1986 Mercury SABLE: complaints, problems and recalls

AFTER DRIVING AND COMING TO A STOP THE AUTOMATIC TRANSMISSION GOES INTO NEUTRAL. STEPPING ON THE GAS PEDAL CAUSED THE TRANSMISSION TO REV UP QUITE HIGH WHILE STILL STAYING IN NEUTRAL UNTIL, SUDDENLY THE TRANSMISSION WILL KICK INTO GEAR AND "BURN RUBBER" CAUSING THE CAR TO LURCH FORWARD IN AN "UNCONTROLLED" WAY AT HIGH SPEED. *NLM

Owner-reported narrative. 111,000 miles reported. Look up ODI 10023181 at NHTSA ↗

SHOULDER BELT CUTS ACROSS DRIVER'S THROAT (OTHER VEHICLE FROM 484009). *AK

Owner-reported narrative. Look up ODI 479934 at NHTSA ↗

RIGHT FRONT HUB CRACKED, CAUSING VIBRATION/NOISE. *SKD

Owner-reported narrative. Look up ODI 480493 at NHTSA ↗

SEAT BELT BUCKLES FAIL TO RETRACT. *SKD

Owner-reported narrative. Look up ODI 482234 at NHTSA ↗

REPLACED TRANSMISSION PLANETARY ASSEMBLY TWICE. *AK

Owner-reported narrative. Look up ODI 483367 at NHTSA ↗

HEAD BOLT SHEARED OFF, CAUSING VEHICLE TO STALL.

Owner-reported narrative. Look up ODI 489070 at NHTSA ↗

TRANSMISSION SLIPS, ALSO FAILS TO PROPERLY SHIFT GEARS. *DSH

Owner-reported narrative. Look up ODI 500638 at NHTSA ↗

WIRING HARNESS TERMINAL BLOCK IN STEERING COLUMN SHORTED, CAUSING FIRE. *DSH

Owner-reported narrative. Look up ODI 504040 at NHTSA ↗

Reported: 1985-12-26 (December 26, 1985)

Consequence: IF THE CAR IS LEFT UNATTENDED WITH THE KEY REMOVED AND THE IGNITION SWITCH NOT IN LOCK POSITION, THE CAR CAN BE EASILY STOLEN. STUDIES HAVE SHOWN THAT STOLEN CARS ARE FREQUENTLY INVOLVED IN ACCIDENTS.

Remedy: IGNITION LOCK SWITCH CYLINDER WILL BE REPLACED.

Reported: 1986-03-10 (March 10, 1986)

THE RIGHT QUARTER WINDOWS MAY CONTAIN GLASS WHICH WAS IMPROPERLY TEMPERED. THIS GLASS MAY YIELD PIECES LARGER THAN THE MAXIMUM ALLOWED BY FMVSS 205, GLAZING MATERIAL. CONSEQUENCE OF DEFECT: IN CASE OF AN ACCIDENT THESE LARGE PIECES OF GLASS MAY SERIOUSLY INJURE THE OCCUPANTS OF THE CAR.

Remedy: REPLACE THE QUARTER WINDOWS CONTAINING DATE CODE 5 AF.

Reported: 1987-02-19 (February 19, 1987)

ROAD SALT INDUCED EROSION OF THE WIPER MOTOR CONDUCTOR STRIPS COULD CAUSE LOCALIZED THERMAL STRESS WITHIN THE GLASS.

Consequence: GLASS COULD FRACTURE WHILE STATION WAGON IS BEING DRIVENOR PARKED, CREATING A RISK OF INJURY TO OCCUPANTS OR SUDDEN DISTRACTION TO THEDRIVER.

Remedy: APPLY SEALANT TO CONDUCTOR STRIPS AND PROTECTIVE TAPE TO LOWER BACKLITES.

Reported: 1987-09-04 (September 4, 1987)

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

Consequence: COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

Reported: 1991-08-06 (August 6, 1991)

FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.

Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.

Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.

Reported: 1992-05-11 (May 11, 1992)

CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.

Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.

Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.

Reported: 1993-06-23 (June 23, 1993)

VEHICLE DESCRIPTION: TAURUS AND SABLES BUILT FROM 10-14-85 THROUGH 8-19-88, AND LINCOLN CONTINENTALS BUILT FROM 11-4-87 THROUGH 9-30-88 (EXCEPT 1989 - 1991 2.5L TAURUS AND 1989 - 1992 SHO). THE AFFECTED CARS WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WISCONSIN. THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, MAY BECOME DETACHED DUE TO CORROSION OF THE SUBFRAME MOUNT RETAINING PLATE. THIS WOULD ALLOW THE REAR CORNERS OF THE SUBFRAME TO DROP.

Consequence: IF ONE OF THE REAR CORNERS DROPS, ONLY MINOR INDICATIONS OF A MALFUNCTION SUCH AS A CLUNKING NOISE OR SLIGHT CHANGE IN STEERING WHEEL ALIGNMENT ARE NOTICEABLE. HOWEVER, IF BOTH REAR CORNERS OF THE SUBFRAME DROP, STEERING BECOMES VERY DIFFICULT, WHICH COULD ADVERSELY AFFECT VEHICLE CONTROL AND POSSIBLY RESULT IN AN ACCIDENT.

Remedy: INSTALL A CORROSION-RESISTANT REINFORCING PLATE AND A NEW BOLT ON BOTH REAR SUBFRAME MOUNTS. THIS RECALL CAMPAIGN HAS BEEN SUPERSEDED BY RECALL 98V-323.

Reported: 1998-12-16 (December 16, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.

Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.