2020 Chevrolet SILVERADO 2500: complaints, problems and recalls

TRUCK STARTED MAKING VERY STRANGE NOISE,, CAME HOME LET TRUCK SIT, WENT TO RESTART AND ENGINE LIGHT CAME ON, TRUCK MADE VERY HORRIBLE SOUND, AND STARTED SPITTING OIL OUT OF THE SIDE OF THE BLOCK. HOLE IN BLOCK AND AT LEAST ONE PISTON DESTROYED.

Owner-reported narrative. 7,528 miles reported. Look up ODI 11318639 at NHTSA ↗

THE VEHICLE ALWAYS PULLS TO THE RIGHT. AFTER TWO INSPECTIONS AND ALIGNMENT CHECKS BY THE GM DEALER THEY STATED THAT IT IS A SOFT WEAR PROBLEM THAT THEY HAVE NO FIX FOR. IT TAKE CONSIDERABLE EFFECT TO KEEP THE VEHICLE ON THE ROADWAY. ALSO THEIR IS AN ISSUE WITH THE STEERING SYSTEM. THE STEERING WHEEL CAN BE PULLED OUT OF THE DRIVERS HAND IF A POT HOLE IS ENCOUNTERED. THERE HAS ALSO BEEN TWO SITUATION WHEN HARD BRAKING WAS REQUIRED THE VEHICLED PULLS HARD TO THE LEFT.

Owner-reported narrative. 10 miles reported. Look up ODI 11340774 at NHTSA ↗

THE TRANSMISSION LOCKED UP WHEN SLOWING DOWN AT A EXIT FROM OHIO TURNPIKE. THE VEHICLE WAS THRONE INTO A SKID JUST MISSING TWO LIGHT POLES. THE VEHICLE ONLY HAD 505 MILES ON IT ,THE DEALER INSTALLED A NEW TRANSMISSION IN IT . WE NOW HAVE 650 MILES ON IT AND HOPE THIS OR OTHER ISSUES OF SAFETY DON'T ARISE .WE HOPE THAT THERE ARE NOT OTHER TRUCKS OUT THERE WITH THIS PROBLEM .

Owner-reported narrative. 505 miles reported. Look up ODI 11341057 at NHTSA ↗

THE CAB IS LEAKING RAIN WATER IN THE BACK DRIVER SIDE CORNER OF THE CAB! I JUST NOTICED IT WHILE WE WERE DRIVING IN THE RAIN. IT LOOKS LIKE IT HAS OCCURRED TWICE BEFORE BECAUSE OF STAINS.

Owner-reported narrative. 11,300 miles reported. Look up ODI 11352124 at NHTSA ↗

AFTER OWNING THE BRAND NEW TRUCK FOR LESS THAN 24 HOURS (APPROXIMATELY 170 MILES ON THE ODOMETER OF THE VEHICLE), I WAS DRIVING IN A STRAIGHT LINE ON A 2 LANE HIGHWAY AT APPROX. 50-55MPH. MY FOOT WAS LIGHTLY ON THE ACCELERATOR, MAINTAINING SPEED, AS I HAD JUST PASSED THROUGH A TRAFFIC CIRCLE ABOUT A MILE PRIOR, AND WAS IN A SMALL LINE OF "TRAFFIC" TRAVELLING ON THE ROAD. THE REAR WHEELS BEGAN TO LIGHTLY SHAKE (IT FELT SIMILAR TO DRIVING ON RUMBLE STRIPS) FOR APPROXIMATELY 3-5 SECONDS, THEN SEVERAL WARNING LIGHTS ON THE DASH LIT UP AND THE TRUCK…

Owner-reported narrative. 171 miles reported. Look up ODI 11362314 at NHTSA ↗

VEHICLE HAS SEVERAL ELECTRICAL / COMPUTER PROBLEMS INCLUDING BUT NOT LIMITED TOO. ELECTRIC PARKING BRAKE APPLIES ITSELF AT CERTAIN TIMES. HILL START ASSIST ALSO APPLIES ITSELF AT TIMES BOTH ON LEVEL GROUND. EXCESSIVE PRESSURE NEEDED TO STOP VEHICLE COMING DOWN EXPRESSWAY RAMP WITH DIESEL EXHAUST BRAKE ON AND NO TRAILER ATTACHED. BRAKES SMELL HOT AFTER STOPPING. VEHICLE WAS STOPPED WITH ELECTRIC BRAKE PROBLEM & HILL START ASSIST. BRAKE SMELL WAS AFTER VEHICLE WAS STOPPED FROM DRIVING APPROX. 25 MILES. EXCESSIVE BRAKE PRESSURE WAS NEEDED TO STOP…

Owner-reported narrative. 1,554 miles reported. Look up ODI 11363162 at NHTSA ↗

THREE DAYS AFTER PURCHASING MY 2020 CHEVY 2500 SILVERADO, ON SEPTEMBER 28TH, 2020 AROUND 1253 I TRIED TO START MY TRUCK AND IT WOULDN'T START. THE TRUCK TURNED OVER BUT SEEMED LIKE IT WASN'T GETTING FUEL. I THEN RECEIVED A DIAGNOSTIC ALERT. AFTER CHANGING THE RELAY THE TRUCK RAN FINE. I THEN SCHEDULED TO TAKE IT IN TO THE DEALER ON OCTOBER 5,2020 TO HAVE A DIAGNOSTIC DONE ON THE TRUCK AND THEY FOUND NOTHING. THE VERY NEXT DAY IT DID THE SAME THING ON OCTOBER 6TH, 2020. I THEN SCHEDULED TO HAVE IT TAKEN IN AGAIN AND FOUND OUT THAT THE FUEL…

Owner-reported narrative. 328 miles reported. Look up ODI 11366110 at NHTSA ↗

10/26/20 WHILE TRAVELING ON THE FREEWAY FOR THE LAST FEW DAYS, I NOTICED THAT THE STEERING FELT LOOSE. I TOOK THE TRUCK TO LES SCHWAB TO HAVE THE TIRES CHECKED AS A PRECAUTION. ON 10/27/20 I INADVERTENTLY RAN OVER SEVERAL POTHOLES ON THE FREEWAY AND THE FORCE OF THE PASSENGER SIDE TIRE HITTING THE POTHOLE FORCED THE STEERING WHEEL OUT OF MY HAND. I HAVE OWED THIS VEHICLE JUST UNDER TWO WEEKS, WHICH WAS BOUGHT NEW AND CURRENTLY HAS 630 MILES ON THE ODOMETER. WHILE RESEARCHING, I CAME ACROSS ANOTHER POST WITH SIMILAR STEERING ISSUES. NOT SURE IF …

Owner-reported narrative. 630 miles reported. Look up ODI 11366768 at NHTSA ↗

Reported: 2019-11-14 (November 14, 2019)

General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2020 Silverado 2500, Silverado 3500, Sierra 2500, and Sierra 3500 vehicles equipped with carpet floor covering. When the front seat belt pretensioners deploy, hot gas may vent through an opening in the pretensioner bracket, possibly igniting the carpet.

Consequence: A vehicle fire could result if materials ignite inside the vehicle.

Remedy: GM will notify owners, and dealers will close off the opening in the pretensioner bracket, free of charge. The recall began December 13, 2019. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192270600.

Reported: 2020-03-12 (March 12, 2020)

General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The hood-latch striker wires may not have been heat-treated properly, possibly causing them to fracture.

Consequence: If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will replace the hood assembly, free of charge. The recall began April 13, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N192284960.

Reported: 2020-06-04 (June 4, 2020)

General Motors LLC (GM) is recalling certain 2020 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles previously recalled under 20V-142. Some of the vehicles in 20V-324 were not part of Recall 20V-142 but received defect parts during another service (typically during collision repair). The hood-latch striker wires on replacement hoods installed for Safety Recall 20V-142 may not have been heat-treated properly, possibly causing them to fracture.

Consequence: If a striker wire fractures, the hood may open unexpectedly while driving, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will replace the hood assembly, free of charge. For hoods sold over the counter, dealers will contact customers with instructions for hood replacement. The recall began July 7, 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202306490.

Reported: 2020-07-30 (July 30, 2020)

General Motors, LLC. (GM) is recalling certain 2020 Buick Enclave, Cadillac XT5 and XT6, Chevrolet Blazer, Silverado 1500, 2500 and 3500 and Traverse and GMC Acadia and Sierra 1500, 2500 and 3500 vehicles. The diffuser component of the Roof-Rail Air Bag (RRAB) inflator may not have been properly crimped to the inflator and could separate from the inflator during air bag deployment.

Consequence: If the diffuser separates from the inflator during deployment, RRAB performance may be degraded, increasing the risk of injury in a crash.

Remedy: GM will notify owners, and dealers will replace the suspect RRAB modules, free of charge. The recall began September 3, 2020. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-333-4223, or Buick customer service at 1-800-521-7300. GM's number for this recall is N202305380.

Reported: 2020-10-22 (October 22, 2020)

General Motors LLC (GM) is recalling certain 2019-2020 Chevrolet Silverado 1500 and GMC Sierra 1500 and 2020 Chevrolet Silverado 2500 trucks. One of the driveshaft joints may not have been properly welded, causing the driveshaft to separate while the vehicle is moving.

Consequence: If the driveshaft separates, there may be a loss of propulsion, increasing the risk of crash.

Remedy: GM will notify owners, and dealers will replace the driveshaft, free of charge. The recall is expected to begin December 2020. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-888-988-7267. GM's number for this recall is N202314870.

Reported: 2020-12-17 (December 17, 2020)

General Motors, LLC (GM) is recalling certain 2019-2021 Chevrolet Silverado 1500 and GMC Sierra 1500, 2021 Chevrolet Suburban and Tahoe and GMC Yukon XL and 2020-2021 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 vehicles. The seat belt brackets may not be secured to the seat frame in the front-row center seating position.

Consequence: If a seat-belt bracket is not secured, the seat belt may not properly restrain an occupant in the front-row center seat position, increasing the risk of injury in a crash.

Remedy: GM will notify owners, and dealers will inspect left-side and right-side front-row center seat-belt bracket attachments and reassemble it correctly as necessary, free of charge. The recall began January 26, 2021. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N202314670.

Reported: 2021-07-29 (July 29, 2021)

General Motors, LLC. (GM) is recalling certain 2020-2021 Chevrolet Silverado 2500 and GMC Sierra 2500 vehicles equipped with a 17" spare tire (RPO ZHQ or ZXT) and either the 20" accessory road tire (RPO REM) or the 18" accessory road tire (RPO Q2V). Operating the spare tire with other 20" or 18" tires can prevent the Anti-Lock Braking System (ABS) from engaging.

Consequence: An ABS system that cannot control the rear wheels independently increases the risk of a crash.

Remedy: Dealers will provide the appropriate spare tire and apply a new spare tire information label, free of charge. Owner notification letters were mailed on October 18, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020; GMC customer service at 1-800-462-8782. GM's number for this recall is N212329780.

Reported: 2024-02-01 (February 1, 2024)

General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

Consequence: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

Remedy: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232426400.

Reported: 2024-10-24 (October 24, 2024)

General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.

Consequence: Rear wheel lock-up can increase the risk of a crash.

Remedy: Dealers will install new transmission control module software, free of charge. GM will provide a special coverage program to cover the repair of transmissions that are identified by the remedy software as containing a defective control valve. Owner notification letters were mailed December 12, 2024. Owners may contact GM customer service at 1-888-988-7267, Cadillac customer service at 1-800-458-8006, GMC customer service at GMC 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242454440.

Reported: 2026-02-12 (February 12, 2026)

General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.

Consequence: Rear wheel lock up increases the risk of a crash.

Remedy: Dealers will inspect the vehicles and update the transmission control software, free of charge. Owner notification letters were mailed March 6, 2026. Owners may contact GMC customer service at 1-800-462-8782 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252516560. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on February 12, 2026.