2010 Volvo XC70: complaints, problems and recalls

MY VOLVO X70 2010 STATION WAGON HAS HAD A NUMBER OF INCIDENTS WHERE THE CAR TRANSMISSION "JUMPS" WHILE THE GAS PEDAL IS NOT ENGAGED. IT SEEMS THAT WHEN THE ENGINE IS AT IDLE, AT A STOP OR DURING A SLOW TURN, THE CAR SLIGHTLY AND SUBTLY JUMPS A BIT. MY VOLVO DEALER HAS ATTEMPTED TO "UPGRADE" THE SOFTWARE BUT THE PROBLEM, ALTHOUGH SPORADIC, RECURS. I AM CONCERNED THAT THERE IS A DEFECTIVE ISSUE HERE AND THAT OTHER POTENTIAL DANGEROUS PROBLEMS MAY ARISE IN THE FUTURE. *TR

Owner-reported narrative. 3,500 miles reported. Look up ODI 10324823 at NHTSA ↗

SRS - AIR BAG LIGHT CAME ON AFTER 1,000 MILES. *TR UPDATED 10/20/10 *BF UPDATED 10/22/10

Owner-reported narrative. 1,065 miles reported. Look up ODI 10331599 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 VOLVO XC70. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, SHE REALIZED THAT SMOKE WAS COMING FROM THE AIR VENTS. THE CONTACT MERGED ONTO THE EXIT RAMP AND STOPPED THE VEHICLE. THE CONTACT THEN EXITED THE VEHICLE AND NOTICED FLAMES COMING FROM THE ENGINE. THE FIRE DEPARTMENT WAS NOTIFIED AND EXTINGUISHED THE FIRE. THE CONTACT WAS TAKEN TO THE EMERGENCY ROOM TO TREAT INJURIES RESULTING FROM INHALING LARGE AMOUNTS OF SMOKE. NO OTHER PERSONS WERE INJURED. THE FIRE DEPARTMENT HAD THE VEHICLE TOWED BECAUSE IT WAS NOT DRIVE…

Owner-reported narrative. 17,000 miles reported. Look up ODI 10462970 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 VOLVO XC70. WHILE DRIVING APPROXIMATELY 80 MPH, THE REAR PASSENGER SIDE TIRE DEFLATED SUDDENLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT ALL FOUR VALVE STEMS WERE CRACKED AND WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 22,000.

Owner-reported narrative. 22,000 miles reported. Look up ODI 10485820 at NHTSA ↗

DRIVING ON THE INTERSTATE HIGHWAY THERE WAS A SUDDEN LOSS OF TIRE PRESSURE. THIS WAS CAUSED BY A FAILURE OF THE TIRE PRESSURE VALVE DUE TO CORROSION OF THE METAL. THE NEW VALVES ARE MADE OF PLASTIC. HOWEVER, THE ISSUE IS THAT ONE DOESN'T KNOW ABOUT THE PROBLEM UNTIL IT OCCURS. IF THE FRONT TIRE HAD LOSS PRESSURE THERE MAY HAVE BEEN A WORSE INCIDENT. THIS HAD PREVIOUSLY OCCURRED ABOUT 6 MONTHS EARLIER WITH ANOTHER TIRE. I STOPPED TO ADD AIR TO A TIRE AND DISCOVERED THAT THE VALVE WAS PUSHED INTO THE TIRE WHEN TRIED TO APPLY THE AIR HOSE. …

Owner-reported narrative. 84,100 miles reported. Look up ODI 10515125 at NHTSA ↗

I HAD JUST PICKED UP THE CAR FROM THE VOLVO DEALERSHIP WHERE THE CAR WAS THERE FOR TWO WEEKS. I STOPPED FOR GAS AND DID SOME SHOPPING AND AS I WAS ENTERING HIGHWAY THE 'TIRE PRESSURE LOW' WARNING LIGHT CAME ON. I THOUGHT IT WAS PROBABLY DUE TO WORK THAT WAS DONE IN THE SHOP. I ENTERED THE HIGHWAY AND AS I WAS SPEEDING UP, I NOTICED THE NOISE COMING FROM THE WHEELS, NOTICED THAT THERE WAS A FLAT. THE FLAT WAS DUE TO TPMS VALVE STEM FAILING AND AS I WAS TOLD LATER BY THE DEALERSHIP, THE LOSS OF AIR WAS VERY QUICK AND THE 13 MONTH OLD TIRE WAS DAM…

Owner-reported narrative. 35,000 miles reported. Look up ODI 10523225 at NHTSA ↗

THERE IS A VOLVO RECALL 226 (NHTSA CAMPAIGN #10V190000) TO REPLACE AN INCORRECT FMVSS LABEL THAT SHOWS TIRE PRESSURE OF 33 PSI AND TO REPLACE A PAGE IN THE OWNERS MANUAL THAT SHOWS THE PRESSURE SHOULD BE 35 PSI. THE CORRECT PRESSURE IS 36 PSI. THIS IS INFORMATION IS ALSO CONTAINED IN A LETTER FROM VOLVO TO NHTSA DATED 4 MAY 2010 (10V-190 3 PAGES). ACCORDING TO VOLVO, OUR XC70 (MFD 8/09) IS NOT PART OF THIS RECALL. HOWEVER, THE TIRE PRESSURE ON THE FMVSS LABEL AND LISTED IN THE OWNERS MANUAL MATCH THE INFORMATION IN THE RECALL. SINCE THE …

Owner-reported narrative. Look up ODI 10585438 at NHTSA ↗

CAR JACK FAILED DURING TIRE CHANGING. THE CAR JACK FAILED CAUSING JACK TO BEND. *TR

Owner-reported narrative. 60,230 miles reported. Look up ODI 10615718 at NHTSA ↗

Reported: 2009-09-01 (September 1, 2009)

VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.

Consequence: IF THE VEHICLE STALLS IN CERTAIN CONDITIONS, A CRASH COULD OCCUR.

Remedy: DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Reported: 2010-05-07 (May 7, 2010)

VOLVO IS RECALLING CERTAIN MODEL YEAR 2010 XC70 VEHICLES MANUFACTURED FROM DECEMBER 5, 2006 THROUGH OCTOBER 1, 2009 FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE FMVSS LABEL, TIRE AND LOADING INFORMATION LABEL AND A PAGE IN THE OWNER'S MANUAL CONTAIN INCORRECT MAXIMUM PERMISSIBLE INFLATION PRESSURE ACCORDING TO FMVSS 110.

Consequence: THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.

Remedy: THE CORRECTIVE ACTION IS TO UPDATE THE VEHICLES WITH A NEW FMVSS LABEL, TIRE AND LOADING INFORMATION LABEL AND TPMS SOFTWARE. VOLVO RETAILERS WILL ALSO APPLY A LABEL WITH CORRECT MAXIMUM TIRE PRESSURE INFORMATION TO THE OWNER'S MANUAL. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 14, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Reported: 2010-10-13 (October 13, 2010)

VOLVO IS RECALLING CERTAIN MODEL YEAR 2010-2011 S80, XC70, MODEL YEAR 2011 XC60 AND MODEL YEAR 2010 V70 VEHICLES. THERE MAY BE AN INTERMITTENT FAULT IN THE DRIVER'S AIRBAG CLOCKSPRING WIRING CONNECTOR FOR THE SUPPLEMENTAL RESTRAINT SYSTEM.

Consequence: IN THE EVENT OF A CRASH, THE DRIVER'S FRONTAL AIRBAG MAY NOT DEPLOY AS INTENDED OR AT ALL, AND THEREFORE WILL NOT BE ABLE TO PROPERLY PROTECT THE DRIVER, INCREASING THE RISK OF INJURIES.

Remedy: DEALERS WILL INSTALL A METAL SHIM IN THE DRIVER'S AIR BAG CLOCKSPRING WIRING CONNECTOR. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 20, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

Reported: 2010-11-08 (November 8, 2010)

VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.

Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.

Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

Reported: 2020-06-30 (June 30, 2020)

Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.

Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.

Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.