Tiffin PHAETON recalls by model year

Reported: 2001-06-22 (June 22, 2001) · Model years: 2000, 2001

VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.

Consequence: SERIOUS INJURY OR DEATH COULD OCCUR IF THE VEHICLE OCCUPANT IS NOT PROPERLY RESTRAINED.

Remedy: AM-SAFE NOTIFIED TIFFIN'S CUSTOMERS TO RETURN THEIR VEHICLE TO AN AUTHORIZED DEALER TO HAVE THE SEAT BELTS REPAIRED FREE OF CHARGE. OWNER NOTIFICATION BEGAN AUGUST 31, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AM-SAFE COMMERCIAL PRODUCTS AT 219-266-8330.

Reported: 2007-11-05 (November 5, 2007) · Model years: 2000, 2001, 2002, 2003, 2004

ON CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THESE REFRIGERATORS MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: TIFFIN MOTORHOMES WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 1-256-356-8661.

Reported: 2011-02-08 (February 8, 2011) · Model years: 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2010, 2011

TIFFIN MOTORHOMES IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: TIFFIN MOTORHOMES IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.

Reported: 2009-11-17 (November 17, 2009) · Model years: 2002, 2003

TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLE EQUIPPED WITH NORCOLD MODEL 1200LR AND 1200LRIM REFRIGERATORS, MANUFACTURED FROM DECEMBER 1, 2001, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Remedy: TIFFIN IS WORKING WITH NORCOLD AND TIFFIN WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE BY NORCOLD. PLEASE SEE NORCOLD'S DEFECT REPORT 09E-027. OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.

Reported: 2004-08-03 (August 3, 2004) · Model years: 2004, 2005

THE SEAT BELT ASSEMBLIES ON CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE LOOP LOAD REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209. "SEAT BELT ASSEMBLIES."

Consequence: THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

Remedy: AMSAFE WILL REPLACE THE BUCKLES. OWNERS SHOULD CONTACT AMSAFE AT 574-266-8330 OR TIFFIN AT 1-256-356-8661.

Reported: 2005-06-03 (June 3, 2005) · Model years: 2004

ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.

Consequence: THE SURFACE TEMPERATURE OF THE EXHAUST TUBE EXITING FROM THE HEATER CAN INCREASE AND COULD POTENTIALLY IGNITE COMBUSTIBLE MATERIALS IN OR AROUND THE VEHICLE.

Remedy: TIFFIN IS WORKING WITH VEHICLE SYSTEMS TO NOTIFY OWNERS AND HAVE THE REPAIR PERFORMED ON THEIR VEHICLES. OWNERS MAY CONTACT VEHICLE SYSTEMS AT 1-800-685-4298 OR TIFFIN AT 256-356-8661.

Reported: 2008-10-07 (October 7, 2008) · Model years: 2004, 2005

TIFFIN IS RECALLING 3,507 MY 2004-2007 ALLEGRO, ALLEGRO BAY AND ALLERO BUS, MY 2004-2005 PHAETON AND MY 2005-2007 ZEPHYR MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy: TIFFIN WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 256-356-8661.

Reported: 2005-04-12 (April 12, 2005) · Model years: 2005

ON CERTAIN RECREATIONAL VEHICLES, THE WASHER/DRYER IN THE REAR OF THE MOTOR HOME CAN MOVE.

Consequence: A VEHICLE OCCUPANT COULD BE INJURED IF THE WASHER/DRYER MOVED.

Remedy: TIFFIN HAS PROVIDED THE OWNERS WITH A REPAIR KIT AND INSTALLATION INSTRUCTIONS. THE RECALL BEGAN ON JANUARY 7, 2005. OWNERS MAY CONTACT TIFFIN AT 1-256-356-0205.

Reported: 2005-07-05 (July 5, 2005) · Model years: 2005

ON CERTAIN MOTOR HOMES CONTAINING A 50 AMP TRANSFER SWITCH BUILT BY INTELLITEC, THE MATERIAL USED FOR THE WIRE LUGS WAS CHANGED FROM NICKEL PLATED TO COPPER LUGS. THE COPPER LUGS ARE SOFTER THAN THE NICKEL PLATED AND DO NOT RETAIN THE TORQUE OF THE SCREW THAT CLAMPS THE WIRE CONNECTOR.

Consequence: WHEN THE TORQUE IS RELAXED, THE LUGS CAN BECOME LOOSE RESULTING IN EXCESSIVE HEAT WITHIN THE CONNECTED WIRE THAT COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE CHANGEOVER BOX. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661.

Reported: 2007-08-15 (August 15, 2007) · Model years: 2007, 2008

ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence: EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy: THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Reported: 2008-08-01 (August 1, 2008) · Model years: 2007, 2008

TIFFIN IS RECALLING 271 MY 2007-2008 PHAETON CLASS A MOTOR HOMES EQUIPPED WITH FREIGHTLINER CHASSIS. THE AAC FRONT AXLE STEERING ARM BOLTS WITH A LATCH LEVER PIVOT BOLT ASSEMBLY MAY HAVE BEEN OVER- TIGHTENED.

Consequence: OVER-TIGHTENED STEERING ARM BOLTS MAY FATIGUE AND FRACTURE INCREASING THE RISK OF A CRASH.

Remedy: TIFFIN IS WORKING WITH FREIGHTLINER TO HAVE THE STEERING ARM TIE ROD FASTENERS INSPECTED AND REPLACED. THE STEERING ARM WILL BE INSPECTED FOR CLEARANCE TO THE KING PIN BOSS. FREIGHTLINER IS HANDLING THE REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.

Reported: 2009-02-27 (February 27, 2009) · Model years: 2007, 2008, 2009

TIFFIN IS RECALLING 1,408 MY 2006-2009 ALLEGRO BUS, MY 2007-2009 PHAETON AND MY 2005-2009 ZEPHYR VEHICLES BUILT ON SPARTAN CHASSIS AND EQUIPPED WITH PUTMAN HITCHES. CERTAIN TRAILER HITCHES MAY FRACTURE WHICH COULD RESULT IN THE LOSS OF THE TRAILER.

Consequence: SUSPECT HITCHES MAY DEVELOP FRACTURES AND SUBSEQUENT SEPARATION MAY OCCUR, RESULTING IN A VEHICLE CRASH, PROPERTY DAMAGE OR PEDESTRIAN HARM.

Remedy: TIFFIN IS WORKING WITH SPARTAN AND SPARTAN IS HANDLING THE REMEDY FOR THIS CAMPAIGN (PLEASE SEE 08V-567). THE TRAILER HITCH WILL BE REPLACED FREE OF CHARGE. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400 OR TIFFIN AT 256-356-8661.

Reported: 2010-11-22 (November 22, 2010) · Model years: 2007, 2008, 2009, 2010

TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: TIFFIN IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR TIFFIN AT 1-256-356-8661.

Reported: 2011-08-25 (August 25, 2011) · Model years: 2007, 2008, 2009, 2010, 2011

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2007-2011 PHAETON, MY 2008-2010 BUS, AND MY 2010 ALLEGRO MOTORHOMES EQUIPPED WITH KONGSBERG AUTOMOTIVE ADJUSTABLE BRAKE PEDALS. THE ADJUSTABLE BRAKE PEDAL ARM MAY LOOSEN ALLOWING THE ARM TO ROTATE AROUND ITS SHAFT AND SWING IN FRONT OF THE ACCELERATOR PEDAL, REDUCING BRAKING FUNCTION.

Consequence: A LOOSE BRAKE PEDAL INCREASES THE RISK OF A CRASH.

Remedy: DAMILER TRUCKS (DTNA) IS PERFORMING RECALL REPAIRS AND NOTIFICATION TO OWNERS. THE OWNERS WERE INITIALLY NOTIFIED BY DTNA TRUCKS ON DECEMBER 22, 2009, AND A FOLLOW UP NOTICE WAS MAILED TO OWNERS ON JULY 20, 2011. OWNERS MAY CONTACT DTNA WARRANTY CLAIMS DEPARTMENT AT 1-800-547-0712 OR TIFFIN MOTORHOMES AT 1-256-356-8661 FOR MORE INFORMATION.

Reported: 2016-07-13 (July 13, 2016) · Model years: 2007, 2008, 2009, 2010, 2011

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2007-2011 Allegro, Allegro Bus, Phaeton, and Zephyr motorhomes, 2007-2010 Allegro Bay motorhomes, and 2010-2011 Allegro Breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.

Consequence: If the windshield wiper arms break, the driver's visibility may be reduced, increasing the risk of a crash.

Remedy: Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The recall began on August 19, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-100.

Reported: 2008-06-17 (June 17, 2008) · Model years: 2008, 2009

DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

Consequence: IF THE WELD FAILS, VEHICLE STABILITY WHILE CORNERING COULD BE AFFECTED RESULTING IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A CRASH. IN ADDITION, THE TRANSVERSE BEAM COULD DROP TO THE GROUND CAUSING SPARKS THAT COULD CAUSE A FIRE HAZARD.

Remedy: DAIMLER TRUCKS IS WORKING WITH SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08E031). THE RECALL RECALL BEGAN ON SEPTEMBER 12, 2008 (THOMAS BUILT BUSES) AND OCTOBER 8, 2008. OWNERS MAY CONTACT SAF-HOLLAND AT 1-231-773-3271 OR DAIMLER TRUCKS AT 1-800-547-0712.

Reported: 2014-05-22 (May 22, 2014) · Model years: 2008, 2009, 2010, 2011

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2009-2011 Allegro, 2010-2011 Bus and Breeze, and 2008-2011 Phaeton and Zephyr recreational vehicles, equipped with LED clearance lights made by Command Electronics, Inc. In the affected vehicles, moisture may enter the light and cause a short between two connections on the circuit board.

Consequence: A short in the circuit board increases the risk of a fire.

Remedy: Tiffin will notify owners, and dealers will install a one amp inline fuse into the front and rear circuits that will blow if there is a short in any of the clearance lights, free of charge. The recall began on July 31, 2014. Owners may contact Tiffin customer service at 1-256-356-8661.

Reported: 2015-12-28 (December 28, 2015) · Model years: 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015

Tiffin Motorhomes (Tiffin) is recalling certain model year 2007-2015 motorhomes manufactured May 1, 2007, to December 31, 2014, equipped with certain Coachstep Double and Triple Electric Steps. The bolt that attaches the fan gear assembly to the steps may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may become unstable.

Consequence: Unstable entry and exit steps increase the risk of injury.

Remedy: Dealers will install a retainer bracket on the double step assemblies and the Coachstep Linkage Assembly will be replaced and a retainer bracket will be installed on the trip step assemblies. The recall began on Ferbuary 10, 2016. Owners may contact Tiffin customer service at 1-256-356-8661, or Lippert customer service at 1-574-537-8900.

Reported: 2017-12-22 (December 22, 2017) · Model years: 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016, 2017, 2018

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2009-2018 Allegro and Allegro RED, Bus and Phaeton vehicles, 2009-2010 Bay vehicles, 2011-2018 Breeze vehicles, and 2009-2015, and 2017-2018 Zephyr vehicles. These motorhomes are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Tiffin will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on February 5, 2018. Owners may contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Owners may also contact Tiffin customer service at 1-256-356-8661.

Reported: 2011-08-08 (August 8, 2011) · Model years: 2010, 2011, 2012

TIFFIN IS RECALLING CERTAIN MODEL YEAR 2010-2012 PHAETON MOTORHOMES WITH FLOOR PLANS QBH, QKH, AND QTH THAT ARE BUILT WITH 2010 EPA-CERTIFIED ENGINES ON POWERGLIDE CHASSIS. THE EXHAUST PIPE IS MOUNTED TOO CLOSE TO THE UNDERSIDE OF THE FLOOR.

Consequence: MELTING OF THE INSULATION CAN OCCUR, POSSIBLY RESULTING IN A FIRE.

Remedy: TIFFIN WILL NOTIFY OWNERS, AND DEALERS WILL ATTACH A HEAT SHIELD TO THE BOTTOM OF THE FLOOR AND AN INSULATING SOCK OR BLANKET WILL BE WRAPPED AROUND THE EXHAUST PIPE. THESE REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 19, 2011. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661.

Reported: 2015-09-30 (September 30, 2015) · Model years: 2010, 2011, 2012

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2010-2012 Phaeton motorhomes built on Powerglide chassis with floor plans QBH, QKH, and QTH manufactured July 1, 2010, to August 1, 2011. The affected vehicles have an exhaust pipe that is mounted too close to the underside of the floor.

Consequence: Insufficient spacing between the exhaust pipe and the floor may result in the insulation melting and an increased risk of a fire.

Remedy: Tiffin will notify owners, and dealers will change the configuration of the exhaust to provide extra clearance between it and the floor, free of charge. The recall began on December 1, 2015. Owners may contact Tiffin customer service at 1-256-356-8661. Note: Although these vehicles may have been previously repaired for this condition under recall number 11V-416, it is important that the affected vehicles receive the revised remedy of this recall.

Reported: 2010-10-25 (October 25, 2010) · Model years: 2011

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO, ALLEGRO BUS, AND PHAETON RVS EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Remedy: TIFFIN IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 28, 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749 OR TIFFIN 1-256-356-8661.

Reported: 2011-09-23 (September 23, 2011) · Model years: 2011

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO BUS AND PHAETON RECREATIONAL VEHICLES BUILT ON THE POWERGLIDE CHASSIS EQUIPPED WITH A CUMMINS ISX OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Consequence: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy: TIFFIN MOTORHOMES IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR TIFFIN MOTORHOMES AT 1-256-356-8661.

Reported: 2011-11-10 (November 10, 2011) · Model years: 2011

TIFFIN MOTORHOMES, INC. (TIFFIN) IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO AND PHAETON RECREATIONAL VEHICLES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH A CUMMINS ISC, ISX, ISM, OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Consequence: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy: TIFFIN IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR TIFFIN AT 1-256-356-8661.

Reported: 2012-02-08 (February 8, 2012) · Model years: 2011, 2012

TIFFIN IS RECALLING CERTAIN MODEL YEAR 2011, 2012, AND 2013 RECREATIONAL VEHICLES, MODELS PHAETON AND ZEPHYR, EQUIPPED WITH A CUMMINS ISB, ISC, ISL, OR ISX DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Consequence: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy: TIFFINS IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR TIFFINS AT 256-356-8661.

Reported: 2012-05-22 (May 22, 2012) · Model years: 2012

TIFFIN MOTORHOMES (TIFFIN) IS RECALLING TWO MODEL YEAR 2012 PHAETON RECREATIONAL VEHICLES BUILT ON A SPARTAN CHASSIS AND EQUIPPED WITH 3030 BRAKE CHAMBERS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 121, “AIR BRAKE SYSTEMS” BECAUSE THEY DO NOT MEET THE PARK BRAKE AND DRAW BAR REQUIREMENTS.

Consequence: THE PARK BRAKE MAY NOT BE SUFFICIENT TO HOLD THE VEHICLE IN PLACE. ACCORDINGLY, THE VEHICLE COULD ROLL AWAY AND STRIKE AND INJURE A BYSTANDER OR CAUSE A CRASH WITHOUT WARNING.

Remedy: THE AFFECTED VEHICLES HAVE NOT BEEN SOLD YET AND TIFFIN HAS NOTIFIED THE DEALERS THAT ARE IN POSSESSION OF THE VEHICLES. SPARTAN DEALERS WILL INSTALL IMPROVED BRAKE CHAMBERS PRIOR TO SALE. OWNERS MAY CONTACT TIFFIN MOTORHOMES AT 1-256-356-8661.

Reported: 2017-02-27 (February 27, 2017) · Model years: 2012

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2012 Phaeton motorhomes with floor plans QBH, QKH, and QTH, built on PowerGlide chassis. The affected vehicles have an exhaust pipe that is mounted too close to the underside of the floor.

Consequence: Insufficient spacing between the exhaust pipe and the floor may result in the insulation melting and an increased risk of a fire.

Remedy: Tiffin will notify owner, and dealers will reconfigure the exhaust to provide extra clearance, free of charge. The recall began on March 22, 2017. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for the recall is TIF-106.

Reported: 2015-05-19 (May 19, 2015) · Model years: 2015

Tiffin Motorhomes, Inc.(Tiffin) is recalling certain model year 2015 Allegro Red 36 QSA, Allegro Red 38 QBA, Phaeton 40 QBH, and Phaeton 40 QKH motorhomes manufactured April 22, 2014, to May 8, 2015. In the affected vehicles, moisture may enter the slide-out controller and cause the "switch out" connection to short, and cause the motorhome slide-out section to extend while the motorhome is moving.

Consequence: If the slide-out opens during transit, there is an increased risk of a vehicle crash.

Remedy: Tiffin will notify owners, and dealers will install a relay to disconnect the power source of the slide-out, free of charge. The recall began on June 16, 2015. Owners may contact Tiffin customer service at 1-256-356-8661.

Reported: 2021-04-30 (April 30, 2021) · Model years: 2017, 2018, 2019, 2020, 2021

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2017-2021 Bus and Phaeton vehicles. The sealing washer may not seat correctly in the pilot bore, allowing the high pressure fuel rail assembly to leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Tiffin will work with Cummins to inspect the rail threads , and replace the rail and fuel lines if damage is found, free of charge. Owner notification letters were mailed August 11, 2021. Owners may contact Tiffin customer service at 1-256-356-8661.

Reported: 2018-05-25 (May 25, 2018) · Model years: 2018, 2019

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2019 Tiffin Allegro RED, Allegro Open Road, Breeze, Bus, Phaeton, and Zephyr motorhomes. The entry door on these vehicles may have been improperly assembled, allowing the door to open while the vehicle is moving.

Consequence: If the door comes open while the motorhome is moving, there is an increased risk of injury to the motorhome occupants.

Remedy: Tiffin will notify owners, and dealers will adjust the door lock mechanism, free of charge. The recall began on June 18, 2018. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-110.

Reported: 2019-03-22 (March 22, 2019) · Model years: 2018, 2019

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2019 Phaeton, Allegro Bus, and Zephyr motorhomes. The alternating current electrical wires may have been improperly secured in the Energy Management Module, causing increased electrical resistance.

Consequence: The additional resistance can cause the wires to overheat, increasing the risk of a fire.

Remedy: Tiffin will notify owners, and dealers will inspect the Alternating Current Relay Board and make sure the wires are properly secured, free of charge. The recall began April 15, 2019. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-111.

Reported: 2021-11-05 (November 5, 2021) · Model years: 2018, 2019, 2020, 2021, 2022

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro Breeze, Allegro Red, Allegro, Allegro Bus, Phaeton, and 2018-2021 Zephyr recreational vehicles. The sofa seat belts may not have been installed correctly, which could result in unsecured passengers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

Consequence: Unsecured passengers have an increased risk of injury in the event of a crash.

Remedy: Dealers will inspect and repair the seat belts as necessary, free of charge. Owner notification letters were mailed October 29, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-118.

Reported: 2020-09-02 (September 2, 2020) · Model years: 2020

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2020 Bus and Phaeton motorhomes. The steering pinch bolts may not have been properly tightened.

Consequence: A loose steering pinch bolt can result in a loss of steering control, increasing the risk of a crash.

Remedy: Tiffin will notify owners, and dealers will tighten the steering bolts to specification, free of charge. The recall began August 27, 2020. Owners may contact Tiffin customer service at 1-256-356-8661.

Reported: 2021-03-18 (March 18, 2021) · Model years: 2021

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021 Phaeton recreational vehicles. The valve stem stabilizer can become loose, allowing the valve stem extender to contact the wheel.

Consequence: If the valve stem extender rubs on the wheel, it can cause a loss of tire pressure, increasing the risk of a crash.

Remedy: Tiffin will notify owners, and dealers will replace the valve stem stabilizer, free of charge. The recall began April 22, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-114.

Reported: 2021-04-15 (April 15, 2021) · Model years: 2021

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021 Phaeton motorhomes, equipped with a roof mounted passenger side awning. A roof mounted body panel may have been improperly attached to the roof.

Consequence: The roof mounted body panel may detach and become a road hazard, increasing the risk of a crash.

Remedy: Tiffin will notify owners, and dealers will inspect and, if necessary, properly adhere the body panel, free of charge. Owner letters were mailed April 26, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-115.

Reported: 2021-07-20 (July 20, 2021) · Model years: 2021, 2022

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2022 Allegro Bus and Phaeton motorhomes, equipped with certain Cummins L9 diesel engines. A fuel leak may occur from the fuel hose between the fuel pump and remote filter head.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will replace the fuel hoses, free of charge. Owner notification letters were mailed September 10, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-117.

Reported: 2021-10-07 (October 7, 2021) · Model years: 2021, 2022

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2022 Phaeton recreational vehicles. During manufacturing, an electrical outlet was not installed as intended, resulting in an open electrical wire inside the wall.

Consequence: An open electrical wire can increase the risk of a fire.

Remedy: Dealers will inspect the vehicle and install an outlet on the wire, free of charge. Owner notification letters were mailed October 27, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-119.

Reported: 2022-07-20 (July 20, 2022) · Model years: 2021, 2022

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2023 Allegro, Red 340, 2021-2022 Phaeton, Breeze, Allegro Red 360, and 2022 Bay motorhomes. The output line on the LPG tanks may not connect properly to the service valve, which can cause a propane leak.

Consequence: A propane leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Dealers will inspect and replace the service valves, as necessary, free of charge. Owner notification letters were mailed September 18, 2022. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-124.

Reported: 2022-08-05 (August 5, 2022) · Model years: 2022, 2023

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022 Zephyr, 2022-2023 Phaeton, Allegro Breeze and Allegro Bus motorhomes equipped with a Powerglide chassis. The chassis fuse can overheat while the motorhome is in motion, possibly causing the dash display to go blank and the engine to stall.

Consequence: An engine that shuts down unexpectedly increases the risk of a crash.

Remedy: Dealers will inspect and replace the defective fuse, as necessary, free of charge. Owner notification letters were mailed August 31, 2022. Owners may contact Tiffin's customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-126.

Reported: 2022-10-31 (October 31, 2022) · Model years: 2022, 2023

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2023 Allegro Bay, Breeze, Phaeton, Red 360, 2023 Allegro and Red 340 motorhomes. The fitting on the non-leaching hose connected to the LPG regulator may leak at the swivel joint.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and replace the LPG hose, as necessary, free of charge. Owner notification letters were mailed November 11, 2022. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-127.

Reported: 2023-06-05 (June 5, 2023) · Model years: 2022, 2023

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2023 Phaeton, Allegro Bus, and Zephyr motorhomes built on PowerGlide chassis. A fuse will trip during an a/c compressor failure, causing a loss of power to the chassis.

Consequence: Loss of power to the chassis can cause an engine stall, increasing the risk of a crash.

Remedy: Dealers will inspect the chassis controller, and install a harness and inline fuse as necessary, free of charge. Owner notification letters were mailed June 20, 2023. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-131.

Reported: 2024-01-23 (January 23, 2024) · Model years: 2022

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022 Allegro Bus, Phaeton, Allegro Red 360, and Zephyr motorhomes. The pedestal mounting plate on the driver's seat may be improperly welded, which can cause the plate to separate and the seat assembly to loosen or detach.

Consequence: A loose or detached seat assembly increases the risk of injury.

Remedy: Dealers will inspect for a missing weld and replace the pedestal, as necessary, free of charge. Owner notification letters are expected to be mailed March 22, 2024. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-135.

Reported: 2024-07-30 (July 30, 2024) · Model years: 2022, 2023, 2024, 2025

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2022-2025 Phaeton, Allegro Bus, and Zephyr motorhomes. The PowerGlide chassis controller may have insufficient circuit protection, which can result in a blown fuse and cause an engine shutdown.

Consequence: An engine shutdown increases the risk of a crash.

Remedy: Dealers will install circuit protection, free of charge. Owner notification letters were mailed September 13, 2024. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-141.

Reported: 2023-07-31 (July 31, 2023) · Model years: 2023

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2023 Phaeton motorhomes, equipped with Cummins L9 diesel engines. The remote Stage 2 fuel filter hoses may have been damaged during production, allowing the hoses to leak or disconnect.

Consequence: A disconnected hose will result in an engine stall increasing the risk of a crash. Also, a fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Cummins dealers will replace both hoses, free of charge. Owner notification letters were mailed October 5, 2023. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-132.

Reported: 2026-06-29 (June 29, 2026) · Model years: 2026, 2027

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2026-2027 Zephyr, Wayfarer, Phaeton, Open Trail, GT1, Allegro Red, Allegro Open Road, Allegro Bus, Allegro Bay, 2026 Midas, Byway, and Allegro Breeze recreational vehicles, equipped with certain MaxxAir N-Series Maxxfan rooftop ventilation fans. The printed circuit board may fail during certain operations and overheat.

Consequence: An overheated printed circuit board increases the risk of a fire.

Remedy: Dealers will replace the circuit board, free of charge. Owner notification letters were mailed August 26, 2026. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-149. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning August 28, 2026.