Jayco Travel Trailer JAY FLIGHT recalls by model year

Reported: 2014-09-12 (September 12, 2014) · Model years: 2015

Jayco, Inc. (Jayco) is recalling certain model year 2015 19RD (TP) Jay Flight trailers manufactured May 19, 2014, to May 21, 2014. The affected trailers may have been manufactured with the roof ladder installed on the door side of the trailer. This incorrect location does not have a reinforcing backer to hold the ladder to the trailer.

Consequence: If the ladder does not have the support of the backer, when the ladder is used, the screws can pull out of the trailer wall and the ladder may give, increasing the risk of injury to the ladder user.

Remedy: Jayco will notify owners, and dealers will inspect the placement of the ladder, and install a backer if the ladder is installed on the wrong side, free of charge. The recall began on September 30, 2014. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9901220.

Reported: 2014-09-23 (September 23, 2014) · Model years: 2015

Jayco, Inc. (Jayco) is recalling certain model year 2015 Jay Flight travel trailers, models 264BHW (7V) and 267BHSW (7W), manufactured April 23, 2014, to June 4, 2014. The affected trailers are equipped with the roof AC option, eliminating the roof vent. As such, since the window does not open, there is inadequate venting for the gases emanating from the range.

Consequence: In the event of a situation where the propane gas continues to flow, if the gas range cannot vent, an ignition source may ignite the propane gas, resulting in a fire.

Remedy: Jayco will notify owners, and dealers will replace the non-opening window with a window that opens, free of charge. The recall began on October 28, 2014. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall 9901221.

Reported: 2014-11-04 (November 4, 2014) · Model years: 2015

Jayco, Inc. (Jayco) is recalling certain model year 2015 Jay Flight trailers manufactured July 10, 2014, to October 24, 2014. The affected trailers may have been manufactured with cargo carrying capacity labels that overstate the load carrying capacity. Thus these vehicles fail to comply with the requirements of the Federal Motor Vehicles Safety Standards No.110, "Tire Selection and Rims and Motor Home/Recreation Vehicle Trailer Load Carrying Capacity Information for Motor Vehicles with a GVWR of 4,536 kilograms (10,000 pounds) or less."

Consequence: A vehicle operator could inadvertently overload the trailer due to the incorrect information on the label and induce premature tire wear or a tire failure, increasing the risk of a vehicle crash.

Remedy: Jayco will notify owners, and dealers will install corrected labels, free of charge. The recall began November 18, 2014. Owners may contact Jayco customer service at 1-800-283-8267.

Reported: 2017-11-21 (November 21, 2017) · Model years: 2015, 2016

Jayco, Inc. (Jayco) is recalling various 2002-2016 recreational vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V746-9524.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Jayco will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Jayco customer service at 1-800-283-8267, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Reported: 2016-07-27 (July 27, 2016) · Model years: 2016, 2017

Jayco, Inc. (Jayco) is recalling certain model year 2016-2017 Jay Feather, Jay Flight, Jay Flight SLX, Eagle, White Hawk, and Octane travel trailers manufactured January 5, 2016, to July 18, 2016, equipped with a Sway Command anti-sway system. When connected to certain tow vehicles that have an integrated brake controller, and after the anti-sway system has applied the trailer brakes in response to a sway event, the trailer brakes may no longer function to slow or stop the trailer.

Consequence: A loss of trailer brakes may lengthen the distance needed to stop the vehicle and cause a loss of vehicle control, increasing the risk of a crash.

Remedy: Jayco will notify owners, and dealers will remove the Sway Command system from the affected travel trailers, free of charge. The recall began on August 3, 2016. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9901308.

Reported: 2016-05-20 (May 20, 2016) · Model years: 2017

Jayco, Inc. (Jayco) is recalling certain model year 2017 Jay Flight trailers manufactured May 6, 2016, to May 9, 2016. The weight ratings on the tire labels are incorrect. Thus, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard (FMVSS) No. 110, "Tire Selection and Rims."

Consequence: Incorrect weight ratings on the tire label could cause the operator to overload the vehicle and lead to premature tire wear, increasing the risk of a crash.

Remedy: All affected units are in dealer inventory. Dealers will be provided new, corrected labels. The recall began May 27, 2016. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9901299.

Reported: 2017-05-01 (May 1, 2017) · Model years: 2017

Jayco Inc. (Jayco) is recalling certain 2017 Jay Flight Bungalow, Hummingbird, White Hawk, Jay Flight SLX, Jay Feather 7, Jay Feather and Jay Flight fifth wheel recreational trailers. The LED ceiling lights may produce excessive heat.

Consequence: The excessive heat from the LED ceiling lights may increase the risk of a fire.

Remedy: Jayco will notify owners, and dealers will replace the affected LED ceiling lights with a different light, free of charge. The recall began on May 24, 2017. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for the recall is 9901349.

Reported: 2021-06-04 (June 4, 2021) · Model years: 2017, 2018, 2019, 2020, 2021

Jayco, Inc. (Jayco) is recalling certain 2017-2018 Jayco Designer, 2017-2021 Eagle HT, Eagle, Jay Feather, Jay Flight SLX, Jay Flight, North Point, Octane Superlite, Pinnacle, White Hawk, 2017-2020 Eagle HT, 2018-2021 Jay Flight Bungalow, 2017-2019 Octane, and 2019-2020 Eagle HTX travel trailers and fifth wheels equipped with a Winntec model 6020 two-stage propane regulator. The regulator may fail, causing an increase in propane pressure.

Consequence: Increased propane pressure can enlarge the flames in gas appliances, increasing the risk of a fire.

Remedy: Dealers will replace the regulator and test the propane system for leaks, free of charge. Owner notification letters were mailed August 3, 2021. Owners may contact Jayco customer service at 1-800-283-8267.

Reported: 2018-09-12 (September 12, 2018) · Model years: 2019

Jayco, Inc. (Jayco) is recalling certain 2019 Jayco White Hawk, Jay Flight, and Jay Flight SLX travel trailers. The axles may be missing inner bearing races on the hubs, which can cause the bearing to burnout or cause the hub to overheat.

Consequence: The missing bearing race may cause premature hub bearing failure, possibly resulting in a separation of the hub from the axle, thereby increasing the risk of a crash.

Remedy: Jayco will notify owners, and dealers will replace the defective hubs with new hubs or replace the axles, free of charge. The recall began October 18, 2018. Owners may contact Jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901410.

Reported: 2018-10-02 (October 2, 2018) · Model years: 2019

Jayco, Inc. (Jayco) is recalling certain 2019 Jayco Jay Flight travel trailers. The turn signal and brake lights were wired incorrectly causing the lights to work intermittently, preventing other drivers from knowing the intentions of the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: If the rear turn signals and brake lights do not operate as intended, other drivers will not be properly notified of stopping or turning, increasing the risk of a crash.

Remedy: Jayco has notified owners, and dealers will correctly wire the rear turn signals and brake lights to the 7-way trailer cord, free of charge. The recall began October 15, 2018. Owners may contact Jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901408.

Reported: 2019-04-30 (April 30, 2019) · Model years: 2019

Jayco, Inc. (Jayco) is recalling certain 2019 Jay Flight TF travel trailers, model 32RLOK. The supports for the fresh water tank may be too thin, resulting in the brackets breaking and the tanks detaching from the trailer.

Consequence: A detached water tank would be a road hazard, increasing the risk of crash.

Remedy: Jayco has notified owners, and dealers will install a threaded rod in the center of the water tank support apparatus to provide additional support, free of charge. The recall began May 9, 2019. Owners may contact Jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901433.

Reported: 2021-03-17 (March 17, 2021) · Model years: 2019, 2020

Jayco, Inc. (Jayco) is recalling certain 2019-2020 Jayco White Hawk, Jay Flight SLX, Jay Feather, and Jay Flight travel trailers equipped with Dometic 3 burner cooking stoves. The saddle valve securing bolt may be overtightened, possibly damaging the o-ring seal and causing a continuous gas leak.

Consequence: A gas leak can increase the risk of a fire.

Remedy: Jayco will notify owners, and Dometic service centers will install a remedy kit of gaskets, washers, thread locker bolts, and two round orange labels, free of charge. Owner notification letters were mailed on May 3, 2021. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9901566.

Reported: 2020-06-09 (June 9, 2020) · Model years: 2020

Jayco, Inc. (Jayco) is recalling certain 2020 Towable Eagle, Eagle HT, JayFlight, NorthPoint, Octane, Pinnacle, Seismic, and Talon recreational vehicles. The adhesive bond between the glass and the metal hinge frame of the frameless crank out vent and egress windows may fail which would then allow the glass to detach and fall out.

Consequence: If the window glass detaches while the vehicle is moving it could become a projectile, increasing the risk of injury or a crash.

Remedy: Jayco will notify owners, and dealers will inspect the frameless windows for proper adhesive bond strength, replacing the windows as necessary, free of charge. This recall began June 15, 2020. Owners may contact Jayco customer service at 1-800-517-9137. Jayco's number for this recall is 9901508.

Reported: 2021-09-02 (September 2, 2021) · Model years: 2021, 2022

Jayco, Inc. (Jayco) is recalling certain 2018-2021 Jayco Eagle, Talon, 2020 Eagle HT, 2021 Jay Feather, Jay Flight Bungalow, Jay Flight Octane, North Point, Octane Super Lite, Pinnacle, White Hawk, 2021-2022 Jay Flights SLX, Jay Flight, and 2017-2021 Seismic recreational vehicles, equipped with Winntec model 6020 two-stage propane regulators. The regulator may fail, causing an increase in propane pressure.

Consequence: Increased propane pressure can enlarge the flames in gas appliances, increasing the risk of a fire.

Remedy: Dealers will replace the regulator, and test the propane system for leaks, free of charge. Owner notification letters were mailed November 1, 2021. Owners may contact Jayco customer service at 1-800-283-8267.

Reported: 2022-10-14 (October 14, 2022) · Model years: 2021, 2022

Jayco, Inc. (Jayco) is recalling certain 2021-2022 Jayco Jay Feather, Jay Flight, and Jay Flight SLX travel trailers. The cooktop flame may invert when the stove and furnace are operated at the same time.

Consequence: An inverted cooktop flame increases the risk of injury or fire.

Remedy: Dealers will install sealant and plywood panels to seal the area, free of charge. Owner notification letters were mailed November 29, 2022. Owners may contact Jayco customer service at 1-800-283-8267. Jayco's number for this recall is 9901582.

Reported: 2022-08-04 (August 4, 2022) · Model years: 2022, 2024

Jayco, Inc. (Jayco) is recalling certain 2022-2023 Eagle, Eagle HT, Jayflight, Jayflight SLX, North point, Pinnacle, and Seismic travel trailers. The electric retractable awning has a welded seam on the fabric that may separate, potentially allowing the awning to drop beyond normal operation.

Consequence: An awning that drops or extends beyond normal operation can increase the risk of injury.

Remedy: Dealers will inspect and repair, or if necessary, replace awning fabric, free of charge. Owner notification letters were mailed August 31, 2022. Owners may contact Jayco's customer service at 1-800-283-8267. Jayco's number for this recall is 9901578.