2015 Toyota HIGHLANDER: complaints, problems and recalls

I PARKED MY CAR IN THE GARAGE AND SEVERAL HOURS LATER I HAPPENED TO NEED SOMETHING OUT THERE. WHEN I ENTERED I HEARD AN ELECTRIC MOTOR RUNNING EVEN THOUGH THE CAR HAD BEEN TURNED OFF FOR SEVERAL HOURS. CRAWLING UNDER THE CAR I FOUND THAT THE SOUND WAS COMMING FROM A MOTOR NEAR THE REAR AXLE. I REPORTED IT TO MY TOYOTA DEALER AND THEY ADVISED THAT IT WAS A MOTOR THAT MAY RUN HOURS AFTER THE CAR IS TURNED OFF TO PURGE THE CARBON CANISTER. THEY ADVISED THAT THEY FOUND THAT INFORMATION IN THEIR SERVICE MANUAL, BUT NOT THE OWNERS MANUAL. ONE TI…

Owner-reported narrative. 200 miles reported. Look up ODI 10664203 at NHTSA ↗

TL*THE CONTACT OWNS A 2015 TOYOTA HIGHLANDER. THE CONTACT STATED THAT DURING INCLEMENT WEATHER, WATER LEAKED INSIDE THE VEHICLE THROUGH THE MOLDING ON THE FRONT DRIVER AND PASSENGER DOORS. THE CONTACT STATED THAT THE MOLDING WAS NOT SEALED PROPERLY TO PREVENT WATER FROM LEAKING IN. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE TECHNICIAN STATED THAT THE VEHICLE WAS WORKING UP TO SPECIFICATIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 700. ....UPDATED 07/22/15…

Owner-reported narrative. 700 miles reported. Look up ODI 10678256 at NHTSA ↗

THIS HIGHLANDER HAS A POWER LIFTGATE. IF A CHILD OR ADULT GETS IN THE WAY OF THE LIFTGATE WHEN IT IS LOWERING, THE CHILD OR ADULT CAN BE SERIOUSLY INJURED, CRUSHED OR KILLED BECAUSE THE LIFTGATE HAS NO EASY REVERSING FEATURE. IT DOES REVERSE WHEN IT HITS AN OBJECT BUT THE FORCE REQUIRED TO MAKE IT REVERSE IS TOO GREAT AND WILL HURT OR KILL A HUMAN WHO GETS IN THE WAY. PEOPLE OFTEN REACH IN THE TRUNK TO FETCH SOMETHING AFTER THE OPERATOR DECIDES TO CLOSE THE TRUNK. IF THIS HAPPENS WITH THE POWER CLOSER, THE OPERATOR MUST KNOW THE EXACT …

Owner-reported narrative. 36 miles reported. Look up ODI 10684150 at NHTSA ↗

APRIL 24, 2015 [XXX] TO AN APPROPRIATE REPRESENTATIVE OF THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION: IN NOVEMBER 2014, I PURCHASED A TOYOTA HIGHLANDER LIMITED MODEL ID# [XXX]:. DURING FREEZING WEATHER THIS WINTER I DISCOVERED A DANGEROUS DESIGN FAULT RELATING TO THE VEHICLE. MUCH OF THE WINDSHIELD WIPERS CAN BE ENTRAPPED AND EMBEDDED IN ICE, AND THE DEFROSTER DOES NOT MELT ICE IN THAT AREA. THE WIPERS ARE INCAPACITATED. THE DEFROSTER CLEARS THE WINDSHIELD BUT DOES NOTHING TO FREE THE WIPERS FROM ICE. THAT WAS THE CASE FOR ME DUR…

Owner-reported narrative. Look up ODI 10713136 at NHTSA ↗

HELLO, I WOULD LIKE TO GET NHTSA'S HELP BECAUSE TOYOTA WON'T PROVIDE ANY REMEDY FOR THIS PROBLEM. ON 4/17/2015, I BOUGHT A TOYOTA 2015 HIGHLANDER LE PLUS FROM TOYOTA NORTH BRUNSWICK (NJ) AND NOTICED BUZZING SOUND AFTER DRIVING ONLY ~30 MINUTES. BUZZING SOUND COMES FROM DASHBOARD AREA CONSTANTLY, ~ONCE EVERY MINUTE (IN THE BEGINNING OF DRIVING) TO ~EVERY SECOND (AFTER DRIVING AN HOUR). THE NOISE IS FROM THE AIR BLEND SERVO (RELATED TO AC) AS ACKNOWLEDGED BY LOCAL TOYOTA SERVICE DPT, BUT TOYOTA KEEPS SAYING THAT THE NOISE IS NORMAL NO …

Owner-reported narrative. 70 miles reported. Look up ODI 10715419 at NHTSA ↗

THE DASH READOUT FOR MPH BEGAN SHOWING VERY ERRATIC NMBERS. GOING FROM 24.4 MPG TO 29.7 MPG AND DOWN TO 13.1 MPG ALL IN A SPAN OF ABOUT 4 MILES. THIS MPG OF 24.4 WAS FOR THE PRIOR 3000 MILES. THE DEALER COULD NOT REPLICATE THIS HAPPENING. THEY ALSO SAID THAT TOYOTA HAD NO BULLETINS FOR THIS MATTER EITHER. I CONTACTED TOYOTA AND THEY SAID THAT I MUST HAVE ACCIDENTALLY RESET THE UNIT AND BY DOING SO IT WAS NOT UNUSUAL FOR THESE LARGE SWINGS IN MPG. THIS WAS NOT THE CASE. I HAD OVER 100 MILES ON SINCE MY LAST FILL UP AND UNTIL THIS HAPPENING THE …

Owner-reported narrative. 4,700 miles reported. Look up ODI 10717042 at NHTSA ↗

I RECEIVED A RECALL NOTICE IN THE MAIL ON MAY 12 ABOUT A POSSIBLE DEFECTIVE CIRCUIT BOARD FOR THE ELECTRIC POWER STEERING. I TOOK THE CAR TO A TOYOTA DEALER ON MAY 13, AND WAS TOLD LATER THAT DAY THAT MY CAR DID INDEED HAVE ONE OF THE UNITS DEEMED DEFECTIVE. I WAS GIVEN A LOANER CAR AT NO CHARGE. EVERYTHING SEEMED OK, BUT NOW IT IS 10 DAYS LATER, AND NO REPLACEMENT PART HAS ARRIVED. NOT ONLY THAT BUT BOTH THE DEALER AND THE NATIONAL CUSTOMER SERVICE NUMBER ARE COMPLETELY UNABLE TO PREDICT WHEN ANY REPLACEMENT PARTS WILL BE AVAILABLE. IS THERE A…

Owner-reported narrative. 4,700 miles reported. Look up ODI 10721074 at NHTSA ↗

A SAFETY RECALL ON A POSSIBLE DEFECTIVE CIRCUIT BOARD FOR THE ELECTRIC POWER STEERING, I WAS TOLD THAT THERE IS NO PARTS AVAILABLE TO REPLACE THE DEFECTIVE PARTS AND THEY DON'T EVEN KNOW WHEN IS THE PARTS WILL BE AVAILABLE.

Owner-reported narrative. Look up ODI 10722261 at NHTSA ↗

Reported: 2015-03-13 (March 13, 2015)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2015 Camry, Camry Hybrid, Highlander, and Highlander Hybrid, and 2014-2015 Rav4 vehicles. A component of the electric power steering (EPS) electronic control unit (ECU) may have been damaged during the manufacturing process. Over time, this damage may result in failure of the electric power steering system.

Consequence: An unexpected loss of power steering increases the risk of a crash.

Remedy: Toyota will notify owners, and dealers will inspect the serial number of the EPS ECU or steering column assembly. If the number is within the affected range, the EPS ECU will be replaced, free of charge. The recall began on May 7, 2015. Owners may contact Toyota customer service at 1-800-331-4331.