Jayco GREYHAWK recalls by model year

Reported: 2003-10-09 (October 9, 2003) · Model years: 2002, 2003, 2004

ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR JAYCO AT 1-574-825-0608.

Reported: 2006-08-30 (August 30, 2006) · Model years: 2002

ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURNING, AND IN AN UNDERHOOD FIRE.

Remedy: FORD IS CONDUCTING THIS RECALL (PLEASE SEE 06V286) AND WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR JAYCO AT 1-800-283-8267.

Reported: 2003-02-21 (February 21, 2003) · Model years: 2003

ON CERTAIN RECREATIONAL VEHICLES BUILT ON GM GMT610 RV CHASSIS, DUE TO A CHANGE IN THE FUEL SYSTEM OF THESE CHASSIS, INCREASED PRESSURE RESULTS IN THE FUEL RETURN LINE. THE FUEL RETURN LINE IS USED TO PROVIDE A FUEL TAP FOR GENERATORS AND AUXILIARY ENGINES.

Consequence: OPERATING THE GENERATOR WHILE THE VEHICLE ENGINE IS RUNNING WILL STALL THE GENERATOR DUE TO OVERFUELING. STARTING, PRIMING OR OPERATING THE GENERATOR WITH THE VEHICLE ENGINE RUNNING COULD RESULT IN FUEL OVERFLOWING THE CARBURETOR, FLOODING THE GENERATOR ENGINE AND SPILLING FUEL INTO THE GENERATOR COMPARTMENT AND ON THE GROUND.

Remedy: GM/ONAN ADVISED JAYCO TO STOP DELIVERY OF THESE UNITS UNTIL A SOLUTION TO THE PROBLEM IS DEVELOPED. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT JAYCO AT 1-574-825-0653.

Reported: 2005-10-14 (October 14, 2005) · Model years: 2003, 2004, 2005, 2006

CERTAIN MOTOR HOMES BUILT ON CHEVROLET C3500 (EXPRESS) CUTAWAY CHASSIS HAVE A TOWING PIGTAIL THAT WILL NOT SHOW BRAKE LIGHTS ON THE TOWED VEHICLE IF HOOKED TO THE TOWING PIGTAIL.

Consequence: THIS CONDITION COULD RESULT IN A CRASH, INJURY OR DEATH.

Remedy: DEALERS WILL REWIRE THE TOWING PIGTAIL WIRES TO INCLUDE THE BRAKE LIGHT CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 31, 2005. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.

Reported: 2006-03-28 (March 28, 2006) · Model years: 2003, 2004, 2005

ON CERTAIN MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION, COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.

Consequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.

Remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.

Reported: 2006-03-31 (March 31, 2006) · Model years: 2003, 2004, 2005

CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.

Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.

Remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.

Reported: 2006-06-14 (June 14, 2006) · Model years: 2003

ON CERTAIN MOTOR HOMES BUILT ON CHEVROLET CHASSIS, THE SAFETY BELT BUCKLES MAY NOT LATCH OR UNLATCH.

Consequence: IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY OR DEATH.

Remedy: GENERAL MOTORS IS CONDUCTING THIS RECALL (PLEASE SEE 05V558000) AND WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALERS WILL REPLACE ONLY THE UPPER BUCKLE COVER. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR JAYCO AT 1-574-825-0608.

Reported: 2017-11-21 (November 21, 2017) · Model years: 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015, 2016

Jayco, Inc. (Jayco) is recalling various 2002-2016 recreational vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V746-9524.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Jayco will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Jayco customer service at 1-800-283-8267, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Reported: 2005-01-28 (January 28, 2005) · Model years: 2004

ON CERTAIN MOTOR HOMES, THE 120-VOLT SHORE POWER CORD WAS WIRED WITHOUT A CIRCUIT PROTECTION DEVICE.

Consequence: THIS COULD CAUSE A FIRE.

Remedy: DEALERS WILL INSPECT AND REWIRE THE 120-VOLT SHORE POWER CORD AND INSTALL A CIRCUIT PROTECTION FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 21, 2005. OWNERS MAY CONTACT JAYCO AT 574-825-5861.

Reported: 2005-08-08 (August 8, 2005) · Model years: 2004, 2005

ON CERTAIN MOTOR HOMES, THE CABLE TIES, WHICH ATTACH THE MAIN WIRING HARNESS TO THE FRAME RAILS, MAY BREAK AND CAUSE THE WIRE HARNESS TO DROP INTO THE EXHAUST SYSTEM.

Consequence: THIS COULD RESULT IN THE CABLE MELTING AND CREATING AN ELECTRICAL SHORT AND/OR FIRE.

Remedy: DEALERS WILL INSPECT THE MOTOR HOMES AND ATTACH NEW HEAVY DUTY CABLE TIES. THE RECALL BEGAN ON AUGUST 22, 2005. OWNERS MAY CONTACT JAYCO AT 1-574-825-5861.

Reported: 2005-12-16 (December 16, 2005) · Model years: 2004, 2005

ON CERTAIN MOTOR HOMES, THE HITCH RECEIVER MAY HAVE MISSING REINFORCING PLATES. WHEN A LOAD IS APPLIED TO THE HITCH, IT MAY BECOME PARTIALLY DETACHED FROM THE FRAME IF THESE PLATES ARE MISSING.

Consequence: THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, PERSONAL INJURY OR DEATH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE REINFORCING PLATES WITH NEW HARDWARE. THE RECALL BEGAN ON JANUARY 10, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.

Reported: 2005-01-12 (January 12, 2005) · Model years: 2005

ON CERTAIN MOTOR HOMES THE BATTERY CABLE MAY HAVE BEEN ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD.

Consequence: THIS COULD CAUSE THE CABLE TO MELT, CREATING AN ELECTRICAL SHORT, WHICH COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND REROUTE AND/OR REPLACE THE BATTERY CABLE FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 28, 2005. OWNERS MAY CONTACT JAYCO AT 574-825-5861.

Reported: 2006-04-10 (April 10, 2006) · Model years: 2005

CERTAIN MOTOR HOMES BUILT ON FORD E-450 CHASSIS, AND EQUIPPED WITH LT225/75R16E TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES.

Consequence: AT THE INCORRECTLY STATED PRESSURE, THE REAR TIRES ARE UNABLE TO SUPPORT THE GROSS AXLE WEIGHT RATING (GAWR) FOR THE REAR AXLE.

Remedy: OWNERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT REAR TIRE INFLATION INFORMATION. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267 .

Reported: 2006-01-13 (January 13, 2006) · Model years: 2006

CERTAIN MOTOR HOMES MAY HAVE U-JOINT RETAINING CLIPS MISSING OR NOT INSTALLED PROPERLY. IF THE RETAINING CLIPS ARE NOT INSTALLED PROPERLY, THE U-JOINT MAY BECOME DISLODGED FROM THE YOKE AND THE DRIVE SHAFT WILL BECOME DISCONNECTED FROM THE DRIVE TRAIN.

Consequence: THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, INJURY OR DEATH.

Remedy: DEALERS HAVE COMPLETED THE REPAIRS TO 100 PERCENT OF THE UNITS AT THE FACTORY AND AT DEALERSHIPS. NO FURTHER ACTION IS NECESSARY ON THIS RECALL.

Reported: 2006-03-30 (March 30, 2006) · Model years: 2006

ON CERTAIN MOTOR HOMES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

Remedy: FORD IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. ALL VEHICLES HAVE BEEN REMEDIED.

Reported: 2008-05-06 (May 6, 2008) · Model years: 2007, 2008

JAYCO IS RECALLING 1,265 MY 2005-2008 SENECA '35GS' AND MY 2007-2008 GREYHAWK '33DS' AND '32SS' MOTOR HOMES. THE CONDUIT CLAMP ON THE COPPER LIQUID PROPANE (LP) TUBE FEEDING THE SLIDE-0UT IS INCORRECTLY PLACED WHICH MAY ALLOW THE COPPER TUBE TO BEND AND POSSIBLY LEAK WITH THE MOVEMENT OF THE SLIDE-OUT.

Consequence: IF THE COPPER TUBE CRACKED, PRESSURIZED LP GAS MAY ESCAPE INTO THE COMPARTMENT. THIS CONDITION, IF NOT ADDRESSED, MAY RESULT IN A FIRE, INJURY OR DEATH.

Remedy: DEALERS WILL RELOCATE THE CONDUIT CLAMP AND ADD A RUBBER GROMMET TO ALLOW ADHESION. THE RECALL BEGAN ON MAY 26, 2008. OWNERS MAY CONTACT JAYCO AT 1-574-825-5861.

Reported: 2012-07-23 (July 23, 2012) · Model years: 2007

Jayco is recalling certain model year 2007 Greyhawk Class C motorhomes; model year 2008 and 2010 Seneca Class C motorhomes; model year 2009 and 2011 Eagle Fifth-wheel; 2010 Recon fifth-wheel; and model year 2008-2010 Designer fifth wheel vehicles manufactured from June 15, 2006, through August 13, 2010 for an improper electrical connection at the buss bar on the Iota-brand transfer switches installed in the vehicles.

Consequence: An improper electrical connection at the buss bar could lead to overheating and melting of the transfer switch, increasing the risk of a fire, injury or death.

Remedy: Jayco will notify owners, and dealers will replace the transfer switch, free of charge. The safety recall began on August 31, 2012. Owners may contact Jayco at 1-800-283-8267.

Reported: 2017-09-22 (September 22, 2017) · Model years: 2016, 2017

Jayco, Inc. (Jayco) is recalling certain 2016-2017 Greyhawk motorhomes, model 29ME. Damage to the liquid propane (LP) line can occur by the line being melted by the vehicle's exhaust pipe, contacting the drive shaft, or being kinked at the p-clamp.

Consequence: A damaged LP line can increase the risk of a fire.

Remedy: Jayco will notify owners, and dealers will inspect the LP lines, correcting them or replacing them as necessary, free of charge. The recall began on October 13, 2017. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9903361.

Reported: 2020-07-14 (July 14, 2020) · Model years: 2016, 2017, 2018

Jayco, Inc. (Jayco) is recalling certain 2016-2018 Greyhawk and Redhawk and 2018 Envoy 100 and 200 Series motorhomes. The mounting bracket for the leveling system hydraulic pump may fail and allow the pump or the fluid reservoir to contact the ground.

Consequence: If the mounting bracket fails and allows the pump and reservoir to contact the ground and possibly detach or leak hydraulic fluids, increasing the risk of a crash.

Remedy: Jayco will notify owners and dealers will add a support bracket to reinforce the existing support bracket, free of charge. The recall began December 8, 2020. Owners may contact Jayco's customer service at 1-800-517-9137. Jayco's number for this recall is 9903515.

Reported: 2020-09-09 (September 9, 2020) · Model years: 2016, 2017, 2018, 2019

Jayco, Inc. (Jayco) is recalling certain 2016-2019 Jayco Greyhawk, 2016 and 2018-2019 Jayco Redhawk, 2017 Jayco Envoy 200 Series and 2018-2019 Entegra Odyssey, Jayco Esteem, and Jayco Greyhawk Prestige motorhomes. The mounting brackets for the leveling system hydraulic pump and reservoir may fail allowing the components to contact the ground.

Consequence: Contact with the ground may cause the pump and reservoir to detach or leak hydraulic fluids, increasing the risk of a crash.

Remedy: Jayco will notify owners and dealers will install an additional support bracket, free of charge. The recall began November 6, 2020. Owners may contact Jayco's customer service at 1-800-517-9137. Jayco's number for this recall is 9901519.

Reported: 2019-03-06 (March 6, 2019) · Model years: 2019

Jayco, Inc. (Jayco) is recalling certain 2019 Jayco Greyhawk and Redhawk motorhomes. The parking brake cable ends may be too small, allowing the cable to disconnect, preventing the emergency brake from engaging.

Consequence: Without the parking brake being engaged, the vehicle may unintentionally move, especially when parked on an incline, increasing the risk of a crash.

Remedy: Jayco has notified owners, and dealers will replace the parking brake cable, free of charge. The recall began March 15, 2019. Owners may contact Jayco's customer service at 1-800-517-9137. Jayco's number for this recall is 9803428.

Reported: 2021-03-24 (March 24, 2021) · Model years: 2019, 2020

Jayco, Inc. (Jayco) is recalling certain 2019-2020 Jayco Alante, Precept, Greyhawk, Redhawk, Entegra Esteem, and Odyssey motorhomes equipped with Dometic 3 burner cooking stoves. The saddle valve securing bolt may be overtightened, possibly damaging the o-ring seal and causing a continuous gas leak.

Consequence: A gas leak can increase the risk of a fire.

Remedy: Jayco will notify owners, and Dometic service centers will install a remedy kit of gaskets, washers, thread locker bolts, and two round orange labels, free of charge. Owner notification letters were mailed on May 3, 2021. Owners may contact Jayco customer service at 1-617-776-0344. Jayco's number for this recall is 9903566.

Reported: 2019-05-30 (May 30, 2019) · Model years: 2020

Jayco, Inc. (Jayco) is recalling certain 2020 Greyhawk motorhomes. The brake relay valve may have an air flow restriction due to a partially blocked orifice, which may cause to extended stopping distance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."

Consequence: An increase in stopping distance without warning increases the risk of crash.

Remedy: Spartan will notify Jayco owners, and Spartan dealers will inspect and replace the brake relay valve, if necessary, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact Spartan customer service at 1-800-543-5008 or Jayco at 1-800-517-9137.

Reported: 2020-06-09 (June 9, 2020) · Model years: 2020

Jayco, Inc. (Jayco) is recalling certain 2020 Motorized Alante, Greyhawk, Melbourne, Precept, Redhawk, Seneca, Accolade, Emblem, Esteem, Odyssey, Qwest, and Vision recreational vehicles. The adhesive bond between the glass and the metal hinge frame of the frameless crank out vent and egress windows may fail which would then allow the glass to detach and fall out.

Consequence: If the window glass detaches while the vehicle is moving it could become a projectile, increasing the risk of injury or a crash.

Remedy: Jayco will notify owners, and dealers will inspect the frameless windows for proper adhesive bond strength, replacing the windows as necessary, free of charge. This recall began June 15, 2020. Owners may contact Jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901508.

Reported: 2020-12-15 (December 15, 2020) · Model years: 2020, 2021

Jayco, Inc. (Jayco) is recalling certain 2020-2021 Greyhawk, Greyhawk Pestige, Redhawk, Redhawk SE, Odyssey, and Esteem motorhomes. The mounting brackets for the leveling system hydraulic pump and reservoir may fail, allowing the components to contact the ground.

Consequence: Contact with the ground may cause the pump and reservoir to detach or leak hydraulic fluids, increasing the risk of a crash.

Remedy: Jayco will notify owners, and dealers will install a new support bracket, free of charge. The recall began February 3, 2021. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9903528.

Reported: 2024-04-02 (April 2, 2024) · Model years: 2020, 2021, 2022

Jayco, Inc. (Jayco) is recalling certain 2020-2022 Entegra Esteem, Odyssey, and Jayco Greyhawk, Redhawk, and Greyhawk Prestige motorhomes. An inadequate connection between the power steering pressure line and the brake hydroboost unit may result in a sudden loss of power steering fluid.

Consequence: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.

Remedy: Dealers will replace the power steering pressure line and the hydro boost jumper line, free of charge. Owner notification letters were mailed July 22, 2024. Owners may contact Jayco customer service at 1-800-283-8267.

Reported: 2022-05-03 (May 3, 2022) · Model years: 2021, 2022

Jayco, Inc. (Jayco) is recalling certain 2021-2022 Jayco Greyhawk, Greyhawk Prestige, Redhawk, Entegra Esteem, and Odyssey recreational vehicles. An inadequate connection between the power steering pressure line and the brake Hydroboost unit may result in a sudden loss of power steering fluid.

Consequence: A sudden loss of power steering fluid can result in a loss of power steering and power brake assist, increasing the risk of a crash.

Remedy: Dealers will inspect the connection between the power steering lines and the Hydroboost unit, and replace the power steering lines, as necessary, free of charge. Owner notification letters were mailed June 15, 2022. Owners may contact Jayco customer service at Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 22V-089.

Reported: 2022-08-04 (August 4, 2022) · Model years: 2022

Jayco, Inc. (Jayco) is recalling certain 2022 Greyhawk, Greyhawk Prestige, Melbourne, Redhawk, and Entegra Coach Odyssey vehicles. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

Remedy: Dealers will inspect and repair, or replace the awning fabric, as necessary, free of charge. Owner notification letters were mailed August 31, 2022. Owners may contact Jayco's customer service at 1-800-283-8267. Jayco's number for this recall is 9903578.

Reported: 2023-02-20 (February 20, 2023) · Model years: 2022, 2023

Jayco, Inc. (Jayco) is recalling certain 2022-2023 Entegra Accolade, Accolade XL, Anthem, Aspire, Cornerstone, Emblem, Esteem, Expanse, Expanse LI, Odyssey, Qwest, Reatta, Reatta XL, Jayco Alante, Greyhawk, Greyhawk Prestige, Melbourne, Melbourne Prestige, Precept, Precept Prestige, Redhawk, Redhawk SE, Seneca, Seneca Prestige, and Seneca XT recreational vehicles. The certification labels may be missing the rear Gross Axle Weight Rating (GAWR). As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."

Consequence: Missing axle information may result in the vehicle being overloaded, increasing the risk of a crash.

Remedy: Dealers will install a new corrected certification label, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9903583.

Reported: 2023-05-04 (May 4, 2023) · Model years: 2022

Jayco, Inc. (Jayco) is recalling certain 2022 Esteem, Odyssey, Redhawk, and Greyhawk motorhomes built on Ford chassis. The paint along the weld seam of the fuel tank may peel and lead to corrosion of the exposed metal, which can result in a fuel leak.

Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.

Remedy: Ford dealers will inspect the fuel tank and replace, if necessary, free of charge. Owner notification letters were mailed on May 31, 2023. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is Ford 22V-925.

Reported: 2023-06-01 (June 1, 2023) · Model years: 2023

Jayco, Inc. (Jayco) is recalling certain 2023 Jayco Greyhawk, Redhawk, and Entegra Coach Odyssey motorhomes. The bolt that secures the rear axle rotor to the wheel-hub may be improperly tightened, possibly resulting in wheel separation.

Consequence: Wheel separation from the vehicle increases the risk of a crash.

Remedy: Dealers will inspect the rear axle serial number, and if necessary, remove and inspect the rear axle rotor and hub assembly. If any bolts are found to be loose, the rotor and hub assembly will be replaced, free of charge. Owner notification letters were mailed June 23, 2023. Owners may contact Jayco customer service at 1-800-283-8267.