2022 Winnebago TRAVATO: complaints, problems and recalls

My safety complaint is for a 2022 Winnebago Travato RV which has a Ram Pro Master Chassis with solar panels on roof. It has two solar panels that are 12" X 18" and 36" X 36" mounted about 4 to 6 inches horizontal above the roof line. The problem is that at higher speeds the flow of wind makes a very strong Turbulence and causes the RV to shutter and vibrate and very hard to control. If a gust of wind comes and you are not ready you could loose control of the RV and crash. Winnebago is aware of this issue since 2020 and has not done any thing ab…

Owner-reported narrative. Look up ODI 11444335 at NHTSA ↗

The contact owns a 2022 Winnebago Travato built on a 2019 Ram Promaster 3500 chassis. The contact stated that while driving approximately 50 MPH, the retractable awning erroneously deployed and struck a light pole, causing the awning to partially detach from the RV. The contact stated that several of the awning poles were bent and damaged after striking the light pole. The cause of the failure was not yet determined. The manufacturer and local dealer were not yet notified of the failure. The failure mileage was 71,000.

Owner-reported narrative. 71,000 miles reported. Look up ODI 11499862 at NHTSA ↗

The contact owns a 2022 Winnebago Travato built on a 2021 Ram Promaster 3500 chassis. The contact received notifications of NHTSA Campaign Number: 23V049000 (Equipment) and 22V696000 (Structure, Equipment); however, the parts to do the recall repairs were not yet available. The local dealer was contacted on multiple occasions but the contact nor his wife received a response. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not e…

Owner-reported narrative. Look up ODI 11534322 at NHTSA ↗

Upon leaving our campground on the morning of 11/30/2023 we were driving out on paved campground exit road at about 10MPH when Carefree awning on our 2022 Winnebago Travato suddenly and without warning fully extended in an uncontrolled fashion. We pulled over immediately and determined how to manually retract the awning with a socket wrench. Upon manually retracting the awning it was still not secured and reeled completely out again. We repeated the manual retraction and this time secured the awning by tying nylon straps around both ends of …

Owner-reported narrative. Look up ODI 11558366 at NHTSA ↗

This is a 2022 Winnebago Travato with the same problem as reported in #11571902. Electrical cables are routed in the inside of the left front wheel well where they can be rubbed by tires.

Owner-reported narrative. Look up ODI 11572386 at NHTSA ↗

This is a 2022 Winnebago Travato 59G on the 2021 Ram Promaster. We have already done the two recalls on the Carefree Awning at Meridian ID Camping World, most recent in May 2024. #22V-696, 23V-627. The van has been driven in town a few times since the most recent recall fix with no incident. Now the awning noisily deployed when the ignition was turned ON. I turned the engine off, awning stopped about 75% out. We were luckily NOT parked next to anything that could have been damaged and were not away from home. Awning cannot be extended or retra…

Owner-reported narrative. Look up ODI 11607834 at NHTSA ↗

May 24,2025 as we were driving, the awning completely deployed out causing us to quickly drive on a safer lane to the side to avoid any risk to other drivers. This is definitely a safety risk for travel that can put ourselves and others at harm or crash collision. There were no prior warning whatsoever on our dash board or driver console at all during this incident.

Owner-reported narrative. Look up ODI 11663128 at NHTSA ↗

The 59G travato bedframe (zomi) weld broke while laying on the bed resulting in us falling off the bed. Could of been much worse. Others in Facebook groups and forums have had the same issue with beds breaking at the same weld which is at the end of the bed. Contacted Winnebago and they said nothing they can do. Case:00432260

Owner-reported narrative. Look up ODI 11692088 at NHTSA ↗

Reported: 2021-06-25 (June 25, 2021)

Winnebago Industries, Inc. (Winnebago) is recalling certain 2021-2022 Solis, Travato, and Ekko vehicles, equipped with GE-ES Double Flipseats. The seat belt retractors may lock up when the vehicle is on a slight incline. As such, these seats fail to comply with the requirements of Federal Motor Vehicle Safety Standards numbers 208, "Occupant Crash Protection" and 209, "Seat Belt Assemblies."

Consequence: If the seat belt retractor locks, a passenger may believe they are trapped in the vehicle, increasing the risk of injury.

Remedy: Winnebago will work with Freedman to notify owners, and dealers will inspect the seat and repair, free of charge. Owner notification letters were mailed on July 23, 2021. Owners may contact Winnebago customer service at 1-614-585-6939 or 1-800-537-1885 or Freedman customer service at 1-800-443-4540.

Reported: 2021-10-12 (October 12, 2021)

Winnebago Industries, Inc. (Winnebago) is recalling certain 2019-2022 Travato and 2021-2022 Boldt vehicles. The wire harness may have been built incorrectly, resulting in the loss of over-current protection.

Consequence: Loss of over-current protection can cause the wires to overheat, increasing the risk of a fire.

Remedy: Owners are instructed to not drive their vehicle until the Volta Power System is disabled. Dealers will replace the harness and inspect the electrical connection, free of charge. Owner notification letters were mailed October 26, 2021. Owners may contact Winnebago customer service at 1-641-585-6939 or 1-800-537-1885. Winnebago's number for this recall is 164.

Reported: 2022-09-16 (September 16, 2022)

Winnebago Industries, Inc. (Winnebago) is recalling certain 2019-2023 Winnebago Travato motorhomes. The retractable awning may extend unintentionally during transit.

Consequence: An awning that extends during transit, may become a distraction or road hazard, increasing the risk of a crash.

Remedy: Dealers will install an on/off switch for the extend/retract awning function, and update firmware, free of charge. Owners notification letters were mailed October 19, 2022. Owners may contact Winnebago customer service at 1-641-585-6939 or 1-800-537-1885. This recall is superseded by Winnebago recall 23V627.

Reported: 2023-02-03 (February 3, 2023)

Winnebago Industries, Inc. (Winnebago) is recalling certain 2020-2023 Solis, 2021-2023 Travato, and 2022-2023 Ekko motorhomes, equipped with certain Suburban Manufacturing Company (Suburban) SDS2 2-Burner Drop-in Cooktops with part number 3032AST. The internal aluminum burner tubes that connect to the gas valves may fracture and cause a gas leak.

Consequence: A gas leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Winnebago will work with Suburban to repair the cooktop, free of charge. Owner notification letters were mailed March 31, 2023. Owners may contact Winnebago customer service at 1-641-585-6939 or 1-800-537-1885.

Reported: 2023-04-28 (April 28, 2023)

Winnebago Industries, Inc. (Winnebago) is recalling certain 2020-2023 Travato, 2021-2023 Solis, and 2022-2023 Ekko motorhomes, equipped with certain Cummins Onan QG 2800i, and Onan QG 2800i EVAP generator sets. The fuel hose between the fuel filter and Injection Pump Module (IPM) may not be properly secured, which can cause a gas leak.

Consequence: A gas leak in the presence of an ignition source increases the risk of a fire.

Remedy: Dealers will inspect and replace the fuel hose and clamps, as necessary, free of charge. Owner notification letters are expected to be mailed June 2, 2023. Owners may contact Winnebago customer service at 1-641-585-6939 or 1-800-537-1885.

Reported: 2023-09-08 (September 8, 2023)

Winnebago Industries, Inc. (Winnebago) is recalling certain 2017-2024 Travato motorhomes. The retractable awning may extend unintentionally during transit.

Consequence: An awning that extends during transit may become a distraction or road hazard, increasing the risk of a crash.

Remedy: Dealers will install a parking brake interlock module, and update the awning firmware, free of charge. Owner notification letters were mailed April 4, 2024. Owners may contact Winnebago customer service at 1-574-585-6939 or 1-800-537-1885. Winnebago's number for this recall is 176. This recall replaces and expands NHTSA Recall 22V-696. Motorhomes previously repaired under 22V-696 will need to have the new remedy completed.