2005 Winnebago VECTRA: complaints, problems and recalls

I PURCHASED A 2005 WINNEBAGO ADVENTURER 37 B TWO MONTHS AGO AND PROCEDED TO TAKE IT ON A LONG VACATION. THE KNOWINGLY DEFECTIVE VEHICLE FAILED ON OVER 200 OCCASIONS AND WAS DIAGNOSED AND REPAIRED OVER 10 TIMES BY FACTORY AND NON FACTORY AUTHORIZED SERVICECENTERS. ULTIMATELY AFTER CONSTANTLY JEOPARDIZING MY WIFE AND PARTNER'S LIFE IN MANY INSTANCES AND AFTER BEING STRANDED AND TOWED ON MULTIPLE OCCASSIONS WINNEBAGO DETERMINED THAT THE PROBLEM WAS IN THE WIRING HARNESSES THAT HAD BEEN IMPROPERLY ROUTED AND WHICH HAD BEEN MELTING AND SHORTING OUT …

Owner-reported narrative. 3,200 miles reported. Look up ODI 10100737 at NHTSA ↗

OWNER HAS A MOTOR HOME AND THE VEHICLE SHAKES VIOLENTLY WHEN TURNING LEFT/RIGHT. OWNER TOOK THE VEHICLE TO FREIGHTLINER OF UTAH AND CHECKED THE ALIGNMENT WHICH WAS FINE. HOWEVER, THE SHAKING OF THE STEERING WHEEL IS STILL IN EXISTENCE. *AK

Owner-reported narrative. 1,409 miles reported. Look up ODI 10113393 at NHTSA ↗

2005 WINNEBAGO VECTRA & FREIGHTLINER CHASSIS DEFECTS: VEHICLE TOTAL LOSS OF STEERING CONTROL @ 65 MPH AGAINST LOW ANGLE FRONT QUARTER CROSS WINDS. A SUDDEN FRONTAL 30-35 MPH GUST OF WIND @ A 10-15 DEGREE ANGLE OF INCIDENCE CREATES A MOMENTARY AIRSPEED OF 95-100 MPH. THE 440 SQ FT BROAD SURFACE AREA OF THE CHASSIS HAS 250% THE AUTHORITY OF AN 767 RUDDER THAT ALSO HAS A VERY EFFICIENT WING ASPECT RATIO. THIS 32,000 LB RV IS SUBJECT (BY NASA ANALYSIS) TO 10,000- 20,000 LB OF LATERAL FORCE UNDER THESE CONDITIONS, DESTABILIZING THE CHASSIS / CO…

Owner-reported narrative. 2,500 miles reported. Look up ODI 10244967 at NHTSA ↗

THE SEALS OF THE DUAL PANE WINDOWS OF THE MOTORHOME LEAK AND THE WINDOWS HAVE BECOME CLOUDY. THIS CONDITION IS LIMITING VISIBILITY TO THE REVIEW MIRRORS. I HAVE CONTACTED WINNEBAGO AND THERE RESPONSE WAS THE COACH IS OUT OF WARRANTY. THE COST TO REPLACE THE THREE WINDOWS IS OVER 2,000. THE MOTORHOME HAS BEEN IN INDOOR STORAGE WHEN NOT USED. THIS SHOULD BE A RECALL ISSUE SINCE THE REDUCED VISIBIILTY COULD CAUSE SERIOUS ACCIDENTS. THE WINDOW MANUFACTURER SHOULD BE HELD RESPONSIBLE TO CORRECT THIS PROBLEM AT THEIR EXPENSE, NOT THE CONSUMER.

Owner-reported narrative. 29,855 miles reported. Look up ODI 10390808 at NHTSA ↗

THIS REPORT IS ON A FAILED ODOMETER. AT AROUND 53100 MILES THE ODOMETER SET TO ZERO AND STARTED COUNTING FORWARD AGAIN. I BROUGHT THE COACH TO A FREIGHTLINER DEALER IN DALLAS, TX. WHEN THE COACH WAS RECEIVED I WAS INFORMED THAT THE ODOMETER COULD NOT BE CALIBRATED TO THE CORRECT AND KNOWN MILEAGE INDICATED BY ANOTHER ENGINE MONITORING COMPUTER. THE ACTUAL MILEAGE ON THE COACH AT THE TIME OF THE REPAIR WAS 53913. WHILE WAITING FOR THE REPAIRS TO BE COMPLETED I FOUND ANOTHER COACH THROUGH THE INTERNET IN FL THAT I WANTED TO TRADE MY COACH …

Owner-reported narrative. 53,100 miles reported. Look up ODI 10511194 at NHTSA ↗

Reported: 2004-09-27 (September 27, 2004)

ON CERTAIN MOTOR HOMES BUILT ON A FREIGHTLINER CHASSIS WITH A 400-HP CUMMINS ENGINE, A SHEET METAL "TAB" ON A WIRE COVER LOCATED BEHIND THE ACCELERATOR PEDAL HAS THE POTENTIAL TO CATCH ON THE ACCELERATOR PEDAL.

Consequence: IF THE ACCELERATOR PEDAL HANGS UP ON THE TAB OF THE WIRE COVER, A HAZARDOUS SITUATION COULD RESULT IN THE PEDAL NOT GOING BACK TO IDLE POSITION, INCREASING THE RISK OF PERSONAL INJURY, VEHICLE DAMAGE AND, A CRASH COULD OCCUR.

Remedy: DEALERS WILL PROVIDE INSTRUCTIONS FOR OWNERS TO INSPECT AND IF NECESSARY HAVE THE WIRE COVER REPAIRED. IF OWNERS DO NOT FEEL COMFORTABLE PERFORMING THE INSPECTION, DEALERS WILL INSPECT AND REPAIR AS NECESSARY. THE RECALL BEGAN ON SEPTEMBER 17, 2004. OWNERS SHOULD CONTACT WINNEBAGO AT 641-585-6939.

Reported: 2004-12-18 (December 18, 2004)

CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Consequence: THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

Remedy: DEALERS WILL REPLACE THE BUCKLES. THE RECALL BEGAN ON NOVEMBER 12, 2004. OWNERS SHOULD CONTACT AMSAFE AT 1-574-266-8330 OR WINNEBAGO AT 1-800-537-1885.

Reported: 2010-10-26 (October 26, 2010)

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.