Volvo XC40 electrical problems
24 complaint narratives mention electrical terms.
Key facts
212 owner complaints analyzed
13 distinct recall campaigns
5,000 mi median reported failure mileage
Scope: 2017 to 2025 model years. Data snapshot: . 41 complaints include usable failure mileage.
Electrical and battery issues evidence
24 of 212 complaints match this topic (11.3%). The keyword filter can include complaints that mention a transmission without reporting its failure. View matching rules.
Owner report 11509510 · 2023-02-28 (February 28, 2023)
The first incident happened back in Oct 2022. I took the car to local Volvo dealer, Rusnak Pasadena, and they said I needed the secondary battery replaced. They replaced it and the car worked for a few weeks until the alarm regarding the power steering failure came on again while my wife was turning left. I brought the car home carefully since it was a short distance from home. My wife was very scared because she almost had an accident and she doesn’t want to drive it any more….We didn’t drive the car for more than a month. On Jan 5, 202…
Owner-reported narrative. Look up ODI 11509510 at NHTSA ↗
Owner report 11481319 · 2022-08-26 (August 26, 2022)
The electrical system on my car apparently failed, which rendered the car unable to start and drive. Park Place Volvo claims that there is water, that penetrated the seals, from underneath the car. Although there were no visible signs of water, Volvo claims that the rain caused this issue. Volvo has refused to honor a warranty for the alleged defective seals, and sent my car to its collision center.
Owner-reported narrative. Look up ODI 11481319 at NHTSA ↗
Owner report 11513931 · 2023-03-27 (March 27, 2023)
The contact owns a 2020 Volvo XC40. The contact stated that while his wife was driving at an undisclosed speed, the speedometer and the infotainment system screen turned blank. The vehicle then lost motive power. The electronic stability program (ESP) warning light was illuminated. The contact's wife veered to the side of the road, and the contact arrived at the scene. The vehicle was able to be restarted. The vehicle was taken to the dealer, where it was diagnosed that the failure was related to the software control module and SRS air bags mal…
Owner-reported narrative. 30,453 miles reported. Look up ODI 11513931 at NHTSA ↗
Owner report 11581906 · 2024-04-09 (April 9, 2024)
During night rainstorm, front and rear wipers, turn signals and high beams all failed. This was the result of a design defect that allows water from panoramic moonroof to drain into the floor where it compromises electrical connections and modules. In addition to potentially catastrophic safety component (wipers, high beams and turn signals) failures, the water damage compromised the seat belts, as well, which also required repairs. Insurance adjuster confided that this is a frequent, common problem. Repairs took 10 days and cost $8700! Bo…
Owner-reported narrative. Look up ODI 11581906 at NHTSA ↗
Owner report 11757999 · 2026-08-19 (August 19, 2026)
The cooling system cracked, malfunctioned and caused a domino effect of multiple repair issues costing at least $5,200. My car is currently at a Volvo dealer. My Safety: The possibility of the hot engine and hot wires could have resulted in a fire. This problem HAS been reproduced and confirmed by a Volvo dealer. The vehicle overheating was witnessed by the Fire Department and local police.. As far as sufficient Warning Lights or dashboard indications, the ONLY messages I received were 1} About 5 p.m. EST Battery indicator (at which point I pul…
Owner-reported narrative. Look up ODI 11757999 at NHTSA ↗