1995 Mercury VILLAGER problems and owner complaints

SIDE SLIDING DOOR STICKS,SLIDING DOOR WINDOW DOESNT STAY SHUT,LOCKS WILL LOCK THEMSELVES ,BACK WIPER MALFUNCTIONS,GRINDING AND SQUEAKING FROM BRAKES,SMELL OF FUEL FROM PASSENGER SIDE AND PASSENGER P/W STICKS SOMETIMES

Owner-reported narrative. Look up ODI 10070535 at NHTSA ↗

VERY STRONG SMELLING GAS FUMES INSIDE PASSENGER COMPARTMENT WHEN HEATER IS TURNED ON. WHILE DRIVING THE SPEED GAUGE WILL STOP WORKING AND THE CHECK ENGINE LIGHT WILL COME ON. BRAKES MAKE A GRINDING NOISE EVEN AFTER BEING REPLACED. CV BOOT IS LEAKING AND CRACKED. DRIVER SIDE AUTO-SEAT BELT SOMETIMES FAILS TO GO UP AND DOWN. REAR WINDSHIELD WIPER GETS STUCK IN UP POSITIONS WHEN TRING TO USE IT. *AK

Owner-reported narrative. Look up ODI 10080599 at NHTSA ↗

AFTER STARTING THE CAR, PARTICULARITY IN COLDER WEATHER, THERE IS A STRONG SMELL OF GASOLINE IN THE PASSENGER COMPARTMENT. UPON ENGINE INSPECTION, THERE IS A NOTICEABLE GASOLINE "WETNESS" UNDER THE FUEL INJECTOR. A NUMBER OF VISITS TO A LOCAL DEALER IN WHITE PLAINS PRODUCED "WE SMELL IT BUT CANNOT FIND IT" RESPONSE. NEW CLAMPS ON THE RUBBER HOUSE UNDER THE FUEL INJECTOR WHERE "WETNESS" WAS OBSERVED DID NOT PREVENT THE PROBLEM. THE PROBLEM APPEARS PROGRESSIVE. CURRENTLY (ONE YEAR LATER), THE SMELL OF FUEL IS CONSTANT. *NLM

Owner-reported narrative. 65,000 miles reported. Look up ODI 10014307 at NHTSA ↗

FUEL ODOR INSIDE PASSANGER COMPARTMENT DUE TO FUEL LINE LEAK ON FUEL INJECTOR RAIL SEVERE FIRE HAZARD BAD PLACEMENT OF RUBBER FUEL LINE.!!!!!

Owner-reported narrative. 147,000 miles reported. Look up ODI 10058446 at NHTSA ↗

IN VERY HIGH TEMPERATURES, MY VAN STALLS AND EVENTUALLY SPLATTERS AND QUITS. THIS HAS HAPPENED ON THREE OCASSIONS WITH MY WIFE AND ONCE WITH ME AND BECAUSE IT STALLS, THE STEERING GETS REALLY HARD AND ALMOST CAUSED ME TO RUN INTO ANOTHER VEHICLE AT A STOP LIGHT.

Owner-reported narrative. 113,989 miles reported. Look up ODI 10136868 at NHTSA ↗

DT*: THE CONTACT STATED THE ENGINE STALLED AND WOULD NOT RESTART AFTER REVERSING OUT OF A DRIVEWAY. THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE WAS PUT IN DRIVE PRIOR TO THE STALLING. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THE END OF THE CRANKSHAFT SNAPPED OFF AND THE ENGINE NEEDED TO BE REPLACED. UPDATED 9/20/2006 - *NM

Owner-reported narrative. 92,000 miles reported. Look up ODI 10166858 at NHTSA ↗

NOTCH WORN INTO THE SLIDING SURFACE ON STEERING KNUCKLE FOR FRONT BRAKE PADS PREVENTING THE OUTER PAD FROM SLIDING AND SELF ADJUSTING CAUSING OUTER PADS TO REMAIN STATIONERY AND CREATE LOUD GRINDING NOISE AND ANTILOCK BRAKES TO MALFUNCTION DEALER STATED THAT THIS IS COMMON, THIS SLIDING SURFACE SHOULD BE A NON WEAR SURFACE AND LAST THE LIFE OF THE CAR WITH NO WEAR.

Owner-reported narrative. Look up ODI 730983 at NHTSA ↗

THE PAINT IS CRACKED ON THE HOOD, UNKNOWN WHAT MONTH, ABOUT 1997. WE NEVER HAD IT FIXED. DRIVERS DOOR SEATBELT STAYS IN THE RUNNING POSITION, IT WON'T MOVE FORWARD, BUT IT MAKES A LOUD MOTOR NOISE, UNKNOWN WHAT MONTH, SINCE ABOUT 1999. WE NEVER HAD IT FIXED. THE SEAT BELT ON THE RIGHT NEXT TO THE MIDDLE SEAT FELL OFF. WE TOLD THE DEALER. THEY ORDERED ONE. WE WENT BACK ABOUT A MONTH LATER THEY SAID IT WAS TOO LATE TO FIX IT. THE TRANSMISSION WENT OUT IN ABOUT MAY OF 1998, AT ABOUT 120,000 MILES. WE HAD IT REBUILT. IT WENT OUT AGAIN ABOUT A Y…

Owner-reported narrative. 120,000 miles reported. Look up ODI 10070382 at NHTSA ↗

VEHICLE GEAR SHIFT APPEARS TO GO INTO PARK, HOWEVER THE TRANSMISSION IS NOT REALLY IN PARK, THUS CAUSING THE VEHICLE TO ROLL, POSSIBLY WHEN NO ONE IS INSIDE THE VEHICLE. IN ADDITION, THIS CONDITION CAN CAUSE THE DRIVER TO BE STRANDED BECAUSE THE CAR WILL NOT RESTART DUE TO IT NOT BEING ENGAGED IN THE PARK POSITION.*AK

Owner-reported narrative. 75,246 miles reported. Look up ODI 10116315 at NHTSA ↗

DT: THE CONTACT STATED ON 9-8-05 HAD THE CRUISE CONTROL ON AT APPROXIMATELY 62 MPH AND SUDDENLY THE CAR STARTED COASTING. IT SLOWED DOWN. HE PULLED OVER AND STOPPED THE CAR. HE OPENED THE HOOD, AND THERE WAS A BIG FIRE ON THE DISTRIBUTOR AND IGNITION AREAS. ALL OF THE SIX WIRES MELTED. THE CONTACT HAD IT TOWED TO A WORKSHOP, AND THEY SAID HE SHOULD CALL THE FORD CUSTOMER SERVICE. THE CONTACT CALLED FORD, AND FORD SAID SOMEONE WOULD GET IN TOUCH WITH HIM. THE MECHANIC AT THE WORKSHOP TOLD FORD THAT IT SEEMED TO BE AN ELECTRICAL FIRE…

Owner-reported narrative. 153,000 miles reported. Look up ODI 10135961 at NHTSA ↗

DRIVER DOOR LOCK CONTROL FAILS TO LOCK OR UNLOCK 3 DOORS. ELECTRICAL SHORT CAUSING RADIO MEMORY TO CLEAR. THE REAR AC/HEATER STARTS AND STOPS WHEN DASH SWITCH IS IN THE "REAR" POSITION. *AK

Owner-reported narrative. Look up ODI 750141 at NHTSA ↗