Spartan MM recalls by model year

Reported: 2015-10-08 (October 8, 2015) · Model years: 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005

Spartan Motors USA (Spartan) is recalling certain model year 1997-2005 MM and K2 motorhome chassis manufactured January 20, 2003, to May 16, 2005. The affected vehicles have a steering gear mounting bracket that may crack, causing a loss of steering ability.

Consequence: A loss of steering increases the risk of a crash.

Remedy: Spartan will notify owners, and dealers will replace the steering gear mounting brackets, free of charge. An interim notice was mailed to owners on December 4, 2015. Owners may contact Spartan customer service at 1-800-543-4277. Spartan's number for this recall is 15022.

Reported: 2006-05-09 (May 9, 2006) · Model years: 1998

ON CERTAIN MOTOR HOMES, THE STEERING GEAR SUPPORT BRACKET HAS THE POTENTIAL TO FAIL WHEN SUBJECT TO THE REPETITIVE FORCES OF STATIC STEERING CONDITIONS.

Consequence: LOSS OF STEERING CONTROL COULD OCCUR INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE STEERING SUPPORT BRACKET FREE OF CHARGE. THE RECALL BEGAN ON MAY 30, 2006. OWNERS MAY CONTACT SPARTAN AT 517-543-6400.

Reported: 2005-04-12 (April 12, 2005) · Model years: 2003, 2004, 2005

ON CERTAIN MOTOR HOMES EQUIPPED WITH NGI AIR PRESSURE GAUGES LOCATED ON THE DASH PANEL IS GIVING A FALSE READING.

Consequence: THIS MAY CAUSE THE PARK BRAKE TO ENGAGE WITHOUT WARNING, THUS THROWING THE PASSENGER FORWARD, CREATING THE POTENTIAL FOR INJURY TO OCCUPANTS.

Remedy: DEALERS WILL USE A JUMPER HARNESS CONTAINING A 33 OHM RESISTOR WHICH WILL SHIFT THE RESISTANCE CURVE OF THE AIR PRESSURE SENDER TO MATCH THE ALARM POINT OF THE CURRENT GAUGE. THE RECALL BEGAN ON JUNE 3, 2005. OWNERS MAY CONTACT SPARTAN AT 517-543-6400.

Reported: 2015-09-01 (September 1, 2015) · Model years: 2004, 2005, 2006, 2007, 2008

Spartan Motors USA (Spartan) is recalling certain model year 2004-2008 K2, K3 and MM motorhomes manufactured March 17, 2003, to March 15, 2007. In the affected vehicles, the engine cooling fan may separate from the fan drive while the fan is spinning.

Consequence: If the engine area is open and the cooling fan is operating and detaches, someone nearby may be injured.

Remedy: Spartan will notify owners, and dealers will replace the fan and fan drive system, free of charge. Interim notices were mailed to owners on October 29, 2015. The recall began on October 29, 2015. Owners may contact Spartan customer service at 1-800-582-3454. Spartan's number for this recall is 15014.

Reported: 2004-09-09 (September 9, 2004) · Model years: 2005

ON CERTAIN MOTORHOMES EQUIPPED WITH CATERPILLAR ENGINES, THE ADJUSTABLE PEDAL RETURN SPRINGS MAY RETURN THE PEDAL SHAFT TO THE HOME POSITION WHILE NOT FULLY RETURNING THE POTENTIOMETER KEY TO ITS HOME POSITION.

Consequence: IN A NEUTRAL OR NO LOAD SITUATION: THE ENGINE WILL CONTINUE TO INCREASE IDLE SPEED UNTIL IT REACES FULL GOVERNED RPM. THE TRANSMISSION WILL NOT ALLOW SHIFT FROM NEUTRAL TO ANY GEAR OVER 900 ENGINE RPM. IN GEAR OR UNDER LOAD: THE ENGINE MAY NOT RETURN TO 725 RPM (NORMAL IDLE) WHICH WILL REQUIRE ADDITIONAL EFFORT BY THE SERVICE BRAKES TO OVERCOME THE ADDITIONAL ENGINE RPM DURING BRAKING, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE THROTTLE PEDAL. THE RECALL BEGAN ON AUGUST 17, 2004, BY PHONE CALLS. OWNERS SHOULD CONTACT SPARTAN AT 517-543-6400.

Reported: 2005-01-12 (January 12, 2005) · Model years: 2005

ON CERTAIN MOTOR HOMES, THE SLACK ADJUSTERS IN THE FRONT AXLES WERE NOT ADJUSTED PROPERLY.

Consequence: THE DRIVER MAY EXPERIENCE A FEELING OF SOFTENING IN THE BRAKING FUNCTION. REDUCTION IN BRAKE FORCE WHICH COULD CAUSE A CRASH.

Remedy: DEALERS WILL ADJUST THE FRONT AXLE BRAKE FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 2, 2005. OWNERS MAY CONTACT SPARTAN AT 1-800-543-4277, OPTION 1.

Reported: 2006-03-31 (March 31, 2006) · Model years: 2006, 2007

ON CERTAIN MOTOR HOMES, THE BUSSMAN BOX WAS INCORRECTLY SOLDERED AND COULD FAIL.

Consequence: ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUTDOWN AND/OR NOT BE CAPABLE OF POWERING UP. ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS MAY OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION STARTING AND ENGINE COOLING SYSTEMS, IN THE OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, ANTILOCK BRAKE SYSTEM (ABS), AUXILIARY BRAKE SYSTEM, HEATER ELEMENTS IN THE AIR DRYER, AND/OR THE HEATER ELEMENT IN THE WATER IN-FUEL SEPARATOR, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE DEFECTIVE COMPONENTS. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Reported: 2007-06-29 (June 29, 2007) · Model years: 2006, 2007

ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

Consequence: IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, RESULTING IN OIL AND DEBRIS ON THE ROADWAY INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: SPARTAN IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 800-343-7357 OR SPARTAN AT 517-543-6400.

Reported: 2013-05-08 (May 8, 2013) · Model years: 2006, 2007, 2008, 2009, 2010

Spartan Motors Chassis (Spartan) is recalling certain model year 2006-2011 K2, and K3 and 2006-2010 MM motorhome chassis manufactured July 20, 2005, through December 17, 2010. The steering gear mounting brackets may crack and detach resulting in a loss of steering.

Consequence: A loss of steering control may increase the risk of a crash.

Remedy: Spartan will notify owners. Starting in mid-June 2013, dealers will install a replacement bracket or a reinforcement to the existing bracket. Until the remedy is available, owners may have their vehicle inspected at any Spartan service center. All repairs will be performed free of charge. Notices were mailed to owners on June 24, 2013. Owners can contact Spartan at 1-855-589-9836.

Reported: 2007-08-15 (August 15, 2007) · Model years: 2007, 2008

ON CERTAIN MOTOR HOME CHASSIS, THERE MAY BE A LOOSE CONNECTION BETWEEN THE BUS BAR AND A GRID PAD DUE TO THE PINS BEING SLIGHTLY SMALLER DIAMETERS AFTER ASSEMBLY. ELECTRICAL POWER MAY BE LOST TO COMPONENTS OF THE MAJOR CHASSIS OPERATING SYSTEMS (ENGINE, TRANSMISSION, STARTING, COOLING) CAUSING THE VEHICLE TO SHUT DOWN AND/OR NOT BE CAPABLE OF POWERING UP.

Consequence: EACH VEHICLE COULD POTENTIALLY EXPERIENCE A UNIQUE CIRCUMSTANCE WHERE ONE OR A COMBINATION OF THE FOLLOWING CONDITIONS COULD OCCUR: LOSS OF ELECTRICAL POWER TO THE ENGINE, TRANSMISSION, STARTING AND ENGINE COOLING SYSTEMS, OPERATION OF THE RIGHT CHASSIS STOP/TURN SIGNAL AND RIGHT TRAILER STOP/TURN SIGNAL, THE ANTI-LOCK BRAKE SYSTEM, AUXILIARY BRAKE SYSTEM, THE HEATER ELEMENTS IN THE AIR DRYER, AND THE HEATER ELEMENT IN THE WATER-IN-FUEL SEPARATOR.

Remedy: THE DVEC BUSSMANN BOX WILL BE REPLACED. THE RECALL BEGAN ON JANUARY 16, 2008. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Reported: 2008-06-20 (June 20, 2008) · Model years: 2007, 2008

SPARTAN CHASSIS IS RECALLING 213 MY 2007-2008 MM, AND MY 2008 K2, K3, AND SU MOTOR HOME CHASSIS. CERTAIN CHASSIS FASTENERS MAY FRACTURE RESULTING IN POOR HANDLING OF THE VEHICLE, LOSS OF STEERING, AND/OR REDUCED LEVEL OF SUSPENSION PERFORMANCE.

Consequence: LOSS OF STEERING WILL INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT AND REPLACE THE FASTENERS AS NEEDED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 30, 2008. OWNERS MAY CONTACT SPARTAN CHASSIS AT 1-800-543-4277.

Reported: 2008-10-28 (October 28, 2008) · Model years: 2007, 2008, 2009

SPARTAN IS RECALLING 2,621 MY 2005-2009 K2, MY 2006-2009 MG, AND MY 2007-2009 MM MOTOR HOME CHASSIS EQUIPPED WITH PUTNAM HITCHES. CERTAIN TRAILER HITCHES MAY FRACTURE WHICH COULD RESULT IN THE LOSS OF THE TRAILER.

Consequence: SUSPECT HITCHES MAY DEVELOP FRACTURES AND SUBSEQUENT SEPARATION MAY OCCUR, RESULTING IN A VEHICLE CRASH, PROPERTY DAMAGE OR PEDESTRIAN HARM.

Remedy: DEALERS WILL REPLACE THE TRAILER HITCH FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 21, 2009. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Reported: 2015-09-01 (September 1, 2015) · Model years: 2007, 2008

Spartan Motors USA (Spartan) is recalling certain 2007-2008 MM and K2 motorhome chassis manufactured March 07, 2006, to June 22, 2006. The affected vehicles have tag axles with wheel bearings that may be adjusted too tight, resulting in their overheating during use.

Consequence: If the wheel bearings overheat, there is an increased risk of a wheel end fire.

Remedy: Spartan will notify owners, and dealers will adjust the wheel bearing load, replacing the bearings as necessary, free of charge. The recall began on October 7, 2015. Owners may contact Spartan at 1-800-582-3454. Spartan's number for this recall is 14015.

Reported: 2016-05-17 (May 17, 2016) · Model years: 2007, 2008, 2009, 2010, 2011, 2012, 2013, 2014, 2015

Spartan Motors (Spartan) is recalling certain model year 2007-2015 Spartan K3 and MM motorhome chassis manufactured September 21, 2006, to March 23, 2015. In the affected vehicles, the flexible exhaust tube may tear allowing hot exhaust to blow against other components or materials.

Consequence: If hot exhaust gas contacts other components or materials, it can increase the risk of a fire.

Remedy: Spartan will notify the motorhome manufacturers that purchased the affected chassis, and Spartan dealers will inspect the alignment of the tubes, correcting them and replacing any that are torn. These repairs will be performed free of charge. The recall began on June 23, 2016. Owners may contact Spartan customer service at 1-517-543-6400. Spartan's number for this recall is 16014. Note: This recall supersedes 15V-554.

Reported: 2008-09-25 (September 25, 2008) · Model years: 2008

SPARTAN IS RECALLING 9 MY 2007-2008 FUR FIRE TRUCK CAB/CHASSIS AND MY 2008 MM MOTOR HOME CHASSIS AND GLD FIRE TRUCK CAB/CHASSIS EQUIPPED WITH C7 OR C9 CATERPILLAR DIESEL ENGINES. THE FUEL PUMP OUTLET CHECK PLUG MAY BE CRACKED WHICH COULD CAUSE FUEL TO SPRAY AND LEAK.

Consequence: THE FUEL PUMP PLUG MAY CRACK CAUSING FUEL TO LEAK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: SPARTAN IS WORKING WITH CATERPILLAR (PLEASE SEE 08E042). CATERPILLAR WILL REPLACE THE FUEL PUMP PLUG FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR AT-1-800-447-4986 OR SPARTAN AT 1-800-543-4277.

Reported: 2009-05-28 (May 28, 2009) · Model years: 2008, 2009, 2010

SPARTAN IS RECALLING 484 MODEL YEARS 2008-2010 ADV, BEY, FUR, GLC, GLD, K2, K3, MG, MM, MTR, AND NVS FIRE TRUCK, AMBULANCE, AND MOTOR HOME CHASSIS MANUFACTURED BETWEEN JULY 1 AND DECEMBER 16, 2008 EQUIPPED WITH CERTAIN HALDEX QUICK RELEASE VALVES (QRV). THE RUBBER DIAPHRAGM INSIDE THE QRV MAY EXPERIENCE DELAMINATION RESULTING IN SIGNIFICANT LEVELS OF AIR PRESSURE LEAKAGE PAST AND/OR THROUGH THE DIAPHRAGM, OR THE DEVELOPMENT OF A BUBBLE IN THE DIAPHRAGM WHICH MAY TRAP AIR PRESSURE IN THE VALVE AND NOT ALLOW THE SERVICE BRAKES TO RELEASE.

Consequence: MALFUNCTION OF THE AIR BRAKE SYSTEM COULD RESULT IN A VEHICLE CRASH.

Remedy: EACH VEHICLE MANUFACTURER WILL PROVIDE A REMEDY PLAN AND NOTIFICATION SCHEDULE. THE AFFECTED VEHICLES WILL BE REPAIRED WITHOUT CHARGE TO THE OWNERS. OWNERS MAY CONTACT THEIR VEHICLE MANUFACTURER OR SPARTAN CHASSIS TOLL-FREE AT 1-800-543-4277.

Reported: 2009-12-16 (December 16, 2009) · Model years: 2008, 2009, 2010

SPARTAN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 MM, K2, AND K3 MOTORHOME CHASSIS MANUFACTURED FROM APRIL 27, 2007 AND AUGUST 11, 2009, EQUIPPED WITH PNEUMATIC AND HYDRAULIC ADJUSTABLE BRAKE PEDAL ASSEMBLIES P/NOS. 6562618, 6565118, 77025-001, 77025-002, 77025-501, 77050-004, SUPPLIED BY KONGSBERG AUTOMOTIVE. SOME ASSEMBLIES COULD CONTAIN A DRIVE PIN THAT IS BELOW SPECIFICATION AND MAY BECOME DISENGAGED FROM THE BRAKE ARM CAUSING SEPARATION OR LOOSENING OF THE PEDAL FROM THE REMAINDER OF THE ASSEMBLY.

Consequence: IF THE DRIVE PIN BECOMES DISENGAGED ON THE BRAKE PEDAL ASSEMBLY, IT COULD RESULT IN A LOSS OF VEHICLE BRAKING FUNCTION AND/OR CAUSE THE BRAKE PEDAL TO INTERFERE WITH THE THROTTLE PEDAL FUNCTION. EITHER CONDITION COULD RESULT IN A VEHICLE CRASH.

Remedy: SPARTAN IS WORKING WITH KONGSBERG AND THE VEHICLE MANUFACTURERS TO REMEDY THESE MOTORHOMES. PLEASE SEE RECALL 09E-064. THE REMEDY WILL BE PERFORMED BY SPARTAN FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 8, 2010. OWNERS MAY CONTACT SPARTAN TOLL-FREE AT 1-800-543-4277 - OPTION 1.

Reported: 2010-06-28 (June 28, 2010) · Model years: 2008, 2009, 2010, 2011

SPARTAN IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 RECREATION VEHICLE CHASSIS MANUFACTURED FROM JUNE 17, 2007 THROUGH MARCH 15, 2010 EQUIPPED WITH TRW IGEN3 INTERMEDIATE STEERING COLUMNS. THE WELD AROUND THE IGEN3 STEERING SHAFT TUBE THAT SECURES THE SPLINE TUBE TO THE INTERMEDIATE TUBE MAY BE MISLOCATED (I.E., NOT FULLY OVER THE SEAM CREATED WHEN THE TUBES ARE PRESSED TOGETHER.)

Consequence: MISLOCATED WELDS MAY RESULT IN TORSIONAL AND AXIAL STRENGTH FALLING BELOW ACCEPTABLE LEVELS. THIS CONDITION COULD RESULT IN SEPARATION OF THE STEERING COLUMN, LOSS OF STEERING CONTROL AND A VEHICLE CRASH WITHOUT WARNING.

Remedy: SPARTAN WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 16, 2010. OWNERS MAY CONTACT SPARTAN AT SPARTAN CHASSIS AT 1-800-543-5008 - OPTION 5.

Reported: 2012-09-04 (September 4, 2012) · Model years: 2008, 2009, 2010, 2012, 2013

Spartan is recalling certain model year 2008-2013 K2 and MM motor home chassis, equipped with a Hendrickson independent front suspension. The front brake chambers may contact the upper control arm of the independent front suspension. Continued contact may result in damage sufficient enough to inhibit the full release of the brakes. If the brakes do not fully release, as they drag, heat could be generated causing the brakes to engage even further.

Consequence: As the brakes self-engage, the driver could lose control of the vehicle, increasing the risk of a crash.

Remedy: Spartan chassis will notify owners, and repair the vehicles free of charge. The safety recall began on Decenber 5, 2012. Owners may contact Spartan at 1-800-543-4277 Option 1.

Reported: 2013-08-30 (August 30, 2013) · Model years: 2009, 2010, 2011, 2012

Spartan Motor Chassis, Inc. (Spartan) is recalling certain model year 2009-2012 MM, 2011-2014 K2, and 2010-2012 K3 motor home chassis. Due to contact with the steering relay rod, the ABS modulator valve may fracture resulting in air not being applied to the affected wheel end.

Consequence: This may increase stopping distance of the vehicle or cause the vehicle to pull to one side. Either condition increases the risk of a crash.

Remedy: Spartan will notify owners and dealers will reorient the ABS modulator valve and install spacers for additional clearance, free of charge. The recall began on September 17, 2013. Owners may contact Spartan at 1-517-543-6400. spartan's recall campaign number is 12008.

Reported: 2011-10-17 (October 17, 2011) · Model years: 2010, 2011

SPARTAN IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 INCOMPLETE RECREATIONAL VEHICLE CHASSIS MANUFACTURED FROM JANUARY 4, 2010, THROUGH JANUARY 26, 2011, EQUIPPED WITH AN ELECTRONIC CONTROL MODULE, PART NUMBER 2791-NN2E-001 OR 2791-NN2E-002. WHEN THE BRAKE IS APPLIED, THE CRUISE CONTROL MAY NOT CANCEL. ADDITIONALLY, THESE VEHICLES MAY EXHIBIT AN INADVERTENT, MODERATE INCREASE IN VEHICLE SPEED UNTIL THE VEHICLES REACHES ITS GOVERNED SPEED AFTER THE VEHICLE'S CRUISE CONTROL IS SET.

Consequence: IF THE DRIVER ATTEMPTS TO CANCEL THE CRUISE CONTROL BY APPLYING THE BRAKE OR IF THE VEHICLE SPEED INCREASES AND THE DRIVER IS UNAWARE, THEY MAY HAVE REDUCED CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: SPARTAN WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 9, 2012. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400.

Reported: 2014-01-28 (January 28, 2014) · Model years: 2010, 2011, 2012, 2013, 2014

Spartan Motors Chassis, Inc. (Spartan Chassis) is recalling certain 2010-2014 model year MM motorhome chassis manufactured December 11, 2009, through January 30, 2013, and equipped with a sway bar and model 1253 front suspension. This front suspension design has increased rebound travel which may result in a binding condition of the sway bar end link which could lead to the breaking of the sway bar end links.

Consequence: Broken sway bar end links may result in poor vehicle handling, or sway, which increases the risk of a crash.

Remedy: Spartan Chassis will notify owners, and dealers will replace the old end links with new end links and an improved mounting, free of charge. The recall began on March 4, 2014. Customers may contact Spartan Chassis at 1-517-543-6400. Spartan Chassis's number for this recall is 12012.

Reported: 2011-08-11 (August 11, 2011) · Model years: 2011, 2012

Spartan Motors Chassis, Inc. (Spartan Chassis) is recalling certain 2011 SU and 2011 through 2012 model year MM, K2, and K3 recreational vehicle chassis manufactured from January 28, 2011, through June 28, 2011, equipped with air gauges supplied by Ametek. An incorrect value may have been used in the formula for calculating the sweep angle of the dial. This may have resulted in the accuracy of the gauge varying as much as eleven percent from the cutout pressure as opposed to the maximum allowable of +/- seven percent. Consequently, these chassis fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 121, "Air Brake Systems."

Consequence: In a condition where constant braking may be necessary, the air systems may deplete sooner than expected. This could cause the application of the spring brake without warning and may result in a vehicle crash.

Remedy: Spartan Chassis will notify owners and replace the affected guages with compliant ones, free of charge. The recall began on September 12, 2013. Owners may contact Spartan at 1-800-543-4277 - Option 1. Spartan's campagn number is 11018.

Reported: 2011-08-17 (August 17, 2011) · Model years: 2011, 2012

SPARTAN IS RECALLING CERTAIN MODEL YEAR 2010, 2011, AND 2012 RECREATIONAL VEHICLES, MODELS MM, K2, K3, BUS, FURION, GLADIATOR, AND METRO STAR, MANUFACTURED FROM SEPTEMBER 29, 2010, THROUGH JUNE 20, 2011, EQUIPPED WITH A CUMMINS ISB, ISC, ISL, OR ISX DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Consequence: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy: SPARTAN IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR SPARTAN AT 1-800-543-5008 - OPTION 5.

Reported: 2013-09-18 (September 18, 2013) · Model years: 2011, 2012

Spartan Motors Chassis, Inc. (Spartan Chassis) is recalling certain model year 2011-2012 motorhomes manufactured January 28, 2010, through March 12, 2012; and equipped with Cummins ISC engines. The affected vehicles have radiator cooling fans that spin excessively fast resulting in the fan blades breaking without warning.

Consequence: If this occurs while the hood is open, a person in the vicinity of the engine could be struck by the blade and injured.

Remedy: Spartan will notify owners, and dealers will repair the vehicles free of charge. The recall began on November 15, 2013. Owners may contact Spartan Chassis at 1-517-543-6400. Spartan Chassis's number for this campaign is 13021.

Reported: 2017-03-13 (March 13, 2017) · Model years: 2011, 2012, 2013, 2014, 2015, 2016, 2017

Spartan Motors USA (Spartan) is recalling certain 2011-2017 Gladiator, 2016-2017 MetroStar, 2012-2018 K2, 2011-2018 K3, 2017-2018 K4, and 2011-2017 MM vehicles. The ball joints on the independent front suspension (IFS) modules can loosen and separate, leading to a partial loss of steering.

Consequence: A separated ball joint can cause a loss of steering control, increasing the risk of a crash.

Remedy: Spartan will notify owners, and dealers will remove, clean, apply thread locker, and reinstall the properly torqued ball joint, free of charge. The recall began on March 24, 2017. Owners may contact Spartan customer service at 1-800-543-4277. Spartan's number for this recall is 17004.

Reported: 2013-06-10 (June 10, 2013) · Model years: 2012, 2013

Spartan Motors, Inc. (Spartan) is recalling certain model year 2012-2013 K2, K3, and MM motor homes manufactured March 2, 2012, through July 30, 2012 and equipped with a 1660 independent front suspension supplied by Reyco Granning. The motor homes may have incorrect wheel bearings installed in the front suspension.

Consequence: Incorrect wheel bearings may cause the vehicle to pull to one side and with continued use, there is a risk of a fire starting at the wheel.

Remedy: Spartan will notify owners and dealers will inspect the bearings and replace them, as needed, free of charge. The recall began on July 8, 2013. Owners may contact Spartan at 1-517-543-6400. Spartan's campaign number is 13-009.

Reported: 2012-12-06 (December 6, 2012) · Model years: 2013

Spartan Motors Chassis is recalling certain model year 2013 K2, K3, and MM motorhome chassis, manufactured July 23, 2012, through November 7, 2012 and equipped with an independent front suspension that has the ABS modulator valve mounted in a forward position. The front brake hoses or the ABS sensor cable may be damaged as a result of contact with the swaybar.

Consequence: Damaged brake hoses will result in insufficient air being applied to the front brake chambers. Lack of air to the front brake may increase stopping distances. Damage to the ABS sensor cable may disable the ABS. Either condition may increase the risk of a vehicle crash.

Remedy: Spartan will notify owners, and dealers will repair the vehicles free of charge. The recall began December 20, 2012. Owners may contact Spartan at 1-517-543-6400.

Reported: 2013-10-25 (October 25, 2013) · Model years: 2013, 2014

Spartan Motors Inc. (Spartan) is recalling certain model year 2013-2014 K2, K3, MetroStar, and MM motor homes and one emergency response chassis. Castle nuts for the steering linkage ball joint fasteners, which mount to bell cranks, may be loose. If the castle nuts become completely loose, the steering linkage may separate from the bell cranks without warning.

Consequence: This may cause a loss of steering, increasing the risk of a crash.

Remedy: Spartan will notify owners, and dealers will inspect the castle nuts and tighten them as necessary. The recall began on December 9, 2013. Owners may contact Spartan at 1-517-543-6400. Spartan's recall campaign number is 13025.

Reported: 2014-11-24 (November 24, 2014) · Model years: 2013, 2014, 2015

Spartan Motors, Inc. (Spartan) is recalling certain model year 2013-2015 Gladiator, DR, K2, K3, MetroStar, MM, and NVS vehicles manufactured December 14, 2011, to October 21, 2014, equipped with certain Wabco Quick Release Valves with Double Check. In the affected valves, the rubber diaphragm may be damaged by sharp edges on the valve seat ribs, reducing the available air pressure in the air tanks.

Consequence: The reduced air pressure levels may reduce braking performance and/or the parking brakes could reapply, increasing the risk of a crash.

Remedy: Spartan will notify owners, and dealers will inspect and replace the valve, free of charge. The recall began January 22, 2015. Owners may contact Spartan customer service at 1-517-543-6400. Spartan's number for this recall is 14021.

Reported: 2014-12-23 (December 23, 2014) · Model years: 2013, 2014, 2015

Spartan Motors, Inc. (Spartan) is recalling certain model year 2013-2015 Gladiator, K2, K3, MetroStar, and MM motorhome and emergency response chassis cabs manufactured November 28, 2012, to October 15, 2013. The castle nuts for the steering linkage may loosen, allowing the steering linkage to separate.

Consequence: If the steering linkage separates, a loss of steering control would occur, increasing the risk of a crash.

Remedy: Spartan will notify owners, and dealers will inspect and tighten the castle nuts, as necessary, free of charge. The recall began on January 26, 2015. Owners may contact Spartan customer service at 1-517-543-6400. Spartan's number for this recall is 14023.

Reported: 2014-08-18 (August 18, 2014) · Model years: 2015

Spartan Motors Chassis, Inc. (Spartan) is recalling certain model year 2014-2015 Gladiator emergency vehicles, 2013-2014 Metrostar emergency vehicles, 2015 motorhome chassis, and 2015 school buses chassis. The Cummins ISB or ISL engines in these vehicles may have been equipped with Fleetguard UFF-XT fuel filters, part number FF63009, whose filter shell may separate from the fuel filter nut plate causing the engine to stall without warning.

Consequence: If the engine stalls unexpectedly, there is an increased risk of a crash.

Remedy: Spartan has notified the final stage manufacturers, and Cummins will replace the affected fuel filters, free of charge. The recall began in August 2014. Owners may contact Spartan customer service at 1-517-543-6400. Owners may also contact Cummins customer service at 1-800-223-4583.

Reported: 2015-01-16 (January 16, 2015) · Model years: 2015

Spartan Motors, Inc. (Spartan) is recalling certain model year 2015 Spartan MM chassis manufactured October 2, 2013, to November 19, 2014. In the affected vehicles, the front sway bar mounting brackets may break, causing the sway bar to detach from the mounting frame.

Consequence: If the sway bar detaches, additional vehicle sway may occur, increasing the risk of a crash.

Remedy: Spartan will notify owners and dealers will replace the front sway bar mounting brackets, free of charge. The recall began on May 15, 2015. Spartan issued an interim notification to owners on March 4, 2015. Owners may contact Spartan customer service at 1-517-543-6400.

Reported: 2015-06-19 (June 19, 2015) · Model years: 2015, 2016

Spartan Motors, Inc. (Spartan) is recalling certain model year 2015-2016 K2, K3 and MM chassis manufactured October 2, 2013, to April 2, 2015. In the affected vehicles, the fasteners that attach the stay rod (v-rod) to the rear drive axle may not have been installed with thread locker or tightened in the correct sequence.

Consequence: If the fasteners come loose, the stay rod may disconnect from the rear axle, resulting in a loss of control, increasing the risk of a crash.

Remedy: Spartan will notify owners, and dealers will replace the fasteners using thread lock, tightening them in the proper sequence and with the required torque values, free of charge. The recall began on August 11, 2015. Owners may contact Spartan customer service at 1-800-582-3454. Spartan's number for this recall is 15010.