Jayco JAY FEATHER recalls by model year

Reported: 2004-07-20 (July 20, 2004) · Model years: 2003, 2004

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH OPTIONAL 6 GALLON DSI GAS/ELECTRIC WATER HEATERS WITH REMOTELY OPERATED 110-VOLT WATER HEATER ON/OFF SWITCHING, EXCESSIVE HEAT CAN BE GENERATED AT THE WIRE CONNECTIONS TO THE WATER HEATER WHILE THE HEATER IS BEING OPERATED ON 110 VOLTS.

Consequence: THIS HAS RESULTED IN HEAT AND SMOKE DAMAGE TO THE WATER HEATER INSULATION, PLUMBING, WIRING AND WATER HEATER COMPARTMENT.

Remedy: DEALERS WILL CONDUCT A DETAILED INSPECTION OF THE WATER HEATER WIRING, REMOTE RELAY AND REMOVE ANY EXCESSIVE INSULATION AT THE CONNECTION BETWEEN THE SUPPLY LINE AND THE INTERNAL WATER HEATER WIRING IN THE WATER JUNCTION BOX. THE RECALL BEGAN ON AUGUST 12, 2004. OWNERS SHOULD CONTACT JAYCO AT 1-219-825-5861.

Reported: 2004-11-18 (November 18, 2004) · Model years: 2004, 2005

CERTAIN TRAVEL TRAILERS HAVE THE POTENTIAL FOR THE BRAKE WIRES TO BE IMPROPERLY SECURED ALONG THE TRAILER FRAME. THIS COULD LEAD TO THE BRAKE WIRES COMING IN CONTACT WITH THE AXLE MOUNTING PLATE AND CHAFING THROUGH THE PROTECTIVE INSULATION.

Consequence: THIS CONDITION MAY RESULT IN LOSS OF BRAKING, WHICH COULD LEAD TO A CRASH OR PERSONAL INJURY.

Remedy: DEALERS WILL REPLACE AND RE-ROUTE THE AXLE BRAKE WIRE TO CLEAR THE AXLE MOUNTING PLATE. THE RECALL BEGAN DECEMBER 1, 2004. OWNERS SHOULD CONTACT JAYCO AT 574-825-0608.

Reported: 2004-11-17 (November 17, 2004) · Model years: 2004, 2005

ON CERTAIN TRAVEL TRAILERS, THE FEDERAL IDENTIFICATION LABEL HAS THE INCORRECT TIRE INFLATION LISTED.

Consequence: FAILURE TO FOLLOW PROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION RECOMMENDATION CAN RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REMOVE THE INCORRECT FEDERAL IDENTIFICATION LABEL AND INSTALL A NEW CORRECTED FEDERAL IDENTIFICATION LABEL. THE RECALL BEGAN DECEMBER 2004. OWNERS SHOULD CONTACT JAYCO AT 574-825-0608.

Reported: 2017-11-21 (November 21, 2017) · Model years: 2004, 2005, 2008, 2009, 2010, 2011, 2012, 2013, 2014

Jayco, Inc. (Jayco) is recalling various 2002-2016 recreational vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V746-9524.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Jayco will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Jayco customer service at 1-800-283-8267, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Reported: 2005-11-02 (November 2, 2005) · Model years: 2005, 2006

ON CERTAIN TRAVEL TRAILERS, THE SPARE TIRE CARRIER BOLT MAY BREAK WHILE TRAVELING DOWN THE ROAD.

Consequence: THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, INJURY OR DEATH.

Remedy: DEALERS WILL REPLACE THE SPARE TIRE CARRIER FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.

Reported: 2006-01-27 (January 27, 2006) · Model years: 2005

ON CERTAIN CAMPING TRAILERS, THE HYDRAULIC BRAKE LINE P-CLAMP WAS INCORRECTLY INSTALLED. THIS MAY CAUSE THE METAL BRAKE LINE ELBOW BETWEEN THE BRAKE HOSE AND THE BACKING PLATE TO BREAK WHILE TRAVELING DOWN THE ROAD LEADING TO THE LOSS OF BRAKING CAPABILITIES.

Consequence: THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, INJURY OR DEATH.

Remedy: DEALERS WILL REMOVE THE BRAKE HOSE P-CLAMP AND REPLACE THE METAL BRAKE LINE ELBOWS FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.

Reported: 2006-08-02 (August 2, 2006) · Model years: 2007

ON CERTAIN TRAVEL TRAILERS, THE OUTLET MOUNTED A THE END OF THE KITCHEN COUNTER TOP DOES NOT MEET NFPA 70 NATIONAL ELECTRIC CODE ARTICLE 5511V NOMINAL 120 VOLT OR 120/240-VOLT SYSTEMS 551.41 (C) GROUND -FAULT CIRCUIT-INTERRUPTER PROTECTION.

Consequence: THIS COULD CAUSE AN ELECTRICAL SHORT, WHICH COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REWIRE TO A GROUND-FAULT CIRCUIT INTERRUPTER CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 24, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.

Reported: 2008-08-14 (August 14, 2008) · Model years: 2007

JAYCO IS RECALLING 265 MY 2007-2008 JAY FEATHER EXP TRAVEL TRAILERS. A P-CLAMP WAS NOT INSTALLED DURING PRODUCTION THAT WAS INTENDED TO PREVENT THE RUBBER LIQUID PROPANE (LP) LINE FROM CONTACTING THE SLIDE-OUT MECHANISM.

Consequence: IF THE P-CLAMP WAS NOT INSTALLED, THE LP LINE COULD CHAFE, WHICH COULD RESULT IN A FIRE, INJURY, OR DEATH.

Remedy: DEALERS WILL INSPECT THE P-CLAMP INSTALLATION, ADD THE P-CLAMP IF IT IS MISSING, AND REPLACE AND ROUTE CORRECTLY ANY CHAFED RUBBER LP LINE, IF NECESSARY. THE RECALL BEGAN ON AUGUST 29, 2008. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.

Reported: 2010-09-09 (September 9, 2010) · Model years: 2011

JAYCO IS RECALLING CERTAIN MODEL YEAR 2011 JAY FEATHER SELECT TRAVEL TRAILERS, SERIES X213 MANUFACTURED FROM MAY 17, 2010 THROUGH AUGUST 16, 2010 FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE FEDERAL ID LABEL AND THE TIRE AND LOADING INFORMATION LABEL HAVE AN INCORRECT TIRE PRESSURE.

Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.

Remedy: JAYCO WILL MAIL TO CONSUMERS THE CORRECTED LABELS OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 13, 2010. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.

Reported: 2010-10-21 (October 21, 2010) · Model years: 2011

JAYCO IS RECALLING CERTAIN MODEL YEAR 2011 TRAVEL TRAILERS AND FIFTH WHEELS MANUFACTURED FROM AUGUST 16, 2010, THROUGH OCTOBER 1, 2010, EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Remedy: JAYCO IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 8, 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749 OR JAYCO AT 1-574-825-0608.