2023 Toyota RAV4: complaints, problems and recalls

Yesterday I drove an hour in the rain for the first time in my brand new 2023 rav4. I pulled into a parking lot, put it in park and all of the sudden my car starting stuttering/jerking/jolting the whole car, the rpm's were fluttering up and down between 2-3, the car engine turned on and off and car felt very weird. Check engine light and yellow explanation symbol came on with message " Engine stopped steering power low" and turned car off. Then I turned it back on and it was doing the same thing jolting me forward with the same message and als…

Owner-reported narrative. Look up ODI 11499456 at NHTSA ↗

Was driving and made a stop at the stop sign. Vehicle stalled, got a message that the engine had shut off. Would not restart in the middle of an intersection. Engine would not turn over after stall.. Dealer was unable to replicate issue but said that the computer had thrown codes.

Owner-reported narrative. Look up ODI 11515720 at NHTSA ↗

I paid for option on my vehicle but it was not installed in the factory. The software shows to be installed on my car. I alerted the sales person numerous times. I told the car had to be moving faster than 40 miles per hour to activate the pre- collision system and it still doesn’t work. This safety issue of the vehicle.

Owner-reported narrative. Look up ODI 11518271 at NHTSA ↗

Panoramic sunroof. First one is fine, back one exploded. All around the edges is a very distinct crack in a connected line. There was minimal traffic, and I was the only other vehicle on the interstate with a good 4 car length between me and the next car which was 2 lanes over. I didn’t see or hear anything other than the “gunshot” sounding explosion. No wind or hail or anything, skies were clear, I was going about 60 on the interstate. It freaked me out. Luckily, I did not swerve or change my driving (slam on brakes etc), but with another pers…

Owner-reported narrative. Look up ODI 11520009 at NHTSA ↗

For the last six months our vehicle has had it's infotainment system malfunction. It shuts off unexpectedly while driving or stopped. It shuts off and on repeatedly as if car is turning on and off. The bright warning sign will show and proceed to act normal then again 5-10 seconds later it shuts off again. This issue happens with and without a phone connected to it via bluetooth. While screen off the rear view camera does not work and nothing else is operable within the screen/ infotainment system. We've brough car to dealership three times i…

Owner-reported narrative. Look up ODI 11525670 at NHTSA ↗

Passenger seat is too high even for a short person and cannot be adjusted.when i get out of the car i hit my head and this can happen often.

Owner-reported narrative. Look up ODI 11528044 at NHTSA ↗

When using an Apple iPhone 12 connected to the vehicle's head unit with CarPlay, and when using any navigation application (Apple Maps, Waze, Google Maps), the car's GPS position on the map randomly becomes extremely inaccurate. The car's map cursor suddenly jumps to a different road than the one the vehicle is on, heads in the wrong direction, or circles wildly. If using the GPS application for directions, the directions suddenly become incorrect. The issue never occurs when the iPhone is not connected to the vehicle's CarPlay display. Thi…

Owner-reported narrative. Look up ODI 11529829 at NHTSA ↗

When the AC is turned on, the AC is not blowing cold AC air. Have turned on the AC to the lowest temperature setting, turned the fan to high, activated the circulation button and it’s only blowing room temperature/warm air. Have tried different combinations of the settings and the AC quality is still only blowing room temperature/warm air. Have driven car to hotter temperature areas and the AC, at this point, is blowing warm/hot air.

Owner-reported narrative. Look up ODI 11533478 at NHTSA ↗

Reported: 2023-07-11 (July 11, 2023)

Gulf States Toyota, Inc. (GST) is recalling certain 2023 Toyota RAV4 vehicles equipped with 17" black alloy accessory wheels. During installation of the alloy wheels, the tire valve stem may have been improperly installed or damaged. In addition, the load carrying capacity label may state the incorrect weight. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."

Consequence: A damaged or improperly installed valve stem may allow air to leak and/or the tires to be underinflated, increasing the risk of tire failure and a crash.

Remedy: Dealers will inspect and, if necessary, replace the wheel valve stems and replace the load carrying capacity modification labels, free of charge. Owner notification letters were mailed on August 18, 2023. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 23R1.

Reported: 2025-09-11 (September 11, 2025)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2023-2024 Toyota Venza, 2023-2025 RAV4 Prime, RAV4, Highlander, GR Corolla, Crown, 2024-2025 Lexus TX, LS, Toyota Tacoma, Grand Highlander, and 2025 Lexus RX, Toyota Crown Signia, Camry, RAV 4 Plug-in Hybrid (PHEV), and 4 Runner vehicles. Due to an error in the instrument panel software at vehicle startup, the instrument panel may fail to display vehicle speed, brake system, and tire pressure warning lights.

Consequence: An instrument panel display that does not show critical information can increase the risk of a crash or injury.

Remedy: Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.

Reported: 2025-10-30 (October 30, 2025)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2022-2026 Toyota, Lexus, and Subaru Solterra vehicles equipped with a Panoramic View Monitor (PVM) system. Please see the recall report for a complete list of models. A software error may cause the rearview camera to freeze or display a blank screen when the vehicle is in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence: A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.