Winnebago VECTRA recalls by model year

Reported: 1993-04-01 (April 1, 1993) · Model years: 1993

A VEHICLE THAT IS FULLY EQUIPPED AND LOADED WITH A TYPICAL PAYLOAD WILL CAUSE AN OVERLOADED CONDITION ON THE FRONT AXLE.

Consequence: OVERLOADING THE AXLE CAUSES THE FRONT AXLE COMPONENTSTO FAIL PREMATURELY WHICH MAY RESULT IN LOSS OF VEHICLE CONTROL AND PERSONALINJURY AND/OR VEHICLE DAMAGE.

Remedy: REPLACE THE FRONT AXLE AND SPRING ASSEMBLY WITH A HIGHER RATED AXLE ASSEMBLY.

Reported: 2010-10-26 (October 26, 2010) · Model years: 1996, 1997, 1998, 1999, 2000, 2001, 2002, 2003, 2004, 2005, 2006, 2007, 2008, 2009, 2010, 2011

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.

Reported: 2004-09-27 (September 27, 2004) · Model years: 2004, 2005

ON CERTAIN MOTOR HOMES BUILT ON A FREIGHTLINER CHASSIS WITH A 400-HP CUMMINS ENGINE, A SHEET METAL "TAB" ON A WIRE COVER LOCATED BEHIND THE ACCELERATOR PEDAL HAS THE POTENTIAL TO CATCH ON THE ACCELERATOR PEDAL.

Consequence: IF THE ACCELERATOR PEDAL HANGS UP ON THE TAB OF THE WIRE COVER, A HAZARDOUS SITUATION COULD RESULT IN THE PEDAL NOT GOING BACK TO IDLE POSITION, INCREASING THE RISK OF PERSONAL INJURY, VEHICLE DAMAGE AND, A CRASH COULD OCCUR.

Remedy: DEALERS WILL PROVIDE INSTRUCTIONS FOR OWNERS TO INSPECT AND IF NECESSARY HAVE THE WIRE COVER REPAIRED. IF OWNERS DO NOT FEEL COMFORTABLE PERFORMING THE INSPECTION, DEALERS WILL INSPECT AND REPAIR AS NECESSARY. THE RECALL BEGAN ON SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT WINNEBAGO AT 641-585-6939.

Reported: 2004-12-18 (December 18, 2004) · Model years: 2004, 2005

CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Consequence: THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

Remedy: DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.

Reported: 2005-12-28 (December 28, 2005) · Model years: 2006

ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC STEPS, THE STEPS MAY HAVE BEEN MANUFACTURED WITH DEFECTIVE STEP CONTROL UNITS.

Consequence: THE DEFECTIVE CONTROL UNITS COULD DEVELOP AN ELECTRICAL SHORT ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE, POSSIBLY RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.

Remedy: DEALERS WILL INSPECT THE KWIKEE STEP AND REPLACE THE STEP CONTROL UNIT, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 23, 2005. OWNERS MAY CONTACT WINNEBAGO AT 1-800-537-1885.

Reported: 2007-08-29 (August 29, 2007) · Model years: 2006, 2007

ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.

Consequence: IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, SPILLING OIL AND DEBRIS ONTO THE ROADWAY INCREASING THE RISK OF A CRASH.

Remedy: WINNEBAGO IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 OR WINNEBAGO AT 641-585-3535.

Reported: 2008-03-28 (March 28, 2008) · Model years: 2007

WINNEBAGO IS RECALLING 31 MY 2006-2008 JOURNEY, VOYAGE, MY 2006-2007 SIGHTSEER, MY 2006 ADVENTURER, MINNIE WINNIE, MY 2007 ACCESS, TOUR, VECTRA, ITASCA CAMBRIA, AND MY 2007-2008 ITASCA HORIZON MOTOR HOMES EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.

Remedy: WINNEBAGO IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). THE RECALL BEGAN ON APRIL 9, 2008. OWNERS MAY CONTACT RICON AT 1-818-267-3000.

Reported: 2008-10-30 (October 30, 2008) · Model years: 2008, 2009

WINNEBAGO IS RECALLING 594 MY 2008-2009 DESTINATION, JOURNEY, TOUR, VECTRA, AND ITASCA LATITUDE, MERIDIAN, ELLIPSE, AND HORIZON MOTOR HOMES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

Consequence: IF THE WELD FAILS, VEHICLE STABILITY WHILE CORNERING COULD BE AFFECTED RESULTING IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A CRASH. IN ADDITION, THE TRANSVERSE BEAM COULD DROP TO THE GROUND CAUSING SPARKS THAT COULD CAUSE A FIRE HAZARD.

Remedy: WINNEBAGO IS WORKING WITH DAIMLER TRUCKS/SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08V269 AND 08E031). OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712, SAF-HOLLAND AT 1-231-773-3271, OR WINNEBAGO AT 1-641-585-3535.

Reported: 2010-01-25 (January 25, 2010) · Model years: 2008, 2009

WINNEBAGO IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 WINNEBAGO VECTRA AND ITASC HORIZON MOTOR HOMES MANUFACTURED BETWEEN NOVEMBER 2006 AND MAY 2009, EQUIPPED WITH KONGSBERG AUTOMOTIVE ADJUSTABLE BRAKE PEDALS. THE ADJUSTABLE BRAKE PEDAL ARM MAY LOOSEN ALLOWING THE ARM TO ROTATE AROUND ITS SHAFT AND SWING IN FRONT OF THE ACCELERATOR PEDAL, REDUCING BRAKING FUNCTION.

Consequence: A LOOSE BRAKE PEDAL INCREASES THE RISK OF A CRASH.

Remedy: WINNEBAGO IS WORKING WITH FREIGHTLINER TO NOTIFY OWNERS. REPAIRS WILL BE CONDUCTED BY FREIGHTLINER FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING FEBRUARY 2010. OWNERS MAY CONTACT DAIMLER TRUCKS WARRANTY CAMPAIGNS DEPARTMENT AT 1-800-647-0712.