2005 Chevrolet MALIBU MAXX: complaints, problems and recalls

WHILE DRIVING 68 MPH AND HAD APPLIED THE BRAKES, THE STEERING WHEEL WAS HARD TO CONTROL; VEERED TO THE RIGHT AND VEHICLE ROLLED OVER INTO A DITCH. *AK RENTAL VEHICLE FROM ENTERPRISE CONTRACT #113732

Owner-reported narrative. 8,000 miles reported. Look up ODI 10101113 at NHTSA ↗

CAR IS LESS THAN TWO WEEKS OLD AND UNDER 400 MILES ON THE ODOMETER. CONSTANT STALLING AND EVENTUALLY DIFFICULT TO START. CAR HAD TO BE TOWED TO THE DEALERSHIP. DEALER SERVICE DEPT HAS DETERMINED THAT THE MASS AIRFLOW SENSOR IS DEFECTIVE AND NEEDS TO BE REPLACED. AWAITING DELIVERY OF REPLACEMENT PART. *NM

Owner-reported narrative. 350 miles reported. Look up ODI 10106259 at NHTSA ↗

THERE WERE NO EVENTS THAT LEAD UP TO THE FAILIURES. I HAVE THE PAPER WORK OF THE TWO TIMES I 'VE TAKEN MY CARE TO BE REPAIRED. THE DATE I INIDATE BELOW IS NOT ACCURATE HOWEVER, JUST AN ESTIMATED DATE.*AK THE FAILURE WAS THE ELECTRIC POWER STEARING HAS GONE OUT NUMEROUS TIMES. I'VE HAD IT IN TEH SHOP TWICE. THE FIRST TIME, THEY REPLACED THE STEERING COLUMN, THE SECOND TIME, THEY CLAIMED ITS NOT THE STEERING COLUMN, BUT THAT IT IS SOMETHING THEY CAN'T FIX BUT CAN CLEAR OUT THE "CODES" AND IT WILL BE "TEMPORARLY" FIXED. ACCORDING TO GM " THEY K…

Owner-reported narrative. 1,000 miles reported. Look up ODI 10116323 at NHTSA ↗

OUR 2005 CHEVY MALIBU HAS HAD STEERING ISSUES SINCE IT WAS NEW. THE DEALER AND GM HAVE NOT BEEN ABLE TO FIX IT AS OF YET. THE CAR HAS A CONSTANT PULL TO THE LEFT AND ON OCCASION (4 TIMES) THE CAR WILL VEER TO THE LEFT CROSSING LANES BEFORE YOU CAN GET CONTROL AND BRING IT BACK IT TO THE CORRECT DRIVING LANE. THE REPAIR SO FAR HAS BEEN TO REPROGRAM THE STEERING MODULE OR REPLACE IT. THIS HAS NOT WORKED AND IS WHAT THEY ARE ATTEMPTING TO DO AGAIN. *JB

Owner-reported narrative. 13,480 miles reported. Look up ODI 10135370 at NHTSA ↗

POWER STEERING FAILED 2 TIMES IN LAST 3 DAYS AND BOTH TIMES IT HAS HAPPENED I WAS STOPPED. I HAD NO POWER ASSIST AND IT TAKES A LOT OF EFFORT TO MOVE THE WHEEL IN ANY DIRECTION. AFTER I DID MOVE THE WHEEL SEVERAL TIMES I REGAINED POWER STEERING AND WAS ABLE TO PROCEED ON MY WAY. I THINK THIS PROBLEM SHOULD BE UPGRADED TO A RECALL ASAP! *JB

Owner-reported narrative. 15,721 miles reported. Look up ODI 10143255 at NHTSA ↗

IGNITION TENDS TO STICK AND CAUSES THE SOLENOID TO GRIND W/FLYWHEEL. I JUST RECEIVED A COPY OF A SERVICE BULLETIN FROM G.M. STATING THEY ARE AWARE OF A PROBLEM. HOWEVER, AT THIS TIME THE ENGINEERS WILL CONTINUE TO WOK ON A SOLUTION. *JB

Owner-reported narrative. Look up ODI 10145983 at NHTSA ↗

UPON STARTING THE CAR, THE INSTRUMENT PANEL WAS COMPLETELY DOWN EXCEPT FOR THE LOW FUEL WARNING LIGHT HOWEVER THE CAR HAD A FULL TANK. POWER WOULD RETURN TO THE INSTRUMENT PANEL INTERMITTENTLY WHEN THE TURN SIGNAL WAS ENGAGED. THE FAULT CLEARED AFTER SHUTTING THE VEHICLE OFF FOR A FEW MINUTES. *NM

Owner-reported narrative. 6,700 miles reported. Look up ODI 10149263 at NHTSA ↗

MY CHEVROLET MALIBU MAXX (2005, 17K MILES) FREQUENTLY HAS A CLUNKING NOISE THAT APPEARS TO BE COMING FROM THE LEFT FRONT SUSPENSION. THE NOISE IS OFTEN ACCOMPANIED BY THE FEELING OF A "HIT" UNDERNEATH THE DRIVER'S FEET AND ON OCCASION SEEMS TO BE CONNECTED TO A STEERING INPUT (STEERING WHEEL MOVES NOTABLY). THIS HAPPENS ONLY AT LOWER SPEEDS (BELOW APPROX. 35 MILES/HOUR) AND DURING OR AFTER LEFT TURNS AND IS ESPECIALLY STRONG ON UNEVEN ROADS. I TOOK THE CAR TO A CERTIFIED CHEVROLET DEALER FOR REPAIR AND HAVE BEEN INFORMED THAT THIS CLUNKING IS R…

Owner-reported narrative. 16,500 miles reported. Look up ODI 10150971 at NHTSA ↗

Reported: 2014-03-31 (March 31, 2014)

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

Reported: 2014-04-30 (April 30, 2014)

General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.

Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the ‘PARK’ position, the transmission may not be in ‘PARK.’ If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.

Reported: 2014-05-14 (May 14, 2014)

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.