1987 Mercury SABLE: complaints, problems and recalls

DRIVERS SEAT BROKE LOOSE FROM MOUNT. SEAT ROCKS FORWARD AND BACK. DOOR AJAR LIGHT STAYS ON ALL THE TIME. DOORS ARE CLOSED. FUEL GAUGE INACCURATE.*AK

Owner-reported narrative. 131,000 miles reported. Look up ODI 10068472 at NHTSA ↗

WHILE DRIVING 65 MPH AND WHEN DEPRESSING THE BRAKES CONSUMER WAS UNABLE TO STOP THE VEHICLE. THIS CAUSED A REAR END COLLISION. DRIVERS SIDE SEAT BELT UNLATCHED, AND DRIVER SUSTAINED INJURIES. *AK

Owner-reported narrative. Look up ODI 10083215 at NHTSA ↗

VEHICLE EXPERIENCED SAME PROBLEM AS NHTSA 98V323000. SUBFRAME BUSHINGS BROKE LOOSE CAUSE NEAR ACCIDENT AND LOSS OF STEERING. LOCAL FORD MOTOR COMPANY DENIED TO FIX BECAUSE OF VIN NUMBER.

Owner-reported narrative. Look up ODI 10159162 at NHTSA ↗

TRANSMISSION FAILED AND LEAKED AFTER REPAIRS. *AK

Owner-reported narrative. Look up ODI 481151 at NHTSA ↗

FRONT/RIGHT POLYCAST MELTED, SEPARATED FROM STEEL PORTION OF WHEEL. *SKD

Owner-reported narrative. Look up ODI 484314 at NHTSA ↗

A/C FAILURE.

Owner-reported narrative. Look up ODI 489044 at NHTSA ↗

TIRE JACK BECAME AIRBORNE IN ACCIDENT.

Owner-reported narrative. Look up ODI 501017 at NHTSA ↗

IGNITION SWITCH BURNED, CAUSING DASHBOARD INSTRUMENTS TO FAIL. *DSH

Owner-reported narrative. Look up ODI 503796 at NHTSA ↗

Reported: 1986-10-28 (October 28, 1986)

STEERING SHAFT ASSEMBLIES CONTAIN LOWER SHAFTS OF INSUFFICIENT LENGTH FOR PROPER ATTACHMENT TO THE SHAFT INSULATOR FLANGE. CONSEQUENCE OF DEFECT: SHAFT COULD SEPARATE, RESULTING IN TOTAL LOSS OF STEERING CONTROL AND A POSSIBLE ACCIDENT.

Remedy: REPLACE STEERING SHAFT ASSEMBLY, AS NECESSARY.

Reported: 1986-11-07 (November 7, 1986)

LEFT AND/OR RIGHT REAR SPINDLE ASSEMBLIES MAY HAVE BEEN IMPROPERLY HEAT TREATED. CONSEQUENCE OF DEFECT: IF SPINDLE STEM SEPARATES, LOSS OF VEHICLE CONTROL COULD OCCUR WITHOUT PRIOR WARNING.

Remedy: REPLACE REAR SPINDLE.

Reported: 1987-02-19 (February 19, 1987)

ROAD SALT INDUCED EROSION OF THE WIPER MOTOR CONDUCTOR STRIPS COULD CAUSE LOCALIZED THERMAL STRESS WITHIN THE GLASS.

Consequence: GLASS COULD FRACTURE WHILE STATION WAGON IS BEING DRIVENOR PARKED, CREATING A RISK OF INJURY TO OCCUPANTS OR SUDDEN DISTRACTION TO THEDRIVER.

Remedy: APPLY SEALANT TO CONDUCTOR STRIPS AND PROTECTIVE TAPE TO LOWER BACKLITES.

Reported: 1987-09-04 (September 4, 1987)

SPRING LOCK FUEL LINE COUPLING MAY NOT BE PROPERLY ENGAGED.

Consequence: COUPLING COULD DISENGAGE DUE TO FUEL PRESSURE,VIBRATION, AND ENGINE MOVEMENTS; THIS WOULD CAUSE LOSS OF FUEL WHICH, INPRESENCE OF AN IGNITION SOURCE, CREATES A FIRE RISK.

Remedy: INSTALL RETAINER CLIPS OVER THE COUPLINGS TO PREVENT COUPLING SEPARATION AND FUEL LEAKAGE.

Reported: 1991-08-06 (August 6, 1991)

FRONT DISC BRAKE ROTORS OF THE SUBJECT VEHICLES MAY EXPERIENCE SEVERE CORROSION IF OPERATED IN AREAS WHERE CALCIUM CHLORIDE AND SODIUM CHLORIDE ARE USED EXTENSIVELY.

Consequence: SEVERELY CORRODED ROTORS MAY FRACTURE OR SEPARATE NEARTHE INNER EDGES OF THE BRAKE DISCS RESULTING IN REDUCED BRAKING EFFECTIVENESS,HIGHER THAN NORMAL PEDAL EFFORTS, LOUD GRINDING NOISES, AND MODERATE PULLS WHENTHE BRAKES ARE APPLIED. REDUCED BRAKING EFFECTIVENESS MAY INCREASE MINIMUMSTOPPING DISTANCES, POSSIBLY RESULTING IN AN ACCIDENT.

Remedy: REPLACE FRONT BRAKE ROTORS WITH FULL CAST FRONT BRAKE ROTORS.

Reported: 1992-05-11 (May 11, 1992)

CHILDREN CAN ACCIDENTALLY LOCK THEMSELVES IN THE FOOTWELL AREA OF THE REAR-FACING THIRD SEAT, OR IN THE STORAGE COMPARTMENT IN STATION WAGONS NOT EQUIPPED WITH AN OPTIONAL THIRD SEAT. ONCE THE COMPARTMENT IS CLOSED IT CANNOT BE OPENED FROM THE INSIDE.

Consequence: THERE IS A DANGER OF AIR DEPRIVATION, HYPERTHERMIA,AND/OR PANIC RESPONSE TO A CHILD WHO HAS LOCKED HIMSELF OR HERSELF INTO THECOMPARTMENT, WITH THE POSSIBILITY OF ASPHYXIATION.

Remedy: REPLACE THE SELF-LATCHING ASSEMBLY CURRENTLY USED IN THE REAR STORAGE COMPARTMENT WITH A LATCH ASSEMBLY THAT CAN ONLY BE CLOSED WITH A KEY.

Reported: 1993-06-23 (June 23, 1993)

VEHICLE DESCRIPTION: TAURUS AND SABLES BUILT FROM 10-14-85 THROUGH 8-19-88, AND LINCOLN CONTINENTALS BUILT FROM 11-4-87 THROUGH 9-30-88 (EXCEPT 1989 - 1991 2.5L TAURUS AND 1989 - 1992 SHO). THE AFFECTED CARS WERE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, AND WISCONSIN. THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, MAY BECOME DETACHED DUE TO CORROSION OF THE SUBFRAME MOUNT RETAINING PLATE. THIS WOULD ALLOW THE REAR CORNERS OF THE SUBFRAME TO DROP.

Consequence: IF ONE OF THE REAR CORNERS DROPS, ONLY MINOR INDICATIONS OF A MALFUNCTION SUCH AS A CLUNKING NOISE OR SLIGHT CHANGE IN STEERING WHEEL ALIGNMENT ARE NOTICEABLE. HOWEVER, IF BOTH REAR CORNERS OF THE SUBFRAME DROP, STEERING BECOMES VERY DIFFICULT, WHICH COULD ADVERSELY AFFECT VEHICLE CONTROL AND POSSIBLY RESULT IN AN ACCIDENT.

Remedy: INSTALL A CORROSION-RESISTANT REINFORCING PLATE AND A NEW BOLT ON BOTH REAR SUBFRAME MOUNTS. THIS RECALL CAMPAIGN HAS BEEN SUPERSEDED BY RECALL 98V-323.

Reported: 1998-12-16 (December 16, 1998)

VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.

Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.