1994 Ford E-150: complaints, problems and recalls

FUEL SMELL AFTER DRIVING. MECHANIC FOUND FUEL TANK TO BE LEAKING. HAD TO REPLACE ENTIRE FUEL TANK.

Owner-reported narrative. 124,500 miles reported. Look up ODI 10007601 at NHTSA ↗

THE VEHICLE LOST POWER STEERING AND BRAKES WHEN A LEFT TURN WAS MADE. WHICH WAS AS A RESULT OF STEERING BOX FAILURE. ALSO THE VEHICLE CAUGHT ON FIRE AND THE CONSUMER WAS INJURED. *JB

Owner-reported narrative. 130,000 miles reported. Look up ODI 10017369 at NHTSA ↗

ON MY 1994 E-150 THE BACK DOOR TIRE AREA SECURING THE TIRE TO THE DOOR HAS RUSTED HROUGH THE DOOR, AND AS A RESULT WILL NOT HOLD THE TIRE INPLACE.REAR AC UNIT DOES NOT COOL HAVE HAD REPAIR STATION LOOK AT IT. *AK AND THEY CANNOT FIND THE PROBLEM THE UNIT HAS BEEN CHARGED AND STILL DOES NOT WORK. PROBLEM WITH THE ABS LIGHT ALSO. THE LIGHT REMAINS ON AND HAVE HAD THAT LOOKED AT ALSO.

Owner-reported narrative. 87,000 miles reported. Look up ODI 10028647 at NHTSA ↗

WHILE DRIVING ON OHIO TURNPIKE VEHICLE CAUGHT ON FIRE.*MR THE CONSUMER WAS INFORMED OVER THE RADIO BY ANOTHER DRIVER THAT THE VEHICLE WAS SMOKING. WITHIN MINUTES, THE PASSENGER SIDE CAUGHT FIRE.CONSUMER PULLED OVER AND HE AND HIS WIFE TOOK THE DOGS OUT THE VEHICLE. A TRUCK DRIVER USED A FIRE EXTINGUISHER TO PUT OUT THE FLAMES. CONSUMER UNHOOKED THE TRAILER AND THE THREE OF THEM PUSHED IT AWAY FROM THE VEHICLE ABOUT 15 FEET. THE VEHICLE CAUGHT FIRE AGAIN BUT THEY COULDN'T PUT IT OUT. THE FIRE DEPT. EXTINGUISHED THE FIRE. *PH

Owner-reported narrative. Look up ODI 10048313 at NHTSA ↗

TWO DIFFERENT VEHICLES EXPERIENCED TOTAL STEERING FAILURE CAUSED BY THE STEERING BOX TEARING AWAY FROM THE FRAME OF THE VEHICLE. *PH AFTER FIRST INCIDENT, CONSUMER COULDN'T FIND A DEALER IN THEIR AREA TO REPAIR THE PROBLEM. *LA

Owner-reported narrative. Look up ODI 10062880 at NHTSA ↗

WHILE DRIVING 5 MPH STEERING GEAR BOLT SHEARED OFF. THIS FORCED THE CONSUMER TO PULL OVER AND HAVE THE VEHICLE TOWED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Owner-reported narrative. 150,000 miles reported. Look up ODI 10075892 at NHTSA ↗

WHILE DRIVING 30 MPH MASTER CYLINDER BRAKE LINE FAILED. AS A RESULT, WHEN APPLYING THE BRAKES, TPEDAL DEPRESSED TO THE FLOOR ,AND VEHICLE CONTINUED TO ACCELERATE. CONSUMER STATES IN ORDER TO SLOW THE VEHICLE DOWN TO A COMPLETE STOP HE HAD TO GO INTO SOME GRAVEL ON THE SIDE OF THE ROAD. NO IMPACT REPORTED. *AK

Owner-reported narrative. 145,380 miles reported. Look up ODI 10079896 at NHTSA ↗

RUBBER HOSE BETWEEN FILLER NECK AND FUEL TANK CRACKED AND DETERIORATED RESULTING IN FUEL SPILL DURING FILL UP. PURCHASED FORD PART NO. F7UZ-9047-BE AS A REPLACEMENT PART. CLERK AT PART COUNTER REMARKED, "WE SELL A LOT OF THESE." OLD PART IS AVAILABLE.*AK

Owner-reported narrative. 95,008 miles reported. Look up ODI 10090589 at NHTSA ↗

Reported: 2006-08-01 (August 1, 2006)

ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.

Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)

Reported: 2008-02-04 (February 4, 2008)

FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.

Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.

Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

Reported: 2009-07-29 (July 29, 2009)

R&R MOBILITY IS RECALLING 7 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS ON MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: R&R MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFT FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000.

Reported: 2009-07-29 (July 29, 2009)

R&R MOBILITY IS RECALLING 7 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEM ACCESSIBLE FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.

Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.

Remedy: R&R MOBILITY IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000.

Reported: 2009-10-13 (October 13, 2009)

FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.

Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.

Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.

Reported: 1994-05-09 (May 9, 1994)

THE MANUFACTURER'S CERTIFICATION LABEL AND/OR THE DRIVER AIR BAG ADVISORY LABEL MAY BE MISSING FROM THE VEHICLES, WHICH DOES NOT CONFORM TO THE REQUIREMENTS OF 49 CFR 567.

Consequence: CONSEQUENCE OF NON-COMPLIANCE: OWNERS OF VEHICLE WOULD BE UNAWARE OF THE LOAD CAPACITY OF THE VANS, THE VAN BUILD DATE, AND WOULD NOT HAVE ANY ASSURANCE THAT THE VANS MEET THE FEDERAL MOTOR VEHICLE SAFETY STANDARDS.

Remedy: THE LABELS WILL BE FURNISHED TO OWNER'S FOR INSTALLATION ON THE VEHICLES.

Reported: 1994-07-11 (July 11, 1994)

THE TRANSFORMER USED TO POWER THE NEON CENTER LIGHTBEAM CAN OVERHEAT AND CATCH ON FIRE.

Consequence: THE OVERHEATING AND FIRES CAUSED BY THE NEON TRANSFORMER CAN RESULT IN DAMAGE TO THE LIGHTBEAM ASSEMBLY, THE ROOF OF THE VEHICLE, AND COULD RESULT IN A VEHICLE FIRE.

Remedy: MARK III DEALERS WILL MODIFY THE ASSEMBLIES TO ELIMINATE THE NEON LIGHTING FIXTURE IN THE VEHICLE AND REPLACE IT WITH INCANDESCENT LIGHTS OPERATING DIRECTLY FROM THE VEHICLE 12-VOLT BATTERY.