2004 Honda PILOT: complaints, problems and recalls

LOW BEAM HEADLIGHTS DO NOT SUFFICIENTLY ILLUMINATE ROAD. *AK

Owner-reported narrative. 1,000 miles reported. Look up ODI 10052602 at NHTSA ↗

BRAND NEW HONDA PILOT EXPERIENCED ELECTRICAL PROBLEM IN THAT THE INTERIOR CAB LIGHT FOR NO APPARENT REASON WILL TURN ITSELF ON AND SHUT ITS SELF OFF AFTER APPROXIMATELY 5 TO 10 SECONDS. AUTOMATIC DOOR LOCKS NOT FUNCTIONING AS WELL AS FRONT PASSENGER WINDOW GETS STUCK AND WILL NOT GO DOWN. DEALER SERVICE SAYS POSSIBLE GHOST IN VEHICLE!! WILL BRING INTO SERVICE ON JAN 10, 2004. *LA

Owner-reported narrative. 100 miles reported. Look up ODI 10052671 at NHTSA ↗

2004 PILOT HAS SAME STARTING PROBLEMS AS 2003. IN COOL/COLD TEMPERATURE ENGINE WILL FREQUENTLY NOT TURN OVER ON THE FIRST TRY. ENGINE WILL CRANK BUT WILL NOT START. 2ND OR 3RD ATTEMPT USUALLY WORKS. EVEN WHEN THE ENGINE HAS BEEN DRIVEN AND IS COMPLETELY WARMED, THE PROBLEM STILL OCCURS. HONDA SUGGESTS TURNING THE KEY UNTIL JUST BEFORE THE ENGINE STARTS (DASH TEST LIGHTS COME ON) AND WAIT A FEW SECONDS, THEN TRY. THIS HELPS SOMETIMES, BUT IS A POOR (AND FREQUENTLY INEFFECTIVE) WAY TO START THE VEHICLE. THIS IS A WIDESPREAD PROBLEM AMONG…

Owner-reported narrative. Look up ODI 10053254 at NHTSA ↗

WHILE DRIVING AT 65 MPH CONSUMER HEARD A NOISE FROM UNDER THE VEHICLE. CONSUMER CONTINUED TO DRIVE UNTIL ANOTHER MOTORIST INDICATED THAT THERE WAS A PROBLEM WITH THE FUEL TANK. CONSUMER PULLED INTO A GAS STATION AND FOUND THAT A HOLE WAS IN THE PLASTIC FUEL TANK. MANUFACTURER AND THE DEALER WERE AWARE OF THE PROBLEM.*AK

Owner-reported narrative. 16,000 miles reported. Look up ODI 10053661 at NHTSA ↗

THE 2003 PILOT HEADLIGHTS ARE VERY WEAK AND DO NOT SUFFICIENTLY ILLUMINATE THE ROAD AHEAD. THIS CREATES A VERY SERIOUS DRIVING HAZARD ON THE FREEWAY ESPECIALLY AT SPEEDS AS HIGH AS 70 MPH. THE PILOT'S HEADLIGHTS FAIL TO ILLUMINATE THE CURVES IN THE FREEWAY, AND CONSEQUENTLY, PILOTS CAN VEER OFF THE HIGHWAY AND GET INTO CRASHES. APPARENTLY, THE HONDA COMPANY IS AWARE OF THIS PROBLEM BUT HAS CHOSEN NOT TO TAKE ANY ACTION. WE APPEAL TO NHTSA TO URGE HONDA TO RECALL AND REPLACE THE DEFECTIVE HEADLIGHTS. *JB

Owner-reported narrative. Look up ODI 10055025 at NHTSA ↗

HONDA PILOT ENGINE LIGHT KEEPS COMING ON. SINCE PURCHASE DATE OF 10-12-04 IT HAS BEEN IN THE HONDA SERVICE DEPT 3 TIMES. ENGINE LIGHT KEEPS COMING ON AND CYLINDERS ARE MISFIRING CAUSING THE PILOT TO LOSE POWER WHILE DRIVING. AFTER STOPPING AND TURNING OFF THE ENGINE FOR AWHILE IT WILL START UP AGAIN AND USUALLY THE ENGINE LIGHT WILL NOT COME ON AGAIN. THIS HAS HAPPENED 3 TIMES SINCE IT WAS IN THE HONDA SERVICE DEPT. *JB

Owner-reported narrative. 543 miles reported. Look up ODI 10056295 at NHTSA ↗

WHEN THE CONSUMER IS IN THE FRONT SEAT THE HEAD RESTRAINT TILTS FORWARD, CAUSING THE CONSUMER'S HEAD TO LEAN FORWARD. CONSUMER IS 5'3," AND SAYS HEAD RESTRAINT CANNOT BE ADJUSTED ANY LOWER. THE DEALER HAS NO REMEDY OR SUGGESTIONS FOR THIS PROBLEM. *AK

Owner-reported narrative. Look up ODI 10058042 at NHTSA ↗

FRONT PASSENGER WINDOW SHATTERED OVERNIGHT DURING DROP IN TEMPERATURE FROM 30F TO 0F. NO VISIBLE BLEMISH OR DAMAGE TO WINDOW PRIOR TO WINDOW EXPLOSION. NO INDICATION OF VANDALISM.*AK

Owner-reported narrative. 5,800 miles reported. Look up ODI 10058384 at NHTSA ↗

Reported: 2004-04-15 (April 15, 2004)

ON SOME MINI VANS, SPORT UTILITY AND PASSENGER VEHICLES, CERTAIN OPERATING CONDITIONS CAN RESULT IN HEAT BUILD-UP BETWEEN THE COUNTERSHAFT AND SECONDARY SHAFT SECOND GEARS IN THE AUTOMATIC TRANSMISSION, EVENTUALLY LEADING TO GEAR TOOTH CHIPPING OR GEAR BREAKAGE.

Consequence: GEAR FAILURE COULD RESULT IN TRANSMISSION LOCKUP, WHICH COULD RESULT IN A CRASH.

Remedy: ON VEHICLES WITH 15,000 MILES OR LESS, THE DEALER WILL UPDATE THE TRANSMISSION WITH A SIMPLE REVISION TO THE OIL COOLER RETURN LINE TO INCREASE LUBRICATION TO THE SECOND GEAR. ON VEHICLES WITH MORE THAN 15,000 MILES, THE DEALER WILL INSPECT THE TRANSMISSION TO IDENTIFY GEARS THAT HAVE ALREADY EXPERIENCED DISCOLORATION DUE TO OVERHEATING. IF DISCOLORATION EXISTS, THE TRANSMISSION WILL BE REPLACED IF DISCOLORATION IS NOT PRESENT, THE DEALER WILL PERFORM THE REVISION TO THE OIL COOLER RETURN LINE. THE RECALL BEGAN ON APRIL 21, 2004, FOR PILOT, ODYSSEY, AND MDX OWNERS. OWNERS OF THE ACCORD VEHICLES WILL START RECEIVING LETTERS ON JUNE 28, 2004, AND ON JUNE 29, 2004, FOR OWNERS OF THE TL AND CL VEHICLES. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009 OR ACURA AT 1-800-382-2238.

Reported: 2004-08-11 (August 11, 2004)

CERTAIN SPORT UTILITY VEHICLE'S CERTIFICATION LABELS MAY CONTAIN INCORRECT VEHICLE WEIGHT AND TIRE SIZE INFORMATION.

Remedy: OWNERS WILL BE REQUESTED TO INSPECT THE CERTIFICATION LABEL OR TO CONTACT A DEALER TO PERFORM THE INSPECTION FOR THEM. IF THE LABEL IS INCORRECT, OWNERS SHOULD CONTACT THEIR DEALERS TO ARRANGE TO HAVE A CORRECTION STICKER PLACED OVER THE INCORRECT INFORMATION. THIS RECALL BEGAN ON AUGUST 11, 2004. OWNERS SHOULD CONTACT HONDA AT 1-800-999-1009.

Reported: 2012-03-30 (March 30, 2012)

HONDA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2004 CR-V; MODEL YEAR 2003 THROUGH 2005 PILOT; AND MODEL YEAR 2002 AND 2003 CIVIC VEHICLES. IN MARCH 2012, HONDA FILED A DEFECT REPORT TO RECALL CERTAIN MODEL YEAR 2002 THROUGH 2004 CR-V AND CERTAIN MODEL YEAR 2003 PILOT VEHICLES. IN AUGUST 2012, HONDA INFORMED THE AGENCY THAT IT WAS INCLUDING AN ADDITIONAL 820,789 VEHICLES INCLUDING CERTAIN MODEL YEAR 2004 AND 2005 PILOTS AND MODEL YEAR 2002 AND 2003 CIVICS. THE TOTAL NUMBER OF VEHICLES BEING RECALLED IS NOW 1,375,217. DUE TO TENSION FROM THE COMBINATION SWITCH WIRING HARNESS, WEAR ON THE SURFACE OF THE ELECTRICAL TERMINAL CAN OCCUR, YIELDING COPPER OXIDE, WHICH INCREASES ELECTRICAL RESISTANCE. INCREASED ELECTRICAL RESISTANCE MAY CAUSE THE TERMINAL ENDS TO MELT WITHIN THE WIRING HARNESS CONNECTOR.

Consequence: IF THE TERMINAL ENDS MELT WITHIN THE WIRING HARNESS CONNECTOR, THE LOW BEAM HEADLIGHTS MAY BECOME INOPERATIVE, REDUCING DRIVER VISIBILITY AND INCREASING THE RISK OF A CRASH.

Remedy: HONDA WILL NOTIFY OWNERS, AND DEALERS WILL REPAIR THE LOW BEAM TERMINAL HARNESS OR REPLACE THE LIGHTING SWITCH AS NECESSARY, FREE OF CHARGE. THE ORIGINAL RECALL BEGAN IN APRIL 2012. OWNERS OF VEHICLES INVOLVED IN THE SEPTEMBER 2012 EXPANSION WILL BE NOTIFIED IN SEPTEMBER 2012. OWNERS MAY CONTACT HONDA CUSTOMER SERVICE AT 1-800-999-1009.

Reported: 2012-12-11 (December 11, 2012)

Honda is recalling certain model year 2003 and 2004 Pilot and Odyssey and 2003 through 2006 Acura MDX passenger vehicles manufactured from November 26, 2001, through August 30, 2006. The interlock lever of the ignition switch may deform, which can allow the interlock function of a vehicle with an automatic transmission to be defeated.

Consequence: Removal of the ignition key when the gear selector of a vehicle with an automatic transmission has not been shifted to the park position can allow the vehicle to roll away, increasing the risk of a crash.

Remedy: Honda will notify owners and instruct them to take their vehicle to a Honda or Acura dealer. The dealer will install an updated shift interlock lever and, if necessary, replace any necessary part of the ignition switch, free of charge. The recall began on February 22, 2013. Owners may contact Honda at 1-800-999-1009.

Reported: 2014-06-20 (June 20, 2014)

American Honda Motor Company, Inc.'s (Honda) is conducting a limited regional recall for certain model year 2003-2005 Accord, Civic, CR-V, Pilot and Acura MDX, model year 2003-2004 Odyssey and Element, and model year 2005 Acura RL, and 2006 Honda Ridgeline vehicles originally sold, or ever registered in California, and equipped with Takata-brand air bag inflators. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the passenger’s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the inflators in all affected vehicles, free of charge. The recall is expected to begin during August 2014. Owners may contact Honda customer service at 1-800-999-1009.

Reported: 2014-11-04 (November 4, 2014)

American Honda Motor Co. (Honda) is recalling certain model year 2001-2005 Honda Civic, 2003-2004 Civic CNG and Element, 2002-2005 CR-V, 2002-2004 Odyssey, 2003-2005 Accord, Pilot, Civic Hybrid, and Acura MDX, 2005 Acura RL and 2006 Honda Ridgeline vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the passenger’s frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the passenger side air bag inflator, free of charge. The recall began January 26, 2015. Owners may contact Honda customer service at 1-800-999-1009.

Reported: 2015-05-28 (May 28, 2015)

Honda (American Honda Motor Co.) is recalling certain model year 2001-2007 Accord, 2001-2005 Civic, 2001-2004 Honda Civic GX, 2003-2005 Honda Civic Hybrid, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot, 2006 Ridgeline, 2003 Acura 3.2CL, 2003-2006 Acura MDX, and 2002-2003 Acura 3.2TL vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.

Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began on July 1, 2015. Owners may contact Honda customer service at 1-888-234-2138. Owners may contact Acura customer service at 1-800-382-2238, select option 4. Note: Vehicles that have had their driver frontal air bag replaced previously as part of a recall remedy prior to September 12, 2014 need to have their air bag replaced under this recall as well. Vehicles that, on or after September 12, 2014, received a remedy for a prior driver frontal air bag inflator recall already received an inflator of a different design, and therefore are not included in this recall and do not require additional servicing. Note: This recall fully supersedes recalls 08V-593, 09V-259, 10V-041, 11V-260, 14V-351 and 15V-153. Honda's numbers for this recall are JQ9, JR0, JR1, JR2, JR3, JR4, JR5, JR6, JR7, and JR8.

Reported: 2016-05-23 (May 23, 2016)

Honda (American Honda Motor Co.) is recalling certain model year 2003-2006 Acura MDX, 2005-2011 Acura RL, 2005-2006 Honda CR-V, 2003-2011 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2011 Ridgeline vehicles originally sold, or that have ever been registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Honda is recalling certain model year 2003-2006 Acura MDX, 2005-2008 Acura RL, 2005-2006 Honda CR-V, 2003-2008 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2008 Ridgeline vehicles originally sold, or that have ever been registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Honda is recalling model year 2002-2004 Odyssey and model year 2003-2004 Acura MDX, Honda Element, and Honda Pilot vehicles originally sold, or registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began June 27, 2016. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KA0, KA1, KA2, and KA3.

Reported: 2018-04-26 (April 26, 2018)

Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.

Consequence: An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.

Remedy: Honda will notify owners, and dealers will inspect and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began June 22, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are K1P, and M1O.

Reported: 2019-03-06 (March 6, 2019)

Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011 CR-V, 2003-2011 Element, 2007 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The affected vehicles received a replacement driver air bag inflator as part of a previous Takata inflator recall remedy or a replacement driver air bag module containing the same inflator type as a service part. Due to a manufacturing error, in the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode.

Consequence: An explosion of an inflator within the driver frontal air bag module may result in sharp metal fragments striking the driver, front seat passenger or other occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the driver's air bag inflator with an alternate inflator, free of charge. The recall began April 10, 2019. Honda owners may contact customer service at 1-888-234-2138. Honda's number for this recall is O41. Acura owners may contact customer service at 1-888-234-2138. Acura's number for this recall is U40.

Reported: 2019-06-27 (June 27, 2019)

Honda (American Honda Motor Co.) is recalling certain 2003 Acura 3.2CL, 2002-2003 3.2TL, 2003-2006 MDX, 2001-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot and 2006 Ridgeline vehicles. These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the driver frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are Q5A and Y58.

Reported: 2019-06-27 (June 27, 2019)

Honda (American Honda Motor Co.) is recalling certain 2003-2006 Acura MDX, 2005-2012 RL, 2003-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2007-2008 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Honda will notify owners, and dealers will replace the passenger frontal airbag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are E5D and X5C.