMINATE AND STAY ON. IF THIS WARNING IS NOT HEEDED, ALOSS OF REAR BRAKES AT A TIME WHEN MINIMUM STOPPING DISTANCE IS REQUIRED COULDRESULT IN A VEHICLE CRASH. AN INOPERATIVE ABS ELECTRICAL RELAY COULD CAUSELOSS OF THE ABS FUNCTION, BUT NORMAL POWER ASSISTED BRAKING WOULD BE RETAINED.THE AMBER ANTI LOCK WARNING LIGHT WOULD ILLUMINATE AND STAY ON.

Remedy: THE ABS AND HYDRAULIC PUMP MOTOR ELECTRICAL RELAYS AND 30 AMP FUSES WILL BE REPLACED. IN ADDITION, THE HYDRAULIC PUMP MOTOR ASSEMBLY AND PRESSURE/WARNING SWITCH WILL BE INSPECTED AND, IF REQUIRED, REPLACED.

Reported: 1994-10-13 (October 13, 1994) · Model years: 1991, 1992, 1993

THE UPPER TRANSAXLE OIL COOLER HOSE CAN PULL OUT OF THE CRIMPED COUPLING AT THE TRANSAXLE END OF THE LINE ASSEMBLY.

Consequence: IN THE EVENT OF SEPARATION OF THE COUPLING, AN OIL LEAK CAN OCCUR WHICH, WHEN EXPOSED TO AN IGNITION SOURCE, COULD RESULT IN AN ENGINE COMPARTMENT FIRE.

Remedy: DEALERS WILL INSTALL A NEW UPPER TRANSAXLE OIL COOLER LINE TO THE TRANSAXLE.

Reported: 2004-03-04 (March 4, 2004) · Model years: 1995, 1996, 1997

SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.

Reported: 1998-05-26 (May 26, 1998) · Model years: 1995

VEHICLE DESCRIPTION: PASSENGER VEHICLES. INADVERTENT DEPLOYMENT OF THE AIR BAGS CAN OCCUR DUE TO WATER INTRUSION.

Consequence: DEPLOYMENT OF THE AIR BAG WITHOUT WARNING COULD CAUSE A DRIVER TO LOSE VEHICLE CONTROL INCREASING THE RISK OF A VEHICLE CRASH AND PERSONAL INJURY.

Remedy: DEALERS WILL CLEAN THE EXTERIOR CASE OF THE SENSING AND DIAGNOSTIC MODULE (SDM) AND APPPLY A POTTING COMPOUND TO THE SDM CASE AND ELECTRICAL CONNECTOR BODY.

Reported: 1995-12-05 (December 5, 1995) · Model years: 1996

THESE VEHICLES COULD HAVE BEEN PRODUCED WITH AN IMPROPERLY ADJUSTED SECONDARY HOOD LATCH. THIS DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 113, "HOOD LATCH SYSTEM."

Consequence: CONSEQUENCE OF NON-COMPLIANCE: IF THE SECONDARY LATCH IS NOT PROPERLY ENGAGED AND THE PRIMARY HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD LATCH WAS ALSO NOT ENGAGED, THE HOOD COULD OPEN UNEXPECTEDLY. IF THIS WERE TO OCCUR WHILE THE VEHICLE IS IN MOTION, THE HOOD CAN CONTACT THE WINDSHIELD REDUCING THE VISION OF THE DRIVER AND INCREASING THE RISK OF A VEHICLE ACCIDENT.

Remedy: DEALERS WILL ADJUST THE SECONDARY HOOD LATCH.

Reported: 1997-04-28 (April 28, 1997) · Model years: 1997

THE ELECTRONIC BRAKE CONTROL MODULE OR THE ELECTRONIC BRAKE AND TRACTION CONTROL MODULE CAN CAUSE THE ANTILOCK BRAKE SYSTEM (ABS) TO CYCLE DURING A NON-ABS BRAKE APPLICATION.

Consequence: THIS CONDITION CAN RESULT IN AN INCREASE IN VEHICLE STOPPING DISTANCE INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE ELECTRONIC BRAKE CONTROL MODULE OR THE ELECTRONIC BRAKE AND TRACTION CONTROL MODULE.

Reported: 2000-08-11 (August 11, 2000) · Model years: 1998, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THE SIDE IMPACT SENSOR MODULES HAVE QUALITY PROBLEMS THAT CAN CAUSE AN INADVERTENT DEPLOYMENT OF THE DRIVER OR PASSENGER SIDE IMPACT AIR BAGS. THESE SIDE AIR BAGS DEPLOY WITH LESS FORCE THAN A FRONTAL AIR BAG AND ARE DESIGNED TO MINIMIZE THE RISK OF SERIOUS INJURY.

Consequence: HOWEVER, AN OCCUPANT CAN RECEIVE SOME INJURY FROM A DEPLOYMENT.

Remedy: DEALERS WILL REPLACE THE DRIVER AND PASSENGER SIDE IMPACT SENSING MODULES. IF THE VEHICLE HAS HAD THE SIDE AIR BAGS TEMPORARILY DISCONECTED, THE TEMPORARY DISCONNECT WILL BE REMOVED BEFORE REPLACING THE SIDE IMPACT SENSING MODULES.

Reported: 1997-10-27 (October 27, 1997) · Model years: 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES, HEARSES AND LIMOUSINES. THE CANISTER PURGE EVAPORATIVE EMISSIONS HARNESS ON THESE VEHICLES WAS MISROUTED.

Consequence: THE HARNESS COULD INTERFERE WITH THE CRUISE CONTROL AND THROTTLE LINKAGE PREVENTING RETURN TO A CLOSED THROTTLE.

Remedy: DEALERS WILL INSPECT THE VEHICLE FOR PROPER ROUTING OF THE HARNESS, CORRECT AS NECESSARY, AND INSTALL A PLASTIC TIE STRAP TO THE HARNESS.

Reported: 1997-12-18 (December 18, 1997) · Model years: 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH HOOD HINGE PIVOT BOLTS WHICH CAN BREAK DUE TO AN IMPROPER HEAT TREAT CONDITION. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 219, "WINDSHIELD ZONE INTRUSION." A BROKEN BOLT CAN CAUSE EITHER THE CORNER OF THE HOOD NEAR THE WINDSHIELD TO RAISE, OR ONE SIDE OF THE HOOD TO BE UNSTABLE WHEN OPENED.

Consequence: IN THE EVENT OF A VEHICLE CRASH, THE HOOD COULD BE PUSHED BACK THROUGH THE WINDSHIELD GLASS POSSIBLY INJURING THE VEHICLE OCCUPANTS.

Remedy: DEALERS WILL REPLACE THE HOOD HINGE PIVOT BOLTS.

Reported: 2000-01-26 (January 26, 2000) · Model years: 2000

VEHICLE DESCRIPTION: LIMOUSINES. DURING NORMAL ENGINE ROLL, THE PLASTIC END FITTING OF THE CRUISE CONTROL CABLE COULD CONTACT THE BRAKE MASTER CYLINDER AND FRACTURE. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS."

Consequence: THE FRACTURE COULD PREVENT FULL CLOSING OF THE THROTTLE AND CAUSE A SMALL INCREASE IN ENGINE RPM IN DRIVE WITH THE BRAKE APPLIED.

Remedy: DEALERS WILL INSTALL A NEW CRUISE CONTROL BRACKET AND, IF NECESSARY, WILL REPLACE THE CRUISE CONTROL CABLE.

Reported: 2000-04-17 (April 17, 2000) · Model years: 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES HAVE INTERNAL FLUID LEAKS IN THE BRAKE HYDRAULIC CONTROL UNIT.

Consequence: WHEN THE REAR BRAKE PROPORTIONING, ANTILOCK BRAKE, TRACTION CONTROL, OR STABILITY CONTROL FEATURE IS ACTIVATED IN SOME DRIVING SITUATIONS, THE FEATURE MAY NOT PERFORM AS DESIGNED.

Remedy: DEALERS WILL INSPECT THE ABS HYDRAULIC MODULATOR UNIT AND IF NECESSARY, REPLACE THE HYDRAULIC MODULATOR.

Reported: 2000-10-30 (October 30, 2000) · Model years: 2000, 2001

VEHICLE DESCRIPTION: PASSENGER VEHICLES, HEARSE, AND LIMOUSINES. SOME OF THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THESE VEHICLES HAVE SEAT BELTS THAT MAY NOT MEET THE 30-POUND PUSH BUTTON RELEASE EFFORT REQUIREMENT OF THE STANDARD.

Consequence: HIGH RELEASE EFFORTS COULD MAKE IT MORE DIFFICULT FOR A CRASH VICTIM TO RELEASE THE BELT AND EXIT THE VEHICLE.

Remedy: DEALERS WILL INSPECT THE SEAT BELTS AND, IF NECESSARY, MODIFY THE LATCH PLATES OR REPLACE THE RETRACTOR. DEALERS WILL ALSO ADD "SNAP ON" LATCH CLIPS TO ELIMINATE THE POTENTIAL OF INVERTED LATCH PLATE INSERTION. OWNER NOTIFICATION IS BEING CONDUCTED IN PHASES. THE FIRST PHASE BEGAN MAY 29, 2001, AND THE SECOND PHASE BEGAN JULY 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006.

Reported: 2002-09-05 (September 5, 2002) · Model years: 2000, 2001, 2002

CERTAIN PASSENGER VEHICLES CONTAIN DRIVER AND FRONT PASSENGER LAP AND/OR SHOULDER BELT RETRACTORS THAT MAY NOT REMAIN LOCKED UP AS DESIGNED DURING A CRASH IN WHICH THE BELT PRETENSIONERS DEPLOY.

Consequence: IN SUCH A CRASH, THIS COULD RESULT IN AN INCREASE IN INJURY FOR THAT OCCUPANT.

Remedy: DEALERS WILL INSTALL A RETAINER KIT IN THE DRIVER AND PASSENGER SAFETY BELT PRETENSIONER. OWNER NOTIFICATION BEGAN JANUARY 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006.

Reported: 2014-06-23 (June 23, 2014) · Model years: 2000, 2001, 2002, 2003, 2004, 2005

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.

Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 23, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), and 1-800-222-1020 (Chevrolet). GM's number for this recall is 14299.

Reported: 2001-05-23 (May 23, 2001) · Model years: 2001

VEHICLE DESCRIPTION: CERTAIN SEDANS, HEARSE, AND LIMOUSINE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THESE VEHICLES HAVE SUNVISOR CENTER SUPPORTS WITH CERTAIN RADII LESS THAN THE 3.2MM REQUIRED BY THE STANDARD.

Consequence: RADII LESS THAN 3.2MM CAN INCREASE THE POSSIBILITY OF CERTAIN TYPES OF INJURIES, LIKE LACERATIONS, IF AN OCCUPANT CONTACTS THE SUPPORT DURING A CRASH.

Remedy: DEALERS WILL REPLACE THE SUNVISOR CENTER SUPPORTS WITH REDESIGNED SUPPORTS. OWNER NOTIFICATION BEGAN NOVEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006.

Reported: 2002-03-06 (March 6, 2002) · Model years: 2002

CERTAIN PASSENGER VEHICLES WERE BUILT WITH MISSING OR UNDER-TORQUED STEERING GEAR ATTACHMENT BOLTS. IF A BOLT IS MISSING, THE DRIVER MAY NOTICE UNEVEN STEERING RESPONSE OR UNUSUAL NOISES DURING TURNS.

Consequence: IF THE LEFT BOLT IS MISSING AND THE RIGHT MOUNTING STRAP FAILS, STEERING CONTROL IS LOST AND A VEHICLE CRASH COULD RESULT.

Remedy: DEALERS WILL INSPECT THE VEHICLES FOR PRESENCE AND PROPER TORQUE OF BOTH STEERING GEAR BOLTS. OWNER NOTIFICATION BEGAN APRIL 5, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300 OR CADILLAC AT 1-800-458-8006.

Reported: 2002-08-09 (August 9, 2002) · Model years: 2002, 2003

CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.

Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.

Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.

Reported: 2003-07-01 (July 1, 2003) · Model years: 2002, 2003

ON CERTAIN CADILLAC DEVILLE AND SEVILLE PASSENGER VEHICLES, FUNERAL COACHES, AND LIMOUSINES EQUIPPED WITH A V8 (4.6L) ENGINE, OLDSMOBILE AURORA PASSENGER VEHICLES EQUIPPED WITH A V8 (4.0L ) ENGINE, AND PONTIAC BONNEVILLE SSEI PASSENGER VEHICLES EQUIPPED WITH A SUPERCHARGED V6 (3.8L) ENGINE, THE FUEL TANK PRESSURE SENSORS ARE UNUSUALLY SUSCEPTIBLE TO MALFUNCTIONS. IF THE SENSOR MALFUNCTIONS, EXCESSIVE VACUUM CAN BE APPLIED DURING SELF-DIAGNOSTIC TESTING.

Consequence: FUEL SYSTEM COMPONENTS CAN BE DAMAGED AND FUEL CAN LEAK FROM THE VEHICLE WHEN IT IS REFUELED. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL TANK PRESSURE SENSOR. OWNER NOTIFICATION BEGAN ON OCTOBER 17, 2003. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.

Reported: 2003-02-14 (February 14, 2003) · Model years: 2003

ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.

Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.

Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.