1996 Chevrolet C10: complaints, problems and recalls

WE WERE DRIVING ON THE HIGHWAY ABOUT 65MPH WHEN IT BEGAN TO RAIN. I TURNED THE WIPERS ON AND OFF SEVERAL TIMES BUT THEY WOULD NOT RESPOND. AFTER A FEW MINUTES THE RAIN INTENSIFIED I TRIED THE WIPERS AGAIN AND THEY WORKED. I RECENTLY NEEDED THE WIPERS AGAIN AND THEY FAILED. *TR

Owner-reported narrative. 134,650 miles reported. Look up ODI 10273479 at NHTSA ↗

WINDSHIELD WIPER PULSE MODULE FAILED - SAME COMPONENT AS FAILURE ON S-10 PURCHASED SAME DATE (NHTSA RECALL 98V150001). *AK

Owner-reported narrative. Look up ODI 720040 at NHTSA ↗

WINDSHIELD WIPERS FAILED WHILE DRIVING IN RAIN, WITHOUT A SERIOUS PROBLEM. I HAD BROSZ REPAIR LOOK AT THEM AND THE PRINTED CIRCUIT MODULE WAS BAD, SO A NEW REPLACEMENT WAS BOUGHT AND INSTALLED. WHILE VISITING YOUR WEBSITE, I SEE THERE WAS A RECALL ON THIS YEAR AND MODEL PICKUPS. I CONTACTED MY DEALER WHO SAYS MY PICKUP WAS NOT RECALLED. I THINK THAT, AS THE FAULTY PART S NOW KNOWN TO BE FAULTY, CHEVROLET SHOULD RE-IMBURSE ME FOR THE PART($53.43), AND THE SMALL LABOR BILL($10).*AK

Owner-reported narrative. Look up ODI 723981 at NHTSA ↗

ENGINE REVS UP WHEN ENGINE IS COLD AND IDLES DOWN THE ROAD AT 35 MPH I FIRST REPORTED THIS TO THE DEALER SOON AFTER I BOUGHT THIS TRUCK AND WAS TOLD THAT IT WAS THE WAY A 5.0 L. ENGINE OPERATED AND NOTHING COULD BE DONE ABOUT IT AFTER SEVERAL NEAR CRASHES BECAUSE OF THE RPMS OF THE ENGINE AS I HAVE APPROACHED ICY INTERSECTIONS BECAUSE THE WHEELS WOULD BE PUSHING ME AND THE BRAKES WOULD LOCK UP I WOULD HAVE TO SHIFT INTO NETURAL TO KEEP FROM RUNNNG INTO THE INTERSECTION, AFTER 5 YEARS I HAVE THIS IS A SAFETY HAZARD AND THE DEALER MAY HAVE BEEN I…

Owner-reported narrative. Look up ODI 743036 at NHTSA ↗

WHILE DRIVING AND WITHOUT WARNING WINDSHIELD WIPERS WILL WORK INTERMITTENTLY, CAUSING DRIVER NOT TO HAVE A CLEAR VIEW. DEALER HAS BEEN NOTIFIED, AND STATED THAT DESPITE A RECALL ISSUED FOR WIPER MOTOR FAILURE IT DID NOT APPLY TO THE CONSUMERS VEHICLE. *AK *YH

Owner-reported narrative. Look up ODI 8005772 at NHTSA ↗

CONSUMER CONTACTED MANUFACTURER REGARDING RECALL 98V 150 001/98 V 150 000 CONCERNING WINDSHIELD WIPER WIRING. MANUFACTURER STATED THAT VEHICLE WAS INCLUDED IN RECALL. HOWEVER, DEALERSHIP INSISTED THAT VEHICLE WAS NOT INCLUDED IN RECALL. *AK *YH

Owner-reported narrative. Look up ODI 8009844 at NHTSA ↗

WINDSHIELD WIPERS STOP WORKING INTERMITTENTLY. VEHICLE HAS NOT BEEN EXAMINED BY A DEALER. THERE IS A RECALL, 98V150001, BUT THIS VEHICLE IS NOT AFFECTED DUE TO VIN. *AK *TT

Owner-reported narrative. Look up ODI 8013153 at NHTSA ↗

WHILE USING WINDSHIELD WIPERS THEY WOULD WORK ON AND OFF. CONSUMER HAD TO HIT THE BOX FOR WINDSHIELD WIPERS TO START THEY WERE WORKING AGAIN. BUT, THEN THEY STOPPED WORKING. THERE WAS A RECALL FOR THIS PROBLEM. BUT, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN. *AK

Owner-reported narrative. Look up ODI 862460 at NHTSA ↗

Reported: 1995-12-28 (December 28, 1995)

CERTAIN TRUCKS HAVE FUEL RAIL ASSEMBLIES WITH AN IMPROPERLY CRIMPED END RETAINER CLIP THAT RESULTS IN A FUEL LEAK.

Consequence: IF FUEL LEAKAGE OCCURS AND AN IGNITION SOURCE IS PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.

Remedy: DEALERS WILL INSPECT THE FUEL RAIL ASSEMBLY AND REPLACE ANY FUEL RAIL ASSEMBLY WITH A JULIAN DATE CODE OF 95318 THROUGH 95338.

Reported: 1996-04-04 (April 4, 1996)

THESE VEHICLES WERE ASSEMBLED WITH THE THROTTLE CABLE CONTACTING THE DASH MAT WHICH COULD BIND THE THROTTLE. THIS DOES NOT MEET WITH THE MAXIMUM RETURN TIMES REQUIRED BY FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, "ACCELERATOR CONTROL SYSTEMS."

Consequence: CONSEQUENCE OF NON-COMPLIANCE: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL INSPECT FOR ADEQUATE THROTTLE CABLE TO DASH MAT CLEARANCE, AND IF THERE IS INSUFFICIENT CLEARANCE, CUT OUT A PORTION OF THE DASH MAT TO PROVIDE PROPER CLEARANCE.

Reported: 1996-05-07 (May 7, 1996)

THE FOUR U-BOLTS NUTS ON EITHER SIDE OF THE REAR AXLE WERE UNDER-TORQUED.

Consequence: VEHICLE USAGE COULD CAUSE THE NUTS TO LOOSEN AND EVENTUALLY FALL OFF THE U-BOLT. THIS COULD RESULT IN SUDDEN LOSS OF VEHICLE CONTROL INCREASING THE POTENTIAL FOR A VEHICLE CRASH.

Remedy: DEALERS WILL CHECK THE U-BOLT NUT TORQUE AND RE-TORQUE ANY LOOSE U-BOLTS TO SPECIFICATION.

Reported: 1997-03-07 (March 7, 1997)

VEHICLE DESCRIPTION: EXTENDED CAB AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH RECLINING SEATS AND THE EASY-ENTRY FEATURE. THESE VEHICLES EXHIBIT A CONDITION IN WHICH A PINCH POINT EXISTS IN THE RECLINER MECHANISM THAT CAN TRAP AND PINCH A PERSON'S HAND OR FINGER(S) WHEN THE EASY-ENTRY FEATURE IS ACTIVATED.

Consequence: THIS PINCHING CAN CUT THE HAND OR POSSIBLY SEVER THE FINGER(S) WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL INSTALL A PROTECTOR COVER OVER THE RECLINER MECHANISM.

Reported: 1998-07-01 (July 1, 1998)

VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.

Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.

Reported: 1998-08-10 (August 10, 1998)

VEHICLE DESCRIPTION: CREW CAB PICKUP TRUCKS. THE FRONT, INNER CORNER OF THE FUEL TANK CAN CONTACT THE BODY SILL EITHER INTERMITTENTLY OR CONSTANTLY. THIS MOVEMENT CAN CAUSE A DISCERNIBLE NOISE AND, OVER TIME, CAN WEAR A HOLE IN OR CRACK THE FUEL TANK AT POINT OF CONTACT.

Consequence: THIS CONDITION CAN RESULT IN FUEL LEAKAGE AND A DISTINCT FUEL ODOR IF THE TANK WERE FILLED ABOVE THE LEVEL OF THE HOLE OR CRACK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.

Remedy: DEALERS WILL INSPECT THE FUEL TANK FOR WEAR AND, EITHER INSTALL A SPACER BETWEEN THE FUEL TANK AND THE FRONT CROSSMEMBER, OR IF NECESSARY, REPLACE THE FUEL TANK.