2003 Itasca SUNCRUISER: complaints, problems and recalls

2003 ITASCA SUNCRUISER MOTORHOME EXPERIENCES STALLING AND ENGINE SHUT DOWN.*MR THE VEHICLE CAN ONLY BE DRIVE 200 MILES BEFORE IT STALLS. THE VEHICLE HAS BEEN TAKEN TO SEVERAL DEALER. THE VEHICLE HAS HAD THREE CRANK SENSORS REPLACED. *NM

Owner-reported narrative. Look up ODI 10124726 at NHTSA ↗

TL*THE CONTACT OWNS A 2003 ITASCA SUNCRUISER RV. WHILE DRIVING 60 MPH, THE CONTACT NOTICED A VIBRATION IN THE STEERING WHEEL. HE TURNED OFF THE VEHICLE. WHEN HE RESTARTED IT, HE NOTICED THAT THE BRAKE PEDAL WAS HIGHER THAN USUAL AND HE HAD TO APPLY EXTREME PRESSURE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT ALL FOUR CALIBERS NEEDED TO BE REPLACED. THE CONTACT DID NOTICE ANY DIFFERENCES BEFOREHAND. THE CURRENT AND FAILURE MILEAGES WERE 15,944.

Owner-reported narrative. 15,944 miles reported. Look up ODI 10241029 at NHTSA ↗

BRAKE PROBLEM ON WORKHOUSE CHASSIS MOTORHOME. CALIPERS LOCKUP, APPARENTLY DO TO PINS. THIS IS A CONTINUOUS PROBLEM. REPLACED ALL 4 ROTOR. 4CALIPERS.2 SETS BRAKE PADS, 4 OIL SEALS, 4 BRAKE HOSE,2 AXLE GASKETS. ALL AT A COST OF $3502.97 I HAVE ROTORS, CALIPERS. *TR

Owner-reported narrative. 18,674 miles reported. Look up ODI 10252856 at NHTSA ↗

I HAVE A 2003 ITASCA SUNCRUISER WITH THE WORKHORSE CHASSIS THAT IS UNDER RECALL FOR THE BRAKE CALIPER PROBLEMS. I ENCOUNTERED THE PROBLEM LAST SUMMER AND TOOK IT TO PARKVIEW RV IN SMYRNA, DE. THEY REBUILT THE FRONT AND BACK BRAKES, SEALS, CALIPERS, PADS AND SENSORS WHICH HAD MELTED. AT THE TIME THEY TOLD ME WORKHORSE WOULD NOT PAY FOR ANY OF THE WORK. LAST WEEK I TOOK THE REPAIRED UNIT TO FLORIDA AND IN TAMPA HAD A PROBLEM WITH THE BRAKES SMOKING AND THE ABS LIGHT CAME ON. I AM TAKING IT BACK TO PARKVIEW SO THEY CAN DOCUMENT THE NEW PROBLE…

Owner-reported narrative. 27,000 miles reported. Look up ODI 10321911 at NHTSA ↗

Reported: 2003-02-21 (February 21, 2003)

CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105,"HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY THE STANDARD.

Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE SYSTEM WARNING INDICATOR.

Remedy: DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-3535.

Reported: 2004-12-22 (December 22, 2004)

ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.

Consequence: WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2005-09-14 (September 14, 2005)

ON CERTAIN MOTOR HOMES, THE ROOF VENT FOR THE OPTIONAL 4-DOOR REFRIGERATOR WAS INCORRECTLY LOCATED.

Consequence: THIS CAN ALLOW EXCESSIVE HEAT BUILDUP WHICH HAS THE POTENTIAL TO IGNITE SURROUNDING MATERIALS, RESULTING IN PERSONAL INJURY AND/OI VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL RELOCATE THE ROOF VENT. THE RECALL BEGAN ON SEPTEMBER 9, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-641-585-6939.

Reported: 2009-07-29 (July 29, 2009)

WINNEBAGO IS RECALLING 1,547 MODEL YEAR 2001-2003 RECREATIONAL VEHICLES EQUIPPED WITH NORCOLD MODEL 1200LRIM REFRIGERATORS, MANUFACTURED FROM MARCH 1, 2001 TO DECEMBER 31, 2002, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

Consequence: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.

Remedy: WINNEBAGO IS WORKING WITH NORCOLD AND NORCOLD WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE (PLEASE SEE 09E-027). OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.

Reported: 2010-10-26 (October 26, 2010)

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.