2017 Chrysler PACIFICA PLUG-IN HYBRID: complaints, problems and recalls

NEW 2017 CHRYSLER PACIFICA HYBRID WITH 270 MILES STALLED ON A BUSY INTERSECTION AND WON'T TURN ON. THE VEHICLE WAS IN MOTION WHEN IT LOST POWER AND CAME TO A COMPLETE STOP. THE ENGINE SIGN IS ON AND MESSAGE SAYS "PRESS BRAKE TO PREVENT ROLLONG". TURNING OFF AND TURNING THE IT BACK ON DOES NOT MAKE THE ISSUE GO AWAY.

Owner-reported narrative. 270 miles reported. Look up ODI 10983848 at NHTSA ↗

HAD THE CAR FOR 23 HOURS. LESS THAN 5000 MILES. AFTER PULLING THE CAR TO THE END OF THE DRIVEWAY AND 3/4 OF THE WAY INTO OUR ROAD IT BEGAN TO SHAKE VIOLENTLY, SO MUCH SO THAT ONE OF OUR DAUGHTERS BURST IN TO TEARS (THE ONE THAT NEVER CRIES). THE SHAKING LASTED SOME TIME, ALONG WITH GRINDING NOISES. THE CAR FLASHED A DOZEN DIFFERENT CODES AS WELL AS INDICATING THAT THE PARKING BREAK WAS NOT AVAILABLE. THE VAN WAS COMPLETELY DEAD IN THE ROAD WITH FIVE CHILDREN INSIDE AND CARS HAVING TO SWERVE AROUND TO MAKE IT THROUGH THE NEARLY BLOCKED ROAD.…

Owner-reported narrative. 15 miles reported. Look up ODI 10991789 at NHTSA ↗

DRIVING ON INTERSTATE WHEN THE CAR BASICALLY LOST FORWARD DRIVE IN THE MIDDLE OF THE HIGHWAY. WAS IN TRAFFIC, GOING APPROXIMATELY 5MPH WITH THE ADAPTIVE CRUISE CONTROL ON, BRAKED FOR SLOWING TRAFFIC AND ON TRYING TO RE-ACCELERATE GOT NO POWER. AND DRIFTED SLOWLY TO A STOP WHILE TRYING TO RE-ENGAGE DRIVE. VEHICLE IS PHEV, WAS RUNNING ON BATTERY WITH PLENTY OF CHARGE AT THE TIME AND PLENTY OF GAS FOR HYBRID GAS ENGINE BACKUP, BUT NEITHER PROVIDED POWER. TRIED UNSUCCESSFULLY TO TURN THE CAR OFF, RESTART, RESET, ETC., BUT NOTHING WORKED DESPITE P…

Owner-reported narrative. 230 miles reported. Look up ODI 10993716 at NHTSA ↗

CHRYSLER SAYS POSSIBLE DIODE FAILURE, POSSIBLE SUDDEN LOSS OF POWER, POSSIBLE CRASH (FATAL), BUT CHRYSLER HAS NO REPLACEMENT, SAYS NOTHING CAN BE DONE UNTIL THIRD QUARTER 2017. THAT'S UNACCEPTABLE. I CAN'T DRIVE A DEATHMOBILE. MY CAR HAS NOT SHOWN SYMPTOMS, BUT THAT'S NOT THE POINT. MY VIN IS ON RECALL LIST. RECALL NOTICE ATTACHED.

Owner-reported narrative. 1,300 miles reported. Look up ODI 10994562 at NHTSA ↗

THE VAN'S ENGINE STOPPED WHILE TRAVELING AT 30 MPH ON A CITY STREET. THE AC HAD BEEN RUNNING. THE HYBRID AND ENGINE LIGHT CAME ON. THE DAY BOARD STATED I NEEDED TO PUT VEHICLE IN PARK TO START VAN. AFTER COASTING TO A STOP THE VEHICLE DID NOT RESPOND TO TRYING TO USE GEAR SELECTOR. THIS CHANGED AFTER SITTING FOR 15 MINUTES. I DROVE THE VEHICLE WITH ENGINE LIGHT AND HYBRID LIGHT THE FINAL 1 MILE HOME....UPDATED 11/06/17 *BF UPDATED 11/09/2017*JS

Owner-reported narrative. 3,800 miles reported. Look up ODI 11003939 at NHTSA ↗

JUN 07,2017 MANUFACTURER RECALL NUMBERT34 NHTSA RECALL NUMBER17V-371 RECALL STATUSRECALL INCOMPLETE, REMEDY NOT YET AVAILABLE SUMMARY INVERTER MODULE DIODE FAILURE WILL CAUSE THE VEHICLE TO QUIT OPERATING RESULTING IN A LOSS OF MOTIVE POWER. SAFETY RISK A LOSS OF MOTIVE POWER COULD CAUSE A CRASH WITHOUT WARNING. REMEDY; REPLACE POWER INVERTER MODULE. CHRYSLER WAS SUPPOSE TO RESPOND BY JULY 24, 2017 WITH A CAMPAIGN FIX BUT STILL NO ACTION ON THERE PART. RECALL NUMBER T34 ...UPDATED 11/06/17 *BF UPDATED 11/09/2017*JS

Owner-reported narrative. Look up ODI 11010673 at NHTSA ↗

FCA STATED THAT THE THEIR T34 RECALL CAMPAIGN (NHTSA RECALL #17V-371) WAS SCHEDULED TO START "ON OR ABOUT JULY 24, 2017." JULY 24, 2017 HAS COME AND GONE WITH NO UPDATES FROM FCA TO OWNERS ON THE PROPOSED FIX OR SCHEDULE FOR PARTS AVAILABILITY. THE RECALL LETTER HAS NOT YET BEEN POSTED TO THE FCA WEBSITE. THE LINK TO THE ASSOCIATED PDF FOR RECALL T34 RESULTS IN A "PAGE NOT FOUND" ERROR. THEIR CUSTOMER SERVICE LINE HAS NO FURTHER INFORMATION. THEIR DEALERS HAVE NO FURTHER INFORMATION. FCA IS NOT ADDRESSING THIS RECALL WITH AN APPROPRIATE LEVEL O…

Owner-reported narrative. Look up ODI 11010842 at NHTSA ↗

TL* THE CONTACT OWNS A 2017 CHRYSLER PACIFICA HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V371000 (HYBRID PROPULSION SYSTEM) HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED [phone removed], WAS MADE AWARE OF THE ISSUE AND WERE NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS N…

Owner-reported narrative. Look up ODI 11020036 at NHTSA ↗

Reported: 2017-06-09 (June 9, 2017)

Chrysler (FCA US LLC) is recalling certain 2017-2018 Pacifica Plug-in Hybrid Electric vehicles (PHEV). The affected vehicles have diodes in the Power Inverter Module ("PIM") that may fail due to an overvoltage condition. If the diodes fail, the vehicle will not move under its own power.

Consequence: A vehicle that suddenly cannot be driven, increases the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will reprogram the Powertrain Control Module, Battery Pack Control Module, On Board Charging Module, and PIM, free of charge. The PIM will be replaced as necessary. The recall began on September 14, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T34.

Reported: 2017-06-13 (June 13, 2017)

Chrysler (FCA US LLC) is recalling certain 2017 Pacifica Plug-in Hybrid Electric vehicles (PHEV). The tire placard on the affected vehicles incorrectly lists the seating capacity as 6 occupants rather then 7 occupants, with a combined weight of 950lbs rather than 1,100lbs. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

Consequence: The incorrect tire label may cause customer confusion, potentially resulting in vehicle overloading, increasing the risk of a crash.

Remedy: Chrysler will notify owners, and dealers will replace tire placard label, free of charge. The recall began July 6, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T37.

Reported: 2018-10-19 (October 19, 2018)

Chrysler (FCA US LLC) is recalling certain 2017-2018 Chrysler Pacifica Plug-in Hybrid Electric vehicles (PHEV). After the vehicle has been operating in PHEV propulsion mode, the gas-fueled engine may not restart properly resulting in unburned fuel entering the exhaust catalyst.

Consequence: The improperly started engine could result in a loss of motive power increasing the risk of a crash or the unburned fuel in the catalyst may ignite increasing the risk of a fire.

Remedy: FCA will notify owners, and dealers will update the powertrain controller module software, and inspect and replace the catalytic converter as necessary, free of charge. The recall began November 15, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U94.

Reported: 2020-06-09 (June 9, 2020)

Chrysler (FCA US LLC) is recalling certain 2017-2020 Pacifica Plug-in Hybrid Electric Vehicles ("PHEV"). The 12 volt isolator post located behind the driver's seat may develop high resistance.

Consequence: A high resistance electrical connection may result in the connection overheating, increasing the risk of a fire with the vehicle on or off.

Remedy: FCA will conduct a voluntary safety recall on affected vehicles to increase the torque and install a waterproof gasket to the 12v isolator post, the post will also be inspected for signs of contamination. In the event the post is compromised, the 12v isolator post and associated cables will be replaced. Until the final remedy is available, customers should bring their vehicles to dealers for an interim inspection of this joint. The recall remedy is currently under development. FCA US LLC will notify owners, and dealers will perform an interim inspection of this joint. If the inspection indicates the joint is compromised, owners will receive a loaner vehicle, until a final remedy is developed. Interim notifications are expected to begin around June 22, 2020. The recall began July 30, 2020. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is W46. Note: Consumers are advised to exercise the following precautions until the vehicle has the final repair completed: do not park these vehicles inside of buildings or structures, or near other vehicles. Additionally, keep liquids out of the backseat area, including but not limited to beverages, wet items, umbrellas, or bottled liquids that may leak.

Reported: 2022-02-11 (February 11, 2022)

Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric Vehicles (PHEV). A vehicle fire can occur when parked, even with the ignition in the "Off" position.

Consequence: A vehicle fire increases the risk of injury.

Remedy: Owners are advised not to recharge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim letters, informing owners of the safety risk were mailed on February 25, 2022. Final owner notification letters were mailed October 6, 2022. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is Z11. This recall is superseded by NHTSA recall 24V-538.

Reported: 2024-07-18 (July 18, 2024)

Chrysler (FCA US, LLC) is recalling certain 2017-2018 Pacifica Plug-In Hybrid Electric (PHEV) vehicles that received a software update remedy under NHTSA recall number 22V-077. The battery pack may cause a vehicle fire when parked, even with the ignition in the "Off" position.

Consequence: A vehicle fire increases the risk of injury.

Remedy: Owners are advised not to charge their vehicles, and to park outside and away from structures, until they are repaired. Dealers will update the high voltage battery pack control module (BPCM) software. In addition, dealers will inspect and if necessary, replace the battery pack assembly. Repairs will be performed free of charge. Interim notification letters, notifying owners of the safety risk, were mailed August 1, 2024. Owner notification letters were mailed December 12, 2024. Owners may contact FCA US LLC customer service at 1-800-853-1403. FCA US LLC's number for this recall is 73B. Vehicles previously repaired under recall 22V-077 will need to have the new remedy completed.