1998 Pontiac SUNFIRE: complaints, problems and recalls

CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEM WITH THE VEHICLE SEAT BACK COLLAPSE. DEALER HAS BEEN NOTIFIED. TS VEHICLE WAS REAR-ENDED AND SEAT BACKS WERE THROWN FORWARD THEN COLLAPSED INTO RECLINE POSITION. DRIVER AND PASSENGER SUSTAINED INJURIES. *TT

Owner-reported narrative. Look up ODI 10001269 at NHTSA ↗

THE REAR SEAT BELTS WHEN CAR IS COLD WILL NOT COME OUT. THIS HAS BEEN AN ONGOING ISSUE, WITH SMALL CHILDREN THAT NEED TO BE SEATBELTED.

Owner-reported narrative. 64,000 miles reported. Look up ODI 10005710 at NHTSA ↗

THE DRIVER SIDE WHEEL LOCK UP CAUSING A ACCIDENT. PLEASE FILL IN ADDITIONAL INFORMATION. DEALER IS AWARE OF THE PROBLEM. PH

Owner-reported narrative. Look up ODI 10006264 at NHTSA ↗

RECALL #02-V-286-000 THE RECALL REGARDING THE RACK AND PINION FAILED, AFTER THE RECALL WAS PERFORMED.*JB

Owner-reported narrative. Look up ODI 10011116 at NHTSA ↗

ON 9/5/02 MY CAR WAS INVOLVED IN AN ACCIDENT WHICH TOTALLY DESTROYED IT. ACCIDENT WAS CAUSED WHEN I WAS SLOWLY MAKING A LEFT TURN, SUDDENLY I EXPERIENCED LOSS OF POWER MAKING IT VERY HARD TO MANEUVER CAR DUE TO HIGH RESISTANCE. I WAS GOING SOUTH, AND WHEN I STARTED TO MAKE LEFT TURN, NORTH BOUND WAS FREE AND CLEAR, BUT BECAUSE THE LENGTH OF TIME I SPENT TRYING TO CONTROL MY VEHICLE, ANOTHER CAR GOING NORTH APPROACHED THE INTERSECTION WHERE I WAS AND COULD NOT AVOID HITTING THE OTHER CAR CAUSING THE CRASH. I SPENT MY ENTIRE SAVINGS TO PURCHASE T…

Owner-reported narrative. 51,000 miles reported. Look up ODI 10014345 at NHTSA ↗

MARCH 24, 2003 DEAR SIRS, I RECENTLY HAD A WATER PUMP FAILURE ON MY 1998 SUNFIRE CONVERTIBLE. THE CAR HAS HAD A NOISE FROM THE FRONT OF THE ENGINE FOR ABOUT A YEAR, I THOUGHT IT WAS AN ALTERNATOR BEARING. THE CAR HAS BEEN IN A GM DEALER TWICE IN THAT TIME FOR OIL CHANGES AND OF ALL THE THINGS THE DEALER HAS TRIED TO SELL ME THEY NEVER SAID ANYTHING WAS WRONG WITH THE WATER PUMP. ON THE NIGHT OF FRIDAY, MARCH 14TH THE CAR BEGAN LEAKING ANTIFREEZE AND THE NOISE INCREASED. I LIVE IN SOUTH LYON, MI AND THE CLOSEST PONTIAC DEALER IS WALDECKER IN …

Owner-reported narrative. 42,000 miles reported. Look up ODI 10016442 at NHTSA ↗

MY DAUGHTER WAS DRIVING MY 1998 PONTIAC SUNFIRE AND HAD A COLLISION WITH ANOTHER CAR. SHE REPORTED THAT THE BRAKES FAILED AND WOULD NOT STOP THE CAR AT ALL. WE HAVE ALSO REPORTED TO THE DEALER ON MULTIPLE OCCASIONS THAT THE GAS PEDAL GETS STUCK. THIS MAY HAVE ALSO CONTRIBUTED TO THE COLLISION. *NLM

Owner-reported narrative. 77,000 miles reported. Look up ODI 10020534 at NHTSA ↗

CONSUMER WAS HAVING PROBLEMS WITH THE EGR VALVE. DEALER NOTIFIED. *AK WHILE DRIVING THE EGR VALVE BECAME STUCK IN THE OPEN POSITION WHICH CAUSED THE ENGINE TO ROUGH OR STALL WITHOUT WARNING. *PH *NLM

Owner-reported narrative. 52,000 miles reported. Look up ODI 10029932 at NHTSA ↗

Reported: 2002-11-04 (November 4, 2002)

CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.

Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.

Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.

Reported: 2004-01-27 (January 27, 2004)

ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.

Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED. THE FIRE COULD SPREAD TO THE INTERIOR OF THE CAR, WHICH COULD INJURE OCCUPANTS OR CAUSE DAMAGE TO ADJOINING STRUCTURES.

Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH, AND CHECK THAT YOUR CAR WILL START WITH A PROPERLY CHARGED BATTERY AND, IF NECESSARY, REPLACE THE IGNITION SWITCH. OWNER NOTIFICATION WILL BEGIN ON MARCH 1, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, BUICK AT 1-866-608-8080, OR OLDSMOBILE AT 1-800-630-6537. CUSTOMERS CAN ALSO CHECK THEIR VEHICLE ONLINE BY GOING TO WWW.MYGMLINK.COM AND ENTERING THE VEHICLE'S IDENTIFICATION NUMBER.

Reported: 1997-11-24 (November 24, 1997)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE WHEEL LUG NUTS WERE NOT TIGHTENED SECURELY RESULTING IN A FRACTURE OF THE WHEEL STUDS.

Consequence: THE WHEEL COULD SEPARATE FROM THE VEHICLE. IF THE VEHICLE WERE IN MOTION, A VEHICLE CRASH COULD RESULT.

Remedy: DEALERS WILL INSPECT THE TORQUE OF ALL WHEEL NUTS AND, IF NECESSARY, TIGHTEN ANY THAT MAY BE BELOW REQUIRED TORQUE.