Toyota SIENNA HYBRID problems and owner complaints

THIRD BRAKE LIGHT CONDITION POOR VISABILITY TO OPERATOR ( REAR WINDOW) WHEN BRAKE IS ACTIVATED IN LOW OR DARK LIGHTING CONDITION(S) THERE IS REFLECTION OFF GLASS AND REAR DEFROST ELEMENT(S) WHICH CAUSE LIMITED REAR VISABILITY OUT OF REAR WINDOW GLASS.

Owner-reported narrative. Look up ODI 11377621 at NHTSA ↗

The contact owns a 2021 Toyota Sienna Hybrid. The contact stated that while depressing the brake pedal, there was a three-second delay before the brakes would respond. Additionally, the brake pedal was difficult to depress, creating an extended stopping distance. The vehicle was taken to the local dealer who adjusted the brake stroke sensor and recalibrated the braking system; however, the failure persisted. The vehicle was later taken to a second dealer who bled the brake lines, but the failure persisted. The manufacturer was notified of the f…

Owner-reported narrative. 30,800 miles reported. Look up ODI 11505111 at NHTSA ↗

SRS light has been showing up on the dashboard, off and on for 3 weeks. Diagnostic reader completed by the dealership states it is an airbag module malfunction of the 2nd row left passenger seat. The seat has never been removed, there have been zero accidents and no damage to the seat or wiring.

Owner-reported narrative. Look up ODI 11740978 at NHTSA ↗

FAILURE: Blind spot monitor module failed due to a corroded internal electrical connector. The failure disabled both the Blind Spot Monitor (BSM) and Rear Cross-Traffic Alert (RCTA). Both remain inoperative. The failed component has not been replaced and is available for inspection. SAFETY RISK: Two active safety systems are disabled. The vehicle no longer warns of vehicles in the blind spot during lane changes, and no longer warns of cross traffic when backing out of parking spaces or driveways. WARNING LAMPS: Yes. Multiple warning lamps illum…

Owner-reported narrative. Look up ODI 11750096 at NHTSA ↗

The electronic driver's seat motor and track assembly failed completely on my 2021 Toyota Sienna (VIN: [XXX]) at less than 18,000 miles. The seat is permanently seized in a fixed position. This creates an immediate safety and crash-protection hazard, as drivers of different heights cannot safely adjust their distance from the steering wheel airbag or properly reach the pedals. Toyota corporate is refusing to repair this premature manufacturing defect on a known problematic seating system, leaving a severe safety risk unresolved. INFORMATION RE…

Owner-reported narrative. Look up ODI 11761587 at NHTSA ↗

I am reporting a recurring safety-related defect involving driver-assistance and steering-wheel controls on my 2022 Toyota Sienna Limited, VIN [XXX] ry 8, 2026, I brought the vehicle to Parkway Toyota in [XXX] bec [XXX] tion” warning appeared and cruise control stopped working. The dealer diagnosed the issue as related to the 12V battery, replaced the battery, and advised that the condition was resolved. The same malfunction later recurred. I returned to Parkway Toyota on March 18-19, 2026 for the same problem. I reported that the issue had r…

Owner-reported narrative. Look up ODI 11729260 at NHTSA ↗

The (PCS) Precollision System has been already set to LOW sensitivity, but every once in awhile when pulling in to oncoming traffic the vehicle would think there's still a car and just stalls for a few seconds (nonresponsive to acceleration pedal) leading to a dangerous occurrence where I could be hit by a vehicle because I've basically stopped in an active intersection. My vehicle is clean, so no dirt blocking the sensors, and I also own a 5th gen RAV4 without this issue.

Owner-reported narrative. Look up ODI 11655001 at NHTSA ↗

On June 5 th the vehicle was going approximately 50 miles per hour in the middle lane. I placed on the brakes suddenly and car lost power and stalled out. Unable to restart vehicle for 5-10 minutes on the freeway. Significant safety concern due to vehicles sudden stall out in mid the highway traffic and unable to restart car. Almost hit from behind as well as others that followed from behind. On Jun 7th vehicle was taken to the Toyota dealership and car checked by special mechanic and reported that they were unable to reproduce the stalling o…

Owner-reported narrative. Look up ODI 11669326 at NHTSA ↗

The contact owns a 2021 Toyota Sienna Hybrid. The contact stated that the vehicle was experiencing inaccurate fuel gauge readings. The contact stated while starting the vehicle, the fuel gauge reading displayed that the fuel tank was empty; however, while the contact was attempting to refuel the vehicle at the gas station, she became aware that the fuel tank was not empty and that there was sufficient fuel in the vehicle. The vehicle was taken to the CarMax dealer, where it was driven and refueled several times; however, the failure could not b…

Owner-reported narrative. 50,300 miles reported. Look up ODI 11596197 at NHTSA ↗

The contact owned a 2021 Toyota Sienna Hybrid. The vehicle was parked in the driveway when an explosion occurred; the vehicle burned down. The contact was inside the residence when a loud noise was heard, and the house "rocked." The contact ran to the front of the house to investigate and noticed that the vehicle was engulfed in flames. The fire damaged the driveway, melted the garage door, and melted a landscaping retaining wall. The fire damaged the post on the front porch. The contact and her family were unable to exit through the front door…

Owner-reported narrative. 80,000 miles reported. Look up ODI 11729036 at NHTSA ↗

We were stopped at a stoplight. As soon as we stepped on the gas pedal, there was a loud clunk sound and plastic parts started flying out from under the car. We immediately pulled over. Oil was spilling out everywhere. The transmission oil pump was laying on the inside of the engine compartment. We had towed to Toyota. They diagnosed a bent piston went through engine which also caused a hole in the transmission. I had it towed for a 2nd opinion. Neither toyota or the 2nd opinion had ever seen anything like it. My mechanic also said there are a …

Owner-reported narrative. Look up ODI 11730547 at NHTSA ↗

The contact owns a 2024 Toyota Sienna Hybrid. The contact stated that while the vehicle was parked, the transmission was shifted into reverse, and the rear end of the vehicle vibrated abnormally. The vehicle was taken to an independent mechanic but was not diagnosed or repaired. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was not available.

Owner-reported narrative. Look up ODI 11659596 at NHTSA ↗