1993 Ford E-150: complaints, problems and recalls

CONSUMER IS HAVING PROBLEM LOCATING A DEALERSHIP THAT CAN DO THE RECALL FOR THE LAMP AND SOCKET 94 V 128 000 ON A CONVERSION VEHICLE. CONSUMER CONTACTED THE MANUFACTURER, BUT THEY ARE NO HELP. TS *JG

Owner-reported narrative. Look up ODI 10002234 at NHTSA ↗

1993 FORD E-150 VAN LEAKS FUEL FROM TANK (NOT FILLER NECK) DURING FILLUP. UNABLE TO COMPLETELY FILL TANK BECAUSE OF THIS PROBLEM.

Owner-reported narrative. 50,000 miles reported. Look up ODI 10016837 at NHTSA ↗

A/C AND HEATER BLOWER SWITCHS ARE TO LIGHT FOR THE APLICATION ELETRICAL SYSTEM DRAWS TO MANY AMPS. BURNS UNDERDASH WIRING AND WILL CAUSE FIRES. MARKIII AND FORD BOTH USE THE SAME MANUFACTURE SWITCHS FRO THE INDAK CORP.*AK

Owner-reported narrative. Look up ODI 10043829 at NHTSA ↗

I HAVE A 1993 FORD E150 CONVERSION VAN WITH AT, ABS,PS, PW, PL, TV, VCR, AND TYPE N ENGINE (V8 5.0). I WENT TO FILL UP WITH GASOLINE AND IT APPEARS THAT THE VENT PIPE LEAKS. HAS THIS PROBLEM BEEN IDENTIFIED BY OTHER OWNERS? *JB

Owner-reported narrative. Look up ODI 10064579 at NHTSA ↗

FROM THE DATE THE CONVERSION VAN WAS PURCHASE, THE CONSUMER WAS HAVING AN ON GOING PROBLEM WITH THE STEERING. THE VAN WOULD NOT DRIVE STRAIGHT, IT WANDERED ALL OVER THE ROAD. OVER THE YEARS IN AN ATTEMPT TO CORRECT THIS PROBLEM THE BALL JOINTS AND STEERING GEAR HAS BEEN REPLACED. THE PROBLEM STILL EXISTED. *JB

Owner-reported narrative. 60,000 miles reported. Look up ODI 10096571 at NHTSA ↗

1993 FORD E150 VAN FRAME CRACKED AROUND BOLT HEADS THAT HOLD STEERING BOX ON, CAUSING ERRATIC STEERING

Owner-reported narrative. 94,200 miles reported. Look up ODI 10168396 at NHTSA ↗

FORD RECALL #05S28 INDICATES A POTENTIAL FIRE HAZARD IN MY "SPEED CONTROL DEACTIVATION SWITCH" WHICH MAY LEAK CAUSING A UNDERHOOD FIRE. FORD WANTS TO PUT A FUSE IN THE WIRING HARNESS TO PREVENT THIS FROM HAPPENING. WHY WOULD FORD NOT WANT TO CHANGE THE SCDS SWITCH THAT MIGHT BE LEAKING INSTEAD? *TR

Owner-reported narrative. Look up ODI 10200874 at NHTSA ↗

TL*THE CONTACTS OWNS A 1993 FORD E150. WHILE DRIVING 45 MPH WITH THE CRUISE CONTROL ACTIVATED, THE VEHICLE FAILED TO STOP WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT STATED THAT HE HAD TO SHIFT THE VEHICLE INTO NEUTRAL AND THEN APPLY THE BRAKES FOR THE VEHICLE TO STOP. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE FAILURE MILEAGE WAS 127,000 AND CURRENT MILEAGE WAS 128,000. UPDATED 01-16-08. *KB THE MECHANIC STATED THE PROBLEM WAS DUE TO CRUISE CONTROL FAILURE. THE CONSUMER HAS CRASHED INTO MAILBOXES CAUSING DAMAGE TO THE VEHICLE. T…

Owner-reported narrative. 127,000 miles reported. Look up ODI 10201608 at NHTSA ↗

Reported: 2007-08-03 (August 3, 2007)

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 2008-02-04 (February 4, 2008)

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Reported: 2009-10-13 (October 13, 2009)

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 1994-07-11 (July 11, 1994)

THE TRANSFORMER USED TO POWER THE NEON CENTER LIGHTBEAM CAN OVERHEAT AND CATCH ON FIRE.

Consequence: THE OVERHEATING AND FIRES CAUSED BY THE NEON TRANSFORMER CAN RESULT IN DAMAGE TO THE LIGHTBEAM ASSEMBLY, THE ROOF OF THE VEHICLE, AND COULD RESULT IN A VEHICLE FIRE.

Remedy: MARK III DEALERS WILL MODIFY THE ASSEMBLIES TO ELIMINATE THE NEON LIGHTING FIXTURE IN THE VEHICLE AND REPLACE IT WITH INCANDESCENT LIGHTS OPERATING DIRECTLY FROM THE VEHICLE 12-VOLT BATTERY.