1992 Ford E-150: complaints, problems and recalls

WHILE DRIVING AND WITH NO WARNING VEHICLE WILL STALL, AND IT WILL BE HARD FOR CONSUMER TO CONTROL VEHICLE. DEALER NOTIFIED.*AK

Owner-reported narrative. Look up ODI 10024069 at NHTSA ↗

VEHICLE CRUISE CONTROL STAYS ON WHEN IT SHOULD SHUT OFF. *LA

Owner-reported narrative. 58,800 miles reported. Look up ODI 10043452 at NHTSA ↗

ON BOTH SIDES OF THE VEHICLE, THERE ARE CRACKS IN THE STEEL FRAME. DEALER HAVE LOOKED AT THE PROBLEM, AND STATED THAT THE CRACKS WERE NORMAL. *AK

Owner-reported narrative. 100,000 miles reported. Look up ODI 10048268 at NHTSA ↗

WHILE FUELING THE VEHICLE, FUEL BEGAN LEAKING ON GROUND FROM FUEL TANK/FILLER AREA. LEAK STOPPED WHEN FUELING WAS DISCONTINUED. TOOK VEHICLE TO REPAIR SHOP AND THEY FOUND SPLIT APPROXIMATELY 3 INCHES LONG IN RUBBER FILL HOSE WHICH IS PART OF THE FUEL FILLER NECK ASSEMBLY HAD TO REPLACE THIS ASSEMBLY (AT 134,088 MILES) . HAD REPLACED THIS ASSEMBLY PREVIOUSLY AT ABOUT 90,000 MILES TO CURE A STRONG FUEL ODOR COMPLAINT. THIS FUEL HOSE SHOULD LAST FOR THE LIFE OF THE VEHICLE. IT'S FAILURE MIGHT RESULT IN FIRE HAZARD, PERSONAL INJURY OR DEATH. *LA

Owner-reported narrative. 134,088 miles reported. Look up ODI 10051086 at NHTSA ↗

WHILE PULLING, INTO A PARKING SPACE THE VEHICLE SUDDENLY ACCELERATED. THE DRIVER HAD BOTH FEET ON THE BRAKE PEDAL. THE VEHICLE CONTINUE TO ACCELERATED. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE. THE DRIVER WOULD CONTACT A DEALER WITH IN THE WEEK. PLEASE FILL IN ADDITIONAL INFORMATION.

Owner-reported narrative. Look up ODI 10073986 at NHTSA ↗

LUG NUTS ON VEHICLE WERE OVER TIGHTENED AND BROKE OFF. *BF THE CONSUMER ALSO NOTICED THAT ONE OF THE TIRES WAS LEANING FORWARD AND THE REMAINING 2 LUG NUTS WERE CRACKED. *JB

Owner-reported narrative. Look up ODI 10096731 at NHTSA ↗

LINE THAT CARRIES TRANSMISSION FLUID TO/FROM AUTOMATIC TRANSMISSION TO RADIATOR/TRANSMISSION FLUID COOLER WERE PLACED OVER A WIRE BUNDLE WRAPPED WITH A HARD RUBBER WRAP. AFTER 13 YEARS/93K MILES, THIS CONSTANT CONTACT/RUBBING BETWEEN THE WRAPPED WIRE BUNDLE AND THE AUTOMATIC TRANSMISSION FLUID LINE RESULTED IN A HOLE WEARING IN THE ATF LINE, AND SUBSEQUENT LOSS OF TRANSMISSION FLUID. ONLY BECAUSE THIS FAILURE WAS DETECTED EARLY WAS A CATASTROPHIC LOSS OF ATF FLUID AND FAILURE OF THE TRANSMISSION AVERTED. WITHOUT EARLY DETECTION, SEVERE L…

Owner-reported narrative. 93,821 miles reported. Look up ODI 10119549 at NHTSA ↗

THIS COMPLAINT IS ABOUT MILESTONE TIRES, MANUFACTURED IN CHINA, MODEL NUMBER MILESTONE RL828, G104/101S, STANDARD RIM 61/2J, SIZE LT 235/75. THREE OF THE FOUR TIRES BY THIS MANUFACTURER THAT WERE INSTALLED ON MY FORD E150 CONVERSION VAN HAVE HAD BELT FAILURES. THE TIRE THAT FAILED ON JUNE 28 HAD APPROXIMATELY 5,000 MILES ON IT, AND THE TIRE HAD JUST BEEN INFLATED TO FULL PRESSURE DURING AN OIL CHANGE APPROXIMATELY 200 MILES PRIOR TO FAILURE. THE PROBLEM WITH THESE TIRES IS APPARENTLY A BELT SEPARATION. TWO TIRES WERE REPLACED BY MY MEC…

Owner-reported narrative. 175,000 miles reported. Look up ODI 10127254 at NHTSA ↗

Reported: 2007-08-03 (August 3, 2007)

ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 2008-02-04 (February 4, 2008)

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Reported: 2009-10-13 (October 13, 2009)

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 1992-08-24 (August 24, 1992)

THE TIRE CERTIFICATION LABELS INCORRECTLY IDENTIFY THE VEHICLE TIRE REQUIREMENTS AS P235/75R15 SL (STANDARD LOAD), RATHER THAN AS P235/75R15 XL (EXTRA LOAD).

Consequence: THE CERTIFICATION LABELS ON THE AFFECTED VEHICLES DO NOTCOMPLY WITH FMVSS 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THANPASSENGER CARS." INCORRECT TIRE SELECTION COULD RESULT IN SUDDEN FAILURE OFA TIRE WHILE THE VEHICLE IS IN MOTION, AND RESULT IN A VEHICLE ACCIDENT.

Remedy: CORRECT TIRE INFORMATION LABELS AND INSTALLATION INSTRUCTIONS WILL BE MAILED TO THE OWNERS OF THESE VEHICLES. OWNERS WILL BE INSTRUCTED THAT DEALERS CAN INSTALL THE LABEL PROVIDED IF THEY PREFER.