Mazda 626 recalls by model year

Reported: 1983-05-10 (May 10, 1983) · Model years: 1979, 1980, 1981, 1982

ANCHORAGE BOLT MAY HAVE BEEN IMPROPERLY REINSTALLED AFTER VEHICLE REPAIR. THE BOLT COULD LOOSEN DURING NORMAL VEHICLE OPERATION.

Remedy: UPON INSPECTION, ALL IMPROPERLY INSTALLED BOLTS WILL BE REMOVED AND REINSTALLED CORRECTLY.

Reported: 1985-09-04 (September 4, 1985) · Model years: 1979, 1980, 1981, 1982

IN CERTAIN HIGH SALT AREAS, THE IDLER ARM IS EXPOSED TO ROAD SALT WHICH CAUSES THE DUST SEAL TO DETERIORATE RESULTING IN IDLER ARM PIN CORROSION. THIS CAUSES THE PIN TO FREEZE AND BREAK. CONSEQUENCE OF DEFECT: A BROKEN IDLER ARM PIN COULD RESULT IN LOSS OF STEERING CONTROL AND MAY CAUSE AN ACCIDENT.

Remedy: REPLACE PIN WITH ONE OF IMPROVED CORROSION RESISTANT QUALITY.

Reported: 1986-03-11 (March 11, 1986) · Model years: 1986

THE THROTTLE ANGLE SENSOR ON THE CARBURETOR MAY CONTAIN A NYLON ROTOR WHICH HAS NOT BEEN HEAT TREATED. ROTORS THAT HAVE NOT BEEN HEAT TREATED CONTRACT IN THE PRESENCE OF HEAT CAUSING THE THROTTLE MECHANISM TO STICK. CONSEQUENCE OF DEFECT: THIS MAY CAUSE THE THROTTLE TO STICK IN THE OPEN POSITION WHICH MAY RESULT IN LOSS OF CONTROL LEADING TO AN ACCIDENT. ALSO,VEHICLE MAY NOT CONFORM WITH STANDARD 124.

Remedy: REPLACE THROTTLE ANGLE SENSOR ASSEMBLIES WITH NEW HEAT TREATED ROTORS WITH LARGER INSIDE DIAMETERS.

Reported: 1990-06-14 (June 14, 1990) · Model years: 1986, 1987

IGNITION SWITCH TERMINAL MAY MALFUNCTION.

Consequence: THIS COULD RESULT IN FAILURE OF WINDSHIELD WIPERS,WINDSHIELD WASHER, ENGINE COOLING FAN, HEATER BLOWER, AND AIR CONDITIONINGCOMPRESSOR. FAILURE OF WINDSHIELD CLEARING DEVICES COULD CAUSE REDUCEDVISIBILITY, WHICH COULD RESULT IN AN ACCIDENT.

Remedy: REPLACE IGNITION SWITCHES.

Reported: 1987-09-17 (September 17, 1987) · Model years: 1988

FLOOR MAT COULD INTERFERE WITH RELEASE OF ACCELERATOR PEDAL DUE TO IMPROPER SHAPE OF MAT.

Consequence: THIS COULD RESULT IN LOSS OF ACCELERATOR CONTROL ANDCREATE POTENTIAL FOR AN ACCIDENT.

Remedy: REMOVE PRESENT MAT AND REPLACE WITH NEW IMPROVED MAT.

Reported: 1987-12-07 (December 7, 1987) · Model years: 1988

FUEL TANK FIXING BAND RETENTION IS NOT SUFFICIENT, ALLOWING THE BAND TO RUB AGAINST THE FUEL TANK BY VEHICLE VIBRATIONS.

Consequence: THIS COULD WEAR A HOLE IN THE FUEL TANK WHICH COULDRESULT IN FUEL LEAKAGE.

Remedy: REPAIR FUEL FIXING BAND BY INSTALLING A RUBBER SHEET.

Reported: 1987-12-29 (December 29, 1987) · Model years: 1988

VEHICLES EQUIPPED WITH REAR BRAKE DRUMS TRANSPORTED BY TRAIN MAY EXPERIENCE SEPARATION OF THE BRAKE SHOE FROM THE WHEEL BRAKE CYLINDER PISTON.

Consequence: SHOULD SEPARATION OCCUR, REPEATED BRAKE OPERATION MAYDAMAGE THE WHEEL BRAKE CYLINDER DUST BOOT, ALLOWING WATER OR DUST INTRUSION ANDSUBSEQUENT PISTON CONTAMINATION.

Remedy: ALL VEHICLES WILL BE INSPECTED AND IF NO SEPARATION IS FOUND GREASE WILL BE APPLIED TO THE COMPONENT INTERFACE TO LOWER FRICTION AND AVOID SUBSEQUENT RELATIVE MOTION. IF SEPARATION IS FOUND THE WHEEL BRAKE CYLINDER DUST BOOT WILL BE REPLACED.

Reported: 1988-02-22 (February 22, 1988) · Model years: 1988

AT AMBIENT TEMPERATURES BELOW 0 DEGREE F, FROST MAY ACCUMULATE WITHIN THE THROTTLE BODY UNDER EXTENDED CONSTANT SPEED OPERATION.

Consequence: FROST ACCUMULATION ON THE THROTTLE VALVE MAY PREVENT THEVALVE FROM RETURNING SMOOTHLY.

Remedy: INSTALL A NEW TYPE THERMOSTAT DESIGNED TO RAISE THE COOLANT TEMPERATURE AND WARM THE THROTTLE BODY TO A LEVEL ABOVE FREEZING.

Reported: 1988-04-14 (April 14, 1988) · Model years: 1988

THE DRIVE SPRING THAT DRIVES THE AUTOMATIC BELT MAY BREAK.

Consequence: THIS WOULD PREVENT FULL FORWARD MOVEMENT OF THE SEAT BELTANCHORAGE FROM THE LOCK POSITION WHEN THE DOOR IS OPENED.

Remedy: REPLACE AUTOMATIC SHOULDER BELT.

Reported: 1993-10-29 (October 29, 1993) · Model years: 1988, 1989, 1990, 1991

RESIN MOLDED FRONT HANDLES FAIL AT THE DOOR LATCH ACTUATING ROD ATTACHMENT, FREEING THE ROD TO FALL INSIDE THE DOOR FRAME. SUBSEQUENT LOWERING OF THE ASSOCIATED WINDOW MAY FORCE THE ACTUATING ROD DOWNWARD AND RELEASE THE DOOR LATCH.

Consequence: INADVERTENT ACTUATION OF THE DOOR LATCH CAUSES THE DOORTO OPEN UNEXPECTEDLY WHICH COULD RESULT IN AN OCCUPANT FALLING OUT OF THEVEHICLE.

Remedy: DEALERS WILL REPLACE THE DOOR HANDLE/LATCH ASSEMBLY.

Reported: 2015-10-19 (October 19, 2015) · Model years: 1993, 1994, 1995, 1996, 1997, 1998

Mazda North American Operations (Mazda) is recalling certain model year 1989-1998 MPV, 1990-1995 323, 1990-1998 Protege, 1992-1993 MX-3, 1993-1995 929, 1993-1997 MX-6, and 1993-1998 626 vehicles. In the affected vehicles, grease applied to the contact points inside the ignition switch may become conductive and overheat.

Consequence: If the ignition switch overheats there would be an increased risk of a fire.

Remedy: Mazda will notify owners, and dealers will replace the ignition switch, free of charge. The recall began on December 17, 2015. Owners may contact Mazda Customer Experience Center at 1-800-222-5500, option#6. Mazda's number for this recall is 8715J.

Reported: 1999-12-17 (December 17, 1999) · Model years: 1994

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHT WIRE THAT RUNS THROUGH THE TURN SIGNAL LEVER CAN FAIL AT THE POINT WHERE IT IS SOLDERED TO THE HEADLIGHT SWITCH.

Consequence: THE FAILURE OF THIS WIRE COULD CAUSE A LOSS OF HEADLIGHTS, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE HEADLIGHT SWITCH LEVER.

Reported: 1998-10-08 (October 8, 1998) · Model years: 1995, 1996, 1997

VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE SAS SENSOR UNIT. THESE VEHICLES CAN EXPERIENCE AIR BAG DEPLOYMENTS IN MINOR UNDERCARRIAGE IMPACTS.

Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.

Remedy: DEALERS WILL REPROGRAM THE SAS UNIT TO REDUCE THE PROBABILITY OF UNNECESSARY DEPLOYMENTS IN LOW SPEED UNDERCARRIAGE IMPACTS.

Reported: 1998-09-08 (September 8, 1998) · Model years: 1997

VEHICLE DESCRIPTION: PASSENGER VEHICLES. AN EXTERNAL SPRING IN THE TIMING BELT TENSIONER CAN BREAK AND GET CAUGHT IN THE TIMING BELT.

Consequence: THIS CONDITION CAN RESULT IN POSSIBLE ENGINE STALLING.

Remedy: DEALERS WILL INSPECT THE TENSIONER AND REPLACE IT IF NECESSARY.

Reported: 2000-05-09 (May 9, 2000) · Model years: 1998, 1999

VEHICLE DESCRIPTION: PASSENGER VEHICLES. AN EXTERNAL SPRING IN THE TIMING BELT TENSIONER COULD BREAK.

Consequence: THE BROKEN SPRING MAY GET CAUGHT IN THE TIMING BELT, RESULTING POSSIBLE ENGINE STALLING.

Remedy: DEALERS WILL CHECK THE TENSIONER INSTALLED AND REPLACE IT IF THE VEHICLE IS EQUIPPED WITH THE AFFECTED TENSIONER.

Reported: 1997-12-17 (December 17, 1997) · Model years: 1998

VEHICLE DESCRIPTION: PASSENGER VEHICLES. DUE TO A PROGRAMMING ERROR, THE POWERTRAIN CONTROL MODULE (PCM) INSTALLED CAN, UNDER CERTAIN DRIVING CONDITIONS, TRIGGER A SHIFT IN AIR-FUEL RATIO TO AN OVERLEAN CONDITION.

Consequence: THIS CONDITION CAN RESULT IN AN ENGINE STALL, WHICH COULD LEAD TO LOSS OF VEHICLE CONTROL AND/OR A VEHICLE CRASH.

Remedy: DEALERS WILL REPROGRAM THE PCM WITH THE CORRECT ENGINE CONTROL LOGIC.

Reported: 1998-10-02 (October 2, 1998) · Model years: 1998

VEHICLE DESCRIPTION: IF THE VEHICLE IS OPERATED IN A HOT, HUMID ENVIRONMENT WITH THE WINDOW OPEN AND AIR CONDITIONER RUNNING, IT IS POSSIBLE FOR CONDENSATION TO ENTER THE AUDIO UNIT AND CAUSE A SHORT CIRCUIT.

Consequence: IF THE SHORT CIRCUIT OCCURS AT ONE SPECIFIC SET OF TERMINALS, THE SPEAKER CAN OVERHEAT AND IN SOME CASES, CATCH FIRE.

Remedy: DEALERS WILL AFFIX ALUMINUM TAPE OVER THE AUDIO UNIT TO PREVENT WATER FROM ENTERING.

Reported: 2000-03-07 (March 7, 2000) · Model years: 1999, 2000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. CERTAIN RESERVOIR TANK CAPS ON THE BRAKE MASTER CYLINDER WERE PRODUCED WITH A WORN OUT DIE AND LACK VENTILATION HOLES. AS A RESULT, THE PRESSURE IN THE RESERVOIR TANK CAN DROP GRADUALLY AS THE BRAKE PAD OR SHOE WEARS AND AMBIENT TEMPERATURE DROPS. ALSO, THE PRESSURE COULD REACH A POINT THAT THE BRAKE CALIPER AND DRUM CYLINDER ARE PULLED BACK BY THE VACUUM IN THE RESERVOIR TANK WHEN THE VEHICLE IS PARKED FOR A LONG TIME.

Consequence: THIS CONDITION COULD CAUSE REDUCED BRAKE EFFICIENCY, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSPECT THE RESERVOIR CAP AND REPLACE IT, IF NECESSARY.