2005 Honda PILOT: complaints, problems and recalls

HEADREST OF THE DRIVER AND PASSENGER SEATS ARE REALLY FAR AWAY. THIS CAUSES SERIOUS NECK STRAIN AND PAIN. THIS IS A SERIOUS SAFETY HAZARD SINCE IT COULD CAUSE A MAJOR INJURY IN THE EVENT OF A CRASH. THE HEADREST OF THE DRIVER AND PASSENGER SEAT IS A DOUGHNUT HOLE TYPES HEADREST. THIS HEADREST IS NOT ADJUSTABLE AND SITS FAR BACK AWAY FROM THE BACK. SO, IT DOES NOT PROVIDE SUPPORT TO THE NECK. QUITE A FEW PEOPLE SEEM TO HAVE THIS PROBLEM. PLEASE CHECK HTTP://WWW.EDMUNDS.COM DISCUSSIONS AND HTTP://WWW.HONDA-PILOT.ORG DISCUSSIONS. PLEAS…

Owner-reported narrative. 3,000 miles reported. Look up ODI 10114138 at NHTSA ↗

VEHICLE: HONDA PILOT 2005 EX-L, PURCHASED ON 12/2004 WHENEVER I DRIVE MY HONDA PILOT I HAVE PAIN IN MY RIGHT EAR. A WEEK FROM TODAY, I STOPPED BY MY DEALER AND TEST DROVE THE EXACT SAME MODEL FROM THE DEALER, AND I DID NOT HAVE NAY PAIN IN MY EAR.*AK I WENT TO SEE AN (EAR, NOSE AND THROAT SPECIALIST, AND ACCORDING TO MY DOCTOR, I HAVE NO PROBLEM WITH MY EAR AT ALL. DOCTOR SUGGESTED THERE COULD BE SOME KIND OF CHEMICAL IN MY CAR THAT PROBABLY CAUSED SOME REACTION IN MY EAR. I HAVE A HONDA, ACCORD THAT I DRIVE REGULARLY, I DO NOT HAV…

Owner-reported narrative. Look up ODI 10116929 at NHTSA ↗

WHILE DRIVING AT ANY SPEED PASSENGER FRONT SHOULDER BELT WOULD LOCK UP UNTIL RELEASED. DEALERSHIP REPAIRED THE PROBLEM ONCE, BUT DID NOT RESOLVE IT. *AK THE SECOND TIME THIS HAPPEN, CONSUMER DROVE TO THE DEALER WITH PASSENGER LOCKED IN FRONT SEAT SHOULDER HARNESS. DEALERSHIP SAID THEY HAD A PROBLEM AND REPLACE MECHANISM. THIRD TIME DEALERSHIP SAID IT WAS A DESIGNED THAT WAY-IF SEAT BELT IS EXTENDED ALL THE WAY OUT WHEN LOCKING THEN THAT WILL OCCUR. *BF *NM

Owner-reported narrative. 1,500 miles reported. Look up ODI 10117450 at NHTSA ↗

HEADREST OF THE DRIVER AND PASSENGER SEATS ARE REALLY FAR AWAY. THIS CAUSES SERIOUS NECK STRAIN AND PAIN. THIS IS A SERIOUS SAFETY HAZARD SINCE IT COULD CAUSE A MAJOR INJURY IN THE EVENT OF A CRASH. THE HEADREST OF THE DRIVER AND PASSENGER SEAT IS A DOUGHNUT HOLE TYPES HEADREST. THIS HEADREST IS NOT ADJUSTABLE AND SITS FAR BACK AWAY FROM THE BACK. SO, IT DOES NOT PROVIDE SUPPORT TO THE NECK. QUITE A FEW PEOPLE SEEM TO HAVE THIS PROBLEM.

Owner-reported narrative. Look up ODI 10120143 at NHTSA ↗

2005 HONDA PILOT - FUNDAMENTAL FLAW IN SHOULDER BELT CENTER SEATING POSITION 2ND ROW. THE BELT STARTS IN THE CEALING SO FAR FORWARD THAT WHEN A PERSON WITHOUT A THICK UPPER BODY SITS IN THE CENTER POSITION IN THE 2ND ROW, THE BELT PASSES NEXT TO THE CHEEK RATHER THAN THE SHOULDER. IN THE CASE OF A CHILD WHO IS TOO BIG TO BE IN A BOOSTER WITH A BACK BUT IS STILL RELATIVELY SMALL, THE SHOULDER BELT ACTUALLY PASSES IN FRONT OF THE SHOULDER AND DESCENDS TO THE BUCKLE WITHOUT EVEN TOUCHING THE SHOULDER OR THE UPPER CHEST! THIS LEAVES THE CHILD IN…

Owner-reported narrative. Look up ODI 10122170 at NHTSA ↗

2005 HONDA PILOT EX WITH LESS THAN 500 MILES ON IT.. ~90% BRAKE FAILURE ON VEHICLE ON TWO OCCASIONS... 06/15/2005 AND 06/24/2005. TAKING TO HONDA OF CONCORD (CONCORD NC) TO BE REVIEWED... MAY OR MAY NOT REPAIR DEPENDING ON IF THEY CAN "DUPLICATE" THE PROBLEM BUT ARE AWARE OF SOME CASES OF THE MASTER CYLINDER GOING COMPLETELY OUT FOR A "MOMENT". ALERTING YOU ALL IN CASE THIS HAPPENS TO OTHERS AND TO HAVE ON RECORD.

Owner-reported narrative. 223 miles reported. Look up ODI 10126729 at NHTSA ↗

SUSTAINED VIBRATION WHEN DRIVING AT SPEEDS ABOUT 45 TO 75 MPH. MULTIPLE TRIPS TO DEALER, WAS TOLD THIS IS A "CHARACTERISTIC OF THE VEHICLE". STARTED THE FIRST DAY I DROVE THE VEHICLE OFF THE LOT WITH 50 MILES ON IT.

Owner-reported narrative. 50 miles reported. Look up ODI 10129652 at NHTSA ↗

MAKE: HONDA PILOT 2005 PLEASE ALSO REVIEW: HTTP://WWW.HONDAPILOT.ORG/FORUMS/SHOWTHREAD.PHP?S=&THREADID=4117&PERPAGE=15&PAGENUMBER=27 WHICH HAS 27 PAGES OF SIMILAR COMPLAINTS. I JUST BOUGHT A 2005 PILOT. I HAD THE HITCH INSTALLED BY HONDA. I NOTICED SOME VIBRATION LOWER THAN 70 MPH BUT ASSUMED THAT I WAS UNFAMILIAR WITH THE CAR. LO AND BEHOLD, WHEN I DROVE THE CAR HOME I NOTICED A SIGNIFICANT VIBRATION IN THE STEERING STARTING AROUND 69MPH, PEAKING AT AROUND 76 MPH AND FADING TO "NORMAL" AT AROUND 80 MPH. THE VIBRATION FEELS LIKE A WHEE…

Owner-reported narrative. 45 miles reported. Look up ODI 10129822 at NHTSA ↗

Reported: 2004-11-18 (November 18, 2004)

ON CERTAIN SPORT UTILITY VEHICLES, SOME FUEL TANKS WERE IMPROPERLY MANUFACTURED.

Consequence: IN A CRASH, THE FUEL TANK COULD BE DAMAGED AND LEAK FUEL. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS REPLACED THE FUEL TANK. ALL OWNERS WERE NOTIFIED BY TELEPHONE ON NOVEMBER 10, 2004.

Reported: 2005-02-03 (February 3, 2005)

ON CERTAIN MINIVANS AND SPORT UTILITY VEHICLES, THE STEERING COLUMN MAY BE INCORRECTLY ASSEMBLED, WHICH COULD RESULT IN A LOSS OF STEERING CONTROL.

Consequence: LOSS OF STEERING CONTROL CAN CAUSE A VEHICLE CRASH WITHOUT PRIOR NOTICE.

Remedy: OWNERS WERE NOTIFIED BY TELEPHONE ON JANUARY 25, 2005, AND ARRANGEMENTS WERE MADE TO HAVE THEIR VEHICLES TOWED TO THEIR DEALERS AND HAVE THE REPAIRS PERFORMED. THE RECALL BEGAN ON JANUARY 25, 2005.

Reported: 2012-03-30 (March 30, 2012)

HONDA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2004 CR-V; MODEL YEAR 2003 THROUGH 2005 PILOT; AND MODEL YEAR 2002 AND 2003 CIVIC VEHICLES. IN MARCH 2012, HONDA FILED A DEFECT REPORT TO RECALL CERTAIN MODEL YEAR 2002 THROUGH 2004 CR-V AND CERTAIN MODEL YEAR 2003 PILOT VEHICLES. IN AUGUST 2012, HONDA INFORMED THE AGENCY THAT IT WAS INCLUDING AN ADDITIONAL 820,789 VEHICLES INCLUDING CERTAIN MODEL YEAR 2004 AND 2005 PILOTS AND MODEL YEAR 2002 AND 2003 CIVICS. THE TOTAL NUMBER OF VEHICLES BEING RECALLED IS NOW 1,375,217. DUE TO TENSION FROM THE COMBINATION SWITCH WIRING HARNESS, WEAR ON THE SURFACE OF THE ELECTRICAL TERMINAL CAN OCCUR, YIELDING COPPER OXIDE, WHICH INCREASES ELECTRICAL RESISTANCE. INCREASED ELECTRICAL RESISTANCE MAY CAUSE THE TERMINAL ENDS TO MELT WITHIN THE WIRING HARNESS CONNECTOR.

Consequence: IF THE TERMINAL ENDS MELT WITHIN THE WIRING HARNESS CONNECTOR, THE LOW BEAM HEADLIGHTS MAY BECOME INOPERATIVE, REDUCING DRIVER VISIBILITY AND INCREASING THE RISK OF A CRASH.

Remedy: HONDA WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE LOW BEAM TERMINAL HARNESS OR REPLACE THE LIGHTING SWITCH AS NECESSARY, FREE OF CHARGE. THE ORIGINAL RECALL BEGAN IN APRIL 2012. OWNERS OF VEHICLES INVOLVED IN THE SEPTEMBER 2012 EXPANSION WILL BE NOTIFIED IN SEPTEMBER 2012. OWNERS MAY CONTACT HONDA CUSTOMER SERVICE AT 1-800-999-1009.

Reported: 2013-03-14 (March 14, 2013)

Honda is recalling certain model year 2005 Pilot vehicles manufactured July 29, 2004, through August 29, 2005; model year 2005-2006 Acura MDX vehicles manufactured September 16, 2004, through September 22, 2005; and model year 2005 Acura RL vehicles manufactured March 1, 2004, through June 29, 2005. An electrical capacitor may have been damaged during the manufacturing of the Vehicle Stability Assist (VSA) control module causing intermittent, automatic, minor brake application. However, if the driver applies the brakes while the VSA is malfunctioning, the vehicle may come to an abrupt stop. Additionally, due to a loose ground connection, certain model year 2005 Pilots have a VSA system that may apply partial brake force, without the illumination of the brake lights, whether or not the driver is using the brakes.

Consequence: Sudden inadvertent braking, especially without illumination of the brake lights, may increase the risk of a vehicle crash.

Remedy: Owners will be notified and instructed to take their vehicles to a dealer of their respective brand. The dealer will install a partial wiring harness containing a capacitor for the VSA modulator, free of charge. The affected model year 2005 Pilots will have their ground connection tightened. The recall began on April 22, 2013. Honda owners may contact Honda Automobile Customer Service at 1-800-999-1009, and select option 4 or go to www.recalls.honda.com; Acura owners may contact 1-800-382-2238, and select option 4, or go to www.recalls.acura.com.

Reported: 2014-06-20 (June 20, 2014)

American Honda Motor Company, Inc.'s (Honda) is conducting a limited regional recall for certain model year 2003-2005 Accord, Civic, CR-V, Pilot and Acura MDX, model year 2003-2004 Odyssey and Element, and model year 2005 Acura RL, and 2006 Honda Ridgeline vehicles originally sold, or ever registered in California, and equipped with Takata-brand air bag inflators. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the passenger’s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the inflators in all affected vehicles, free of charge. The recall is expected to begin during August 2014. Owners may contact Honda customer service at 1-800-999-1009.

Reported: 2014-11-04 (November 4, 2014)

American Honda Motor Co. (Honda) is recalling certain model year 2001-2005 Honda Civic, 2003-2004 Civic CNG and Element, 2002-2005 CR-V, 2002-2004 Odyssey, 2003-2005 Accord, Pilot, Civic Hybrid, and Acura MDX, 2005 Acura RL and 2006 Honda Ridgeline vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the passenger’s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the passenger side air bag inflator, free of charge. The recall began January 26, 2015. Owners may contact Honda customer service at 1-800-999-1009.

Reported: 2015-05-28 (May 28, 2015)

Honda (American Honda Motor Co.) is recalling certain model year 2001-2007 Accord, 2001-2005 Civic, 2001-2004 Honda Civic GX, 2003-2005 Honda Civic Hybrid, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot, 2006 Ridgeline, 2003 Acura 3.2CL, 2003-2006 Acura MDX, and 2002-2003 Acura 3.2TL vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began on July 1, 2015. Owners may contact Honda customer service at 1-888-234-2138. Owners may contact Acura customer service at 1-800-382-2238, select option 4. Note: Vehicles that have had their driver frontal air bag replaced previously as part of a recall remedy prior to September 12, 2014 need to have their air bag replaced under this recall as well. Vehicles that, on or after September 12, 2014, received a remedy for a prior driver frontal air bag inflator recall already received an inflator of a different design, and therefore are not included in this recall and do not require additional servicing. Note: This recall fully supersedes recalls 08V-593, 09V-259, 10V-041, 11V-260, 14V-351 and 15V-153. Honda's numbers for this recall are JQ9, JR0, JR1, JR2, JR3, JR4, JR5, JR6, JR7, and JR8.

Reported: 2016-05-23 (May 23, 2016)

Honda (American Honda Motor Co.) is recalling certain model year 2003-2006 Acura MDX, 2005-2011 Acura RL, 2005-2006 Honda CR-V, 2003-2011 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2011 Ridgeline vehicles originally sold, or that have ever been registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Honda is recalling certain model year 2003-2006 Acura MDX, 2005-2008 Acura RL, 2005-2006 Honda CR-V, 2003-2008 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2008 Ridgeline vehicles originally sold, or that have ever been registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Honda is recalling model year 2002-2004 Odyssey and model year 2003-2004 Acura MDX, Honda Element, and Honda Pilot vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began June 27, 2016. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KA0, KA1, KA2, and KA3.

Reported: 2017-01-10 (January 10, 2017)

Honda (American Honda Motor Co.) is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2011 Honda Element vehicles, 2005-2012 Acura RL vehicles, 2006-2012 Honda Ridgeline vehicles, 2007-2008 Honda Fit vehicles and 2005-2008 Honda Pilot vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, if not included in "Zone A" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2009 Acura RL and Honda Element vehicles, 2007-2008 Honda Fit vehicles, 2005-2008 Honda Pilot vehicles and 2006-2009 Honda Ridgeline vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, if not included in "Zone A" or "Zone B" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2008 Acura RL, Honda Element and Honda Pilot vehicles, 2007-2008 Honda Fit vehicles and 2006-2008 Honda Ridgeline vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall bagan March 2017. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KD9 and KE0.

Reported: 2018-04-26 (April 26, 2018)

Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.

Consequence: An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.

Remedy: Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are K1P, and M1O.

Reported: 2019-03-06 (March 6, 2019)

Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011 CR-V, 2003-2011 Element, 2007 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The affected vehicles received a replacement driver air bag inflator as part of a previous Takata inflator recall remedy or a replacement driver air bag module containing the same inflator type as a service part. Due to a manufacturing error, in the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode.

Consequence: An explosion of an inflator within the driver frontal air bag module may result in sharp metal fragments striking the driver, front seat passenger or other occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the driver's air bag inflator with an alternate inflator, free of charge. The recall began April 10, 2019. Honda owners may contact customer service at 1-888-234-2138. Honda's number for this recall is O41. Acura owners may contact customer service at 1-888-234-2138. Acura's number for this recall is U40.

Reported: 2019-06-27 (June 27, 2019)

Honda (American Honda Motor Co.) is recalling certain 2003 Acura 3.2CL, 2002-2003 3.2TL, 2003-2006 MDX, 2001-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot and 2006 Ridgeline vehicles. These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are Q5A and Y58.

Reported: 2019-06-27 (June 27, 2019)

Honda (American Honda Motor Co.) is recalling certain 2003-2006 Acura MDX, 2005-2012 RL, 2003-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2007-2008 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the passenger frontal airbag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are E5D and X5C.