2006 Bmw K1200 GT: complaints, problems and recalls

(1) EVENTS LEADING UP TO THE FAILURE: BMW MOTORCYCLE 06 K1200GT. DRIVING MOTORCYCLE AT HIGHWAY SPEEDS. ENGINE FULLY WARMED UP. (2) FAILURE AND ITS CONSEQUENCES: SHUTTING OFF THROTTLE TO DOWN SHIFT ENGINE WOULD NOT IDLE DOWN, ENGINE IDLE STUCK AT 3000 RPM FOR FIVE TO TEN SECONDS. WHEN IDLE DID SLOW DOWN IT WOULD IDLE ERRATIC AND NOT SMOOTH JUST TOUCHING THE THROTTLE WOULD CAUSE THE ENGINE TO REV TO 3000 RPM'S. VERY DIFFICULT TO DRIVE AT SURFACE STREET SPEEDS, 40 MPH OR SLOWER. PROBLEM WOULD GO AWAY IF ENGINE IS TURNED OFF FOR A MINUTE …

Owner-reported narrative. 10,000 miles reported. Look up ODI 10191686 at NHTSA ↗

ENGINE WILL NOT IDLE PROPERLY, IT SHOULD IDLE AT 1,000 RPM. AT LEAST PART OF EVERY RIDE IT WILL GO UP TO 1,500 TO 2,000 RPM.

Owner-reported narrative. 8,000 miles reported. Look up ODI 10191705 at NHTSA ↗

MY VENICLE SPORADICALLY EXIBITS AN IDLE SPEED WHICH IS ABNORMALLY HIGH, AND MAKES LOW SPEED, TRAFFIC DIRIVING DANGEROUS. THE MANUFACTURER HAS CHANGED COMPONENTS AND COMPUTER SOFTWARE TO FIX THE PROBLEM TO NO AVAIL. MY MOTORCYCLE REMAINS UNSAFE AND NOT RUNNING PROPERLY

Owner-reported narrative. 3,000 miles reported. Look up ODI 10191712 at NHTSA ↗

BRAKE WARNING LIGHT CONSTANTLY ILLUMINATED. BMW DEALER CANNOT TURN IT OFF OR RESET IT. INTERNET CHAT ROOMS REVEAL THIS IS A VERY COMMON PROBLEM WITH THE LATE MODEL BMW MOTORCYCLE LINE. *TR

Owner-reported narrative. 7,500 miles reported. Look up ODI 10193349 at NHTSA ↗

RANDOM HIGH IDLE CONDITION. ENGINE RPMS RANDOMLY INCREASE FOR NO REASON TO AS HIGH AS 2500 AT A STOP AND DURING DECEL CONDITIONS. MUST PULL IN CLUTCH TO KEEP FROM ACCELERATING DURING DECEL. UNSAFE CONDITION. INTERNET FORUMS REVEAL THIS IS A COMMON CONDITION TO LATE MODEL BMW MOTORCYCLES. DEALERS HAVE NOT BEEN ABLE TO REMEDY THE CONDITION. SOFTWARE UPDATES UNSUCCESSFUL. THIS SAFETY PROBLEM NEEDS RESOLUTION. *TR

Owner-reported narrative. 3,000 miles reported. Look up ODI 10193351 at NHTSA ↗

IDLE IS ERRATIC. BIKES IDLE JUMPS RANDOMLY AND HANGS UP AT A HIGH RPM AT IDLE OR WHEN SHIFTING BETWEEN GEARS. BIKE HAS BEEN IN FOR REPAIR FIVE TIMES NOW. DEALER HAS REPLACED THE AIRBOX AND UPDATED SOFTWARE TO NO AVAIL. BIKE IS UNSAFE TO RIDE IN THIS CONDITION. PROBLEM IS MORE PRONOUNCED AT HIGHER AMBIENT TEMPS. *JB

Owner-reported narrative. 5,000 miles reported. Look up ODI 10201186 at NHTSA ↗

TL*THE CONTACT OWNS A 2006 BMW K1200 GT. WHILE RIDING APPROXIMATELY 20 MPH, THE VEHICLE REMAINED AT A CONSTANT SPEED INSTEAD OF DECELERATING WHEN THE THROTTLE WAS RELEASED. THE CONTACT STATED THAT WHEN THE THROTTLE WAS HELD AT A CONSTANT SPEED, THE ENGINE OFTEN SURGED. THE DEALER WAS AWARE OF THE FAILURE, BUT HAD NOT INSPECTED THE VEHICLE. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 7,400 AND FAILURE MILEAGE WAS 5,600. UPDATED 09/26/07 *TR

Owner-reported narrative. 5,600 miles reported. Look up ODI 10201913 at NHTSA ↗

THIS K1200GT, 2006 MODEL YEAR, HAS BEEN STALLING AT SPEEDS >50MPH. MANY TIMES, THE STALLS OCCUR AT HIGHWAY SPEEDS 70-80MPH WITH SUDDEN, UNEXPECTED DECELERATION, AND LOSS OF BRAKES (THEY ARE POWER ASSISTED BY THE MOTOR). MANY OCCURRENCES HAVE RESULTED IN NEAR MISSES IN REGARDS TO ACCIDENTS. INITIAL FINDINGS BE A REPAIRING DEALER INDICATED THAT IT WAS INCOMPATIBLE FUEL TYPE (IE FUELS CONTAINING ETHANOL, WATER IN FUEL, ETC) BUT THE PROBLEM CONTINUES AFTER SWITCHING FUEL GRADES AND STATIONS. PROBLEM SEEMS TO EXIST OR APPEARS MORE RAMPANTLY WHEN AMB…

Owner-reported narrative. 26,000 miles reported. Look up ODI 10482543 at NHTSA ↗

Reported: 2007-02-23 (February 23, 2007)

ON CERTAIN MOTORCYCLES, FREQUENT SHORT TRIPS PARTICULARLY DURING COLD TEMPERATURES, CAN CAUSE WATER TO ACCUMULATE IN THE OIL TANK, AND WHEN THE ENGINE IS RUNNING, ESCAPING WATER VAPOR CAN CONDENSE ON THE OIL TANK AIR BLEED VALVE. IN FREEZING TEMPERATURES, THIS WATER COULD FREEZE AND BLOCK THE AIR BLEED VALVE.

Consequence: IT IS POSSIBLE THAT A PRESSURE BUILD UP IN THE OIL TANK COULD CAUSE IT TO RUPTURE, ALLOWING OIL TO LEAK ONTO THE REAR TIRE. AN OIL LEAK COULD CAUSE A FIRE. OIL ON THE REAR TIRE COULD CAUSE LOSS OF CONTROL.

Remedy: DEALERS WILL INSTALL A NEW OIL TANK CAP CONTAINING A VALVE TO PREVENT OVERPRESSURE IN THE TANK FREE OF CHARGE. THE RECALL BEGAN ON APRIL 10, 2007. OWNERS MAY CONTACT BMW AT 1-800-831-1117.

Reported: 2010-10-08 (October 8, 2010)

BMW IS RECALLING CERTAIN MODEL YEAR 2005-2011 MOTORCYCLES. THE BEARINGS COULD BE SUBJECT TO CORROSION. THIS COULD LEAD TO REDUCED MOVEMENT OF THE LINK LEVER.

Consequence: THIS COULD AFFECT THE HANDLING OF THE MOTORCYCLE INCREASING THE RISK A DRIVER MAY LOSE CONTROL OF THE VEHICLE RESULTING IN A CRASH.

Remedy: BMW WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT BMW AT 1-800-525-7417.

Reported: 2020-08-10 (August 10, 2020)

BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V-617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1-800-525-7417.