Jayco GRANITE RIDGE recalls by model year

Reported: 2003-10-09 (October 9, 2003) · Model years: 2002, 2003, 2004

ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Consequence: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR JAYCO AT 1-574-825-0608.

Reported: 2006-08-30 (August 30, 2006) · Model years: 2002

ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.

Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURNING, AND IN AN UNDERHOOD FIRE.

Remedy: FORD IS CONDUCTING THIS RECALL (PLEASE SEE 06V286) AND WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR JAYCO AT 1-800-283-8267.

Reported: 2017-11-21 (November 21, 2017) · Model years: 2002, 2003, 2004, 2005, 2006

Jayco, Inc. (Jayco) is recalling various 2002-2016 recreational vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V746-9524.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Jayco will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Jayco customer service at 1-800-283-8267, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Reported: 2006-03-28 (March 28, 2006) · Model years: 2003, 2004, 2005

ON CERTAIN MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION, COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.

Consequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.

Remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.

Reported: 2006-03-31 (March 31, 2006) · Model years: 2003, 2004, 2005

CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.

Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.

Remedy: FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.

Reported: 2005-12-16 (December 16, 2005) · Model years: 2004, 2005

ON CERTAIN MOTOR HOMES, THE HITCH RECEIVER MAY HAVE MISSING REINFORCING PLATES. WHEN A LOAD IS APPLIED TO THE HITCH, IT MAY BECOME PARTIALLY DETACHED FROM THE FRAME IF THESE PLATES ARE MISSING.

Consequence: THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, PERSONAL INJURY OR DEATH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE REINFORCING PLATES WITH NEW HARDWARE. THE RECALL BEGAN ON JANUARY 10, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.

Reported: 2005-01-12 (January 12, 2005) · Model years: 2005

ON CERTAIN MOTOR HOMES THE BATTERY CABLE MAY HAVE BEEN ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD.

Consequence: THIS COULD CAUSE THE CABLE TO MELT, CREATING AN ELECTRICAL SHORT, WHICH COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND REROUTE AND/OR REPLACE THE BATTERY CABLE FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 28, 2005. OWNERS MAY CONTACT JAYCO AT 574-825-5861.

Reported: 2006-04-10 (April 10, 2006) · Model years: 2005

CERTAIN MOTOR HOMES BUILT ON FORD E-450 CHASSIS, AND EQUIPPED WITH LT225/75R16E TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES.

Consequence: AT THE INCORRECTLY STATED PRESSURE, THE REAR TIRES ARE UNABLE TO SUPPORT THE GROSS AXLE WEIGHT RATING (GAWR) FOR THE REAR AXLE.

Remedy: OWNERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT REAR TIRE INFLATION INFORMATION. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267 .

Reported: 2006-01-13 (January 13, 2006) · Model years: 2006

CERTAIN MOTOR HOMES MAY HAVE U-JOINT RETAINING CLIPS MISSING OR NOT INSTALLED PROPERLY. IF THE RETAINING CLIPS ARE NOT INSTALLED PROPERLY, THE U-JOINT MAY BECOME DISLODGED FROM THE YOKE AND THE DRIVE SHAFT WILL BECOME DISCONNECTED FROM THE DRIVE TRAIN.

Consequence: THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, INJURY OR DEATH.

Remedy: DEALERS HAVE COMPLETED THE REPAIRS TO 100 PERCENT OF THE UNITS AT THE FACTORY AND AT DEALERSHIPS. NO FURTHER ACTION IS NECESSARY ON THIS RECALL.

Reported: 2006-03-30 (March 30, 2006) · Model years: 2006

ON CERTAIN MOTOR HOMES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.

Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.

Remedy: FORD IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. ALL VEHICLES HAVE BEEN REMEDIED.

Reported: 2024-02-28 (February 28, 2024) · Model years: 2024

Jayco, Inc. (Jayco) is recalling certain 2024 Jayco Granite Ridge, Solstice, Entegra Coach Condor, Expanse, and Expanse LI motorhomes. An inadequate amount of rear axle lubricant may cause rear axle tail bearing damage and seizure, which can result in wheel lock-up or driveshaft separation.

Consequence: Wheel lock-up or driveshaft separation can result in a loss of drive power. A disconnected driveshaft can also result in a roll away when the vehicle is in park without the parking brake applied. Any of these scenarios can increase the risk of a crash.

Remedy: Dealers will inspect the rear axle and replace the axle bearings or axle assembly as necessary, free of charge. Owner notification letters were mailed April 1, 2024. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is Ford 24V-102.

Reported: 2025-03-06 (March 6, 2025) · Model years: 2024

Jayco, Inc. (Jayco) is recalling certain 2024 Entegra Condor, Jayco Granite Ridge, 2025 Jayco Alante SE, Redhawk SE, and Entegra Odyssey SE motorhomes. The Occupant and Cargo Carrying Capacity (OCCC) on the Federal label may be incorrect and allow the vehicle to be overloaded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 120, "Wheels and Rims - other than passenger cars."

Consequence: An overloaded vehicle increases the risk of a crash.

Remedy: Jayco will mail new labels, free of charge. Owner notification letters were mailed March 31, 2025. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9903622.

Reported: 2025-10-28 (October 28, 2025) · Model years: 2025, 2026

Jayco, Inc. (Jayco) is recalling certain 2025-2026 Entegra Condor and Jayco Granite Ridge motorhomes. The Certification Label may have the front and rear axle information reversed. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."

Consequence: A tire can be over or under inflated after referencing the incorrect information, increasing the risk of a crash.

Remedy: Jayco will mail correct labels to owners, free of charge. Owner notification letters were mailed November 7, 2025. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9903641.

Reported: 2026-04-28 (April 28, 2026) · Model years: 2026

Jayco, Inc. (Jayco) is recalling certain 2026 Entegra Condor and Jayco Granite Ridge motorhomes. The tempering mixing valve may not have been installed on the water heater.

Consequence: The water could reach scalding temperatures without the mixing valve, increasing the risk of injury.

Remedy: Owners are advised to turn on the cold water first until the repairs are complete. Dealers will install the valve, free of charge. Owner notification letters were mailed May 1, 2026. Owners may contact Jayco customer service at 1-800-283-8267. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 28, 2026.

Reported: 2026-06-03 (June 3, 2026) · Model years: 2026

Jayco, Inc. (Jayco) is recalling certain 2026 Entegra Qwest SE, Condor, Jayco Granite Ridge, and Melbourne recreational vehicles. The taillight warning light may incorrectly illuminate on the instrument panel display when the taillights are functioning correctly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."

Consequence: The incorrect warning light may fail to alert the driver to critical safety information or cause confusion, increasing the risk of a crash.

Remedy: Dealers will replace the taillight harness, free of charge. Owner notification letters were mailed June 18, 2026. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9903657 .