Mazda CX-90 PLUG-IN HYBRID problems and owner complaints

Vehicle was parked in garage overnight in our house. At approximately 630AM, carbon monoxide detector alarmed indicating high CO levels inside the house. Source likely appeared to the vehicle- distinct odor of burned electrical wiring/insulation; vehicle felt warm to the touch. Vehicle was dead and would not start. Mazda app indicated critical warnings for ACTIVESENSE, hydrid battery, hydrid system malfunction, high voltage battery depletion, and charging system malfunction starting abruptly at 0210 hours and terminating at 0340 hours. Vehicl…

Owner-reported narrative. Look up ODI 11536250 at NHTSA ↗

Driving to work the dash lit up with warming signs stating electrical leak detected, Malfunction to hybrid system stop car immediately and contact dealership. Once stopped the car locked up. It would not start would not engage in to gear. There is no neutral gear bypass. We were stranded. Called Mazda roadside assistance and it took 9 hours for a tow truck to arrive. Tow truck had to drag the car up onto flatbed since there was no way to put it into gear. We we're in the city limits not out in the middle of nowhere. The car is currently at the …

Owner-reported narrative. Look up ODI 11566650 at NHTSA ↗

When radar cruise control is on, the car sometimes brakes hard totally unexpectedly when it’s about to overtake to a slower-moving vehicle in the adjacent right lane, and despite the fact that the CX-90 does not have any vehicle directly in front of it in its lane. This happens quite regularly at highway, when I am guetting within 100-200 ft of a semi located on the adjacent right lane, even when the road is at right. I almost got rear ended at 75mph by another vehicle because of that, as they did not expect my car to brake while overtaking a s…

Owner-reported narrative. Look up ODI 11551122 at NHTSA ↗

while passing a truck that is in the right hand lane, adaptive cruise control will pick up a vehicle straight ahead and hit the brakes hard. Issue - there is no vehicle in front of you. Almost got rear ended due to this issue.

Owner-reported narrative. Look up ODI 11551746 at NHTSA ↗

The contact owns a 2024 Mazda CX-90. The contact received notification of NHTSA Campaign Number: 24V022000 (Steering) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Owner-reported narrative. Look up ODI 11571072 at NHTSA ↗

On [XXX], I was driving on [XXX] near Pasadena at normal speed of traffic when suddenly an error message “Hybrid System Malfunction” appeared on the dash board along with check engine light, and the car began to stall slowing down to nearly full stop almost immediately. When I pressed gas pedal, it would not accelerate. Because I was in the far right lane, I had just about enough time to pull over onto the shoulder before the car stopped completely. The car was in EV mode (using all electric power) when this incident occurred with 20 miles …

Owner-reported narrative. Look up ODI 11573765 at NHTSA ↗

Driving up snowy pass on I-90 approaching the top of Snoqualmie Pass. Vehicle stalled and warning lights flashed critical warning and loss of power. The vehicle stopped in the middle of the highway and would not start or go into drive. After a few minutes, because of speeding and adverse conditions, another driver collided with my vehicle from behind. Another following vehicle lost control and ran off the road. Nobody was injured. Mazda has not provided any information to what happened with the vehicle. We added about 12k miles in the 5 …

Owner-reported narrative. Look up ODI 11583951 at NHTSA ↗

At 3200 miles the vehicle had a major powertrain malfunction causing the vehicle to throw multiple error codes - Hybrid System Malfunction; Charging System Malfunction; Electrical Leakage Detected. Was instructed to pull over to a safe area immediately. Was unclear how long car would continue to be drivable. Once car stopped it became completely immobile. Repeated restart attempts would not let vehicle start ICE engine or shift into gear. Had to be towed via dollies to nearest dealer for diagnosis and repair. Dealer found a failed PTC heater …

Owner-reported narrative. Look up ODI 11577948 at NHTSA ↗

July 11, 2024 – Odometer – 7,604, Gas – Full, Electric – 19 Miles range - From work to Home, Receive the following errors “Engine Malfunction, Have Vehicle Inspected” and “Hybrid System Malfunction, Have Vehicle Inspected” warning lights come on. Cars behavior – Air conditioning motor running but not cooling air, Loss of power and car very sluggish (have to be careful at intersections), seems to maintain speed even when taking foot of gas and requires extra breaking, seems to be clunky when transmission upshifts/downshifts at times. When leavin…

Owner-reported narrative. Look up ODI 11604822 at NHTSA ↗