2014 Ford E-150: complaints, problems and recalls

ON JUNE 10, 2014 I LEFT MY OFFICE AND TRAVELED ACROSS THE PARKING DRIVEWAY AT ABOUT 7 MPH, A DISTANCE OF ABOUT 150 FEET WHERE I ATTEMPTED TO STOP(USING MY RIGHT FOOT ON THE BRAKE) BEFORE MAKING A RIGHT HAND TURN ONTO A BUSY FAST MOVING STREET. AT THIS POINT MY FOOT HIT THE BRAKE AND ACCELERATOR AT THE SAME TIME (THEY ARE EXTREMELY CLOSE) CAUSING ME TO SUDDENLY LURCH FORWARD TOWARD THE ONCOMING TRAFFIC COMING FROM MY LEFT. FORTUNATELY I WAS ABLE TO QUICKLY USE MY LEFT FOOT TO POWER BRAKE AND SAFELY STOP MY VEHICLE. THIS WAS THE THIRD TIME IN …

Owner-reported narrative. 250 miles reported. Look up ODI 10598091 at NHTSA ↗

TL* THE CONTACT OWNS A 2015 (NA) FORD E-150. WHILE THE VEHICLE WAS IN PARK, THE CONTACT HEARD A LOUD NOISE AND NOTICED THAT THE REAR DRIVER SIDE WINDOW FRACTURED. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT ALL THE REAR WINDOWS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 23,000. UPDATED 4/7/15*CN UPDATED 04/09/15*JB

Owner-reported narrative. 23,000 miles reported. Look up ODI 10680649 at NHTSA ↗

WHEN STARTED 3 SEPARATE TIMES 4X4 WAS ENGAGED BY ITSELF JUST BARELY TOUCHED 4WHEEL DRIVE SWITCH AND IT WENT OFF ALSO DID IT AGAIN WHEN I WAS DRIVING

Owner-reported narrative. 22,050 miles reported. Look up ODI 10722873 at NHTSA ↗

TL* THE CONTACT OWNS A 2014 FORD E-I50. THE CONTACT STATED THAT THE FRONT BRAKE PAD WAS GRINDING THE ROTOR AND CAUSED THE STEERING TO PULL TO THE LEFT AND RIGHT. THE DEALER SHAVED THE ROTOR AND REPLACED THE PADS, BUT THE FAILURE RECURRED A MONTH LATER. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY SHAVED THE ROTOR AND REPLACED THE PADS AGAIN, BUT THE FAILURE RECURRED. WHEN THE VEHICLE WAS TAKEN BACK TO THE DEALER, THE CONTACT WAS INFORMED THAT THE VEHICLE WAS OPERATING THE WAY IT SHOULD. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE.…

Owner-reported narrative. 11,426 miles reported. Look up ODI 10839717 at NHTSA ↗

I ONLY HAVE 8000 MILES ON IT, AND THE STEERING WHEEL IS SHAKING WHEN I TOUCH THE BRAKES. IT ALSO HAS SQUEAKED FROM THE DAY I BOUGHT IT. I TOOK IT BACK TO THE DEALER, THEY DIDN'T HEAR THE SQUEAK. IT IS ONLY WHEN I BACK UP.

Owner-reported narrative. 8,000 miles reported. Look up ODI 10839848 at NHTSA ↗

THE VAN WANDERS BACK AND FORTH AT HIGHWAY SPEEDS (> 60MPH). I HAD THE FRONT END ALIGNMENT AND SUSPENSION CHECKED OUT - ALL OK. PROBLEM GETS WORSE WHEN PULLING A 5000 LB CAMPER - ALMOST A SAFETY ISSUE.

Owner-reported narrative. 34,000 miles reported. Look up ODI 11002038 at NHTSA ↗

Reported: 2014-03-04 (March 4, 2014)

Landi Renzo USA is recalling certain model year 2011-2014 Ford E-150, E-250, and E-350 vehicles modified January 2, 2011, through February 24, 2014 to operate on compressed natural gas (CNG). In the affected vehicles, the left and right rear brackets that support the rear CNG cylinder may fail, allowing the cylinder to dislodge from the vehicle.

Consequence: If the cylinder dislodges, a CNG leak may result, increasing the risk of a fire.

Remedy: Landi Renzo USA will notify owners, and dealers will inspect and replace the side arm brackets, as necessary, free of charge. The recall began on March 27, 2014. Owners may contact Landi Renzo USA at 1-855-526-3400.

Reported: 2014-05-02 (May 2, 2014)

WMK Inc., doing business as Mobility Works, Inc. (Mobility), is recalling certain model year 2013-2014 Mobility-modified Ford E-150, and E-250 transit buses manufactured December 1, 2013, through January 4, 2014, and equipped with certain Ricon S series and K series wheelchair lifts, with an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.

Consequence: If the cable does not clear the wheel chair lift it may contact the power lug and if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, then a short circuit may occur that could result in a fire.

Remedy: Mobility will notify owners, and Ricon will send the owner a supplemental cover kit and instructions free of charge. The recall began on June 4, 2014. Owners may contact Mobility customer service at 1-800-769-8267, or Ricon Customer Service at 1-800-322-2884 or by e-mail at recall.admin@wabtec.com.

Reported: 2014-09-23 (September 23, 2014)

National Van Builders, Inc. (National Van) is recalling certain 2007-2014 Ford E-150 and E-250 vehicles manufactured February 26, 2007, to August 19, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: National Van will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 3, 2014. Owners may contact National Van customer service at 1-800-527-7477. National Van's number for this recall is Ricon2014.

Reported: 2014-11-05 (November 5, 2014)

Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.

Remedy: Cummings will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began January 13, 2015. Owners may contact Cumming's customer service at 1-800-639-5438 or Ricon customer service at 1-800-322-2884. Cumming's number for this recall is 14E-041.

Reported: 2015-11-04 (November 4, 2015)

MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.

Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.

Remedy: MobilityWorks will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 15, 2015. Owners may contact MobilityWorks customer service at 1-800-769-8267, or Ricon Customer Service at 1-800-322-2884. Note: These vehicles and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.

Reported: 2019-04-03 (April 3, 2019)

Mobility Specialists, Inc. (Mobility Specialists) is recalling certain 2014-2017 Ford E-150 and Transit vans modified to be equipped with Ricon S-Series and K-Series wheel chair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height.

Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.

Remedy: Mobility Specialists, working with Ricon, has notified the owners. Ricon will provide instructions and materials for replacing defective parts. Owners may contact Ricon customer service at 1-800-322-2884.