White Gmc WG recalls by model year

Reported: 1998-10-14 (October 14, 1998) · Model years: 1986, 1987, 1988, 1989, 1990, 1991, 1992, 1993, 1994, 1995, 1996, 1997, 1998

VEHICLE DESCRIPTION: CLASS 8 HEAVY DUTY TRUCKS. THE AIR SUSPENSION CONTROL VALVE SUPPLY LINE WAS NOT PLUMBED THROUGH AN AIR PRESSURE PROTECTION VALVE. IN THE EVENT OF A FAILURE, THERE WOULD BE LOSS OF AIR PRESSURE IN THE 'B' SYSTEM AIR RESERVOIR THAT SUPPLIES AIR PRESSURE FOR THE FRONT STEER AXLE BRAKES.

Consequence: THIS CONDITION WOULD RESULT IN INCREASED STOPPING DISTANCES.

Remedy: DEALERS WILL INSTALL THE NECESSARY AIR PRESSURE PROTECTION VALVE.

Reported: 1989-06-09 (June 9, 1989) · Model years: 1989

THE LABEL ON THE HAND THROTTLE WAS OMITTED.

Consequence: TRUCKS WOULD NOT COMPLY WITH FMVSS 101.

Remedy: LABEL AND INSTALLATION INSTRUCTIONS WILL BE SENT TO OWNERS.

Reported: 1994-02-23 (February 23, 1994) · Model years: 1993, 1994

THE BRACKETS THAT ATTACH THE STEERING COLUMN ASSEMBLY TO THE CAB STRUCTURE CRACKS AT THE "V" NOTCH IN THE BRACKET.

Consequence: FAILURE OF THE BRACKET MAY CAUSE THE STEERING COLUMN ASSEMBLY TO FALL, WHICH MAY RESULT IN LOSS OF STEERING CONTROL AND AN ACCIDENT.

Remedy: VOLVO GM WILL REPLACE THE SUSPECT BRACKETS WITH A NEWLY DESIGNED BRACKET.

Reported: 1994-12-01 (December 1, 1994) · Model years: 1993, 1994

THE MAIN ELECTRICAL POWER HARNESS WAS MISROUTED. IF THERE WAS AN ELECTRICAL SHORT IN THIS HARNESS, THE CIRCUIT WOULD NOT BE FUSE-PROTECTED.

Consequence: A SHORT IN A MISROUTED POWER HARNESS CAN CREATE A POTENTIAL FOR A VEHICLE FIRE.

Remedy: DEALERS WILL REROUTE THE SUBJECT POWER HARNESS AND RECONNECT THE AFFECTED WIRES TO THE CORRECT FUSE-PROTECTED POWER JUNCTION.

Reported: 1995-11-13 (November 13, 1995) · Model years: 1994, 1995

UNDERCOATING APPLIED TO THE INSIDE OF THE CAB SHELL SQUEEZED OUT DURING ASSEMBLY ONTO THE BRAKE PEDAL PLUNGER.

Consequence: UNDERCOATING ON THE PLUNGER MAY CAUSE THE PLUNGER TO STICK RESULTING IN INCREASED BRAKE PEDAL EFFORT AND/OR SLOW RELEASE OF THE BRAKES INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.

Remedy: DEALERS WILL CLEAN THE UNDERCOATING FROM THE BRAKE PEDAL PLUNGER ASSEMBLY, LUBRICATE AND REINSTALL THE BRAKE PEDAL PLUNGER ASSEMBLY.

Reported: 1996-03-23 (March 23, 1996) · Model years: 1994, 1995, 1996

THE TRACTION SOLENOID EXHAUST CAN BE OBSTRUCTED DUE TO INADEQUATE DRAINAGE AND A BUILD-UP OF ROAD CONTAMINATION BETWEEN THE MOUNTING BRACKET AND THE SOLENOID HOUSING. THE OBSTRUCTED EXHAUST PREVENTS THE RELAY VALVE CONTROL AIR PRESSURE FROM VENTING AFTER A DIFFERENTIAL BRAKING TRACTION EVENT.

Consequence: THIS CONDITION WOULD KEEP THE REAR AXLE SERVICE BRAKES APPLIED WITHOUT ANY BRAKE PEDAL MOVEMENT BY THE DRIVER INCREASING THE RISK OF A VEHICLE ACCIDENT.

Remedy: DEALERS WILL REMOVE THE SUSPECT VALVE AND INSTALL A NEW VALVE THAT HAS A MODIFIED SOLENOID HOUSING WHICH WILL ALLOW FOR SUFFICIENT DRAINAGE AND A NEW VALVE MOUNTING BRACKET WITH INCREASED HEIGHT TO REDUCE ENTRY OF CONTAMINATION.

Reported: 1995-06-07 (June 7, 1995) · Model years: 1995

TWO BOLTS ATTACHING THE UPPER STEERING ARM TO THE FRONT STEERING AXLE WERE NOT TIGHTENED PROPERLY.

Consequence: THE BOLTS COULD LOOSEN INCREASING THE POTENTIAL FOR LOSS OF STEERING CONTROL AND AN ACCIDENT.

Remedy: DEALERS WILL INSTALL NEW BOLTS AND TIGHTEN TO PROPER TORQUE SPECIFICATION.

Reported: 1996-02-12 (February 12, 1996) · Model years: 1995

THE REAR SUSPENSION AXLE RETENTION PLATE CAN BREAK UNDER NORMAL USE, AFFECTING AXLE ALIGNMENT.

Consequence: THIS CONDITION COULD RESULT IN LOSS OF REAR AXLE STABILITY AFFECTING VEHICLE DIRECTIONAL CONTROL AND INCREASING THE POTENTIAL FOR A VEHICLE CRASH.

Remedy: DEALERS WILL REMOVE AND REPLACE THE AXLE RETENTION CLIP PLATES ON AFFECTED VEHICLES.