2001 Volkswagen PASSAT: complaints, problems and recalls

FAILURE OF IGNITION COIL PACK. VERY ROUGH IDLE, LOSS OF POWER, STALLING. CAR IS AT DEALERSHIP OVER 2 WEEKS STILL AWAITING PARTS TO REPAIR. NO DEFINITIVE TIME SCHEDULE GIVEN BY DEALER OR VW OF AMERICA AS TO WHEN PARTS WILL BECOME AVAILABLE AND REPAIR CAN BE MADE.

Owner-reported narrative. 18,500 miles reported. Look up ODI 10000199 at NHTSA ↗

RE COIL PACKS. VW HAS SUPPLIED THE CARS WITH DEFECTIVE COIL PACKS THAT CAN FAIL WITHOUT WARNIHG AT ANY TIME.I HAD ONE FAILED AT 18000 MILES. THE OTHER THREE CAN FAIL AT ANY TIME. CAN'T TAKE THE CAR ON LONG TRIPS WITHOUT TAKING A CHANCE OF A COIL PACK FAILURE.DON'T KNOW WHAT WOULD HAPPEN AT HIGHWAY SPEEDS IF THERE WAS A FAILURE. VW NEEDS TO RECALL THE CARS AND REPLACE THESE DEFECTIVE PARTS. AND IF YOU ARE UNLUCKY ENOUGH TO HAVE A FAILURE YOU CAN WAIT FOR PARTS FOR MONTHS AND IN TURN NOT HAVE ANYTHING TO DRIVE.

Owner-reported narrative. 18,000 miles reported. Look up ODI 10000223 at NHTSA ↗

MY 2001 VW PASSAT GLS WAS HIT IN THE REAR BY A LARGE 89 CHEVY VAN. THE SEAT THAT I WAS SITTING IN RECLINED ALMOST ALL THE WAY BACK TO THE BACK SEAT SO THAT I WAS LOOKING UP AT THE ROOF. MY SEAT BELT CUT MY HEAD AND WRIST OF MY LEFT ARM AS I FELL BACK. I KNOW IT WAS THE SEAT BELT BECAUSE THERE WAS SKIN ON THE SHOULDER PORTION OF IT. AFTER THE ACCIDENT I LOOKED AT THE TOTALLED CAR AND NOTICED THAT THE SEAT HAD SHIFTED. THE FRONT THIGH SUPPORT PORTION CAME UP, AND THE BACK SUPPORT WENT DOWN. UPON CLOSE INSPECTION, I THINK THAT THE SEAT BRACK…

Owner-reported narrative. 46,000 miles reported. Look up ODI 10000255 at NHTSA ↗

WHILE DIVING THE VEHICLE AT 45MPH SUDDENLY LOSS POWER DUE TO A FAULTY COIL DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS

Owner-reported narrative. Look up ODI 10001351 at NHTSA ↗

CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE VEHICLES COIL PACKS. ALSO STATED THAT THIS IS THE FOURTH TIME THAT THEY HAVE BEEN REPLACED. DEALER WAS CONTACTED AND HAS KNOWLEDGE OF THE PROBLEM. DEALER HAS STATED THAT IT IS A COMMON PROBLEM. PH *DT

Owner-reported narrative. 5,000 miles reported. Look up ODI 10002129 at NHTSA ↗

ONE OF THE FOUR COILPACKS ON MY 1.8T ENGINE HAS FAILED. IT HAS BEEN BROUGHT TO MY ATTENTION THAT THIS IS A VERY COMMON PROBLEM. I WAS TOLD THAT VW HAS REDESIGNED THE PART. VW WILL ONLY REPLACE THE PART THAT FAILED. ONCE THE PART FAILS THE CAR IS NOT DRIVABLE. VW SHOULD RECALL ALL OF THE PASSATS WITH THIS ENGINE AND REPLACE THE FAULTY PARTS.

Owner-reported narrative. 21,000 miles reported. Look up ODI 10002765 at NHTSA ↗

MULTIPLE PROBLEMS WITH THE 2001 VW PASSAT. PROBLEMS BEGAN AT 16000 MILES AND HAVE CONTINUED UP TO THE CURRENT DATE AND MILEAGE OF 33000 MILES. CAR HAS BEEN SEEN IN VW SERVICE DEPARTMENT 11 TIMES SINCE NOVEMBER 2001. LAWSUIT HAS BEEN FILED AGAINST VW AMERICA.

Owner-reported narrative. 16,000 miles reported. Look up ODI 10003026 at NHTSA ↗

I HAVE VW PASSAT, 2001. IT HAS AROUND 30 000 MILES ON IT. THE CLUTCH HAS GONE DOWN ON THIS CAR AND IT NEEDS TO BE REPLACED. PARTS AND LABOR FOR THIS REPAIR ARE MORE THAN $2200. THIS CAR HAS ELECTRICAL PROBLEMS ALSO. THE WARRANTY IS GONE AFTER 24000K OR 2 YEARS. I HAVE EXTENDED WARRANTY ON THIS CAR, BUT THEY DON'T COVER ANYTHING FROM THE LONG LIST OF REPAIR. I CALLED TO VW CUSTOMER CARE AND ASK TO REIMBURSE ME FOR CLUTCH REPAIR, SINCE IT MUST BE AFTER 10 YEARS/100 000 MILES POWER TRAIN WARRANTY. THEY REFUSED TO PARTICIPATE. I COMPLA…

Owner-reported narrative. 30,000 miles reported. Look up ODI 10003183 at NHTSA ↗

Reported: 2001-05-03 (May 3, 2001)

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SULFUR IN FUEL INTERACTS WITH CERTAIN ADDITIVES FOUND IN WIDELY AVAILABLE GASOLINE CAUSING SULFUR TO BECOME DEPOSITED ON THE CONTACT POINTS OF THREE FUEL SENDING UNITS MOUNTED INSIDE THE FUEL TANK. THIS COULD CAUSE THE FUEL GAUGE TO READ FULL WHILE THE FUEL TANK MAY NOT IN FACT BE FULL OR COULD BE EMPTY.

Consequence: RUNNING OUT OF FUEL WITHOUT WARNING WHILE THE FUEL GAUGE INDICATES THAT THERE IS SUFFICIENT FUEL IN THE TANK LEAD TO SAFETY PROBLEMS.

Remedy: DEALERS WILL REMOVE THE EXISTING FUEL LEVEL SENDING UNITS AND REPLACE THEM WITH FUEL LEVEL SENDING UNITS USING A NEW ALLOY COMPOSED OF GOLD, SILVER, AND A SMALL AMOUNT OF NICKEL, WHICH WILL NOT CHEMICALLY REACT WITH SULFUR. VW/AUDI WILL ALSO CALL BACK VEHICLES THAT WERE REPAIRED UNDER A PREVIOUS RECALL LAST JUNE IN ORDER TO INSTALL THE UPDATED FUEL SENDING UNITS NHTSA 00V137/AUDI LB). OWNER NOTIFICATION BEGAN MAY 1, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUDI AT 1-866-892-2834.

Reported: 2002-01-25 (January 25, 2002)

ON SOME PASSENGER VEHICLES, THE FUEL TANK FILLER NECK CAN SUFFER ABRASION DAMAGE IF THE REAR TIRE GOES FLAT AND THE VEHICLE IS DRIVEN UNTIL THE TIRE DISINTEGRATES.

Consequence: FUEL LEAKAGE CAN OCCUR INCREASING THE RISK OF A FIRE.

Remedy: DEALERS WILL FIT PASSAT VEHICLES WITH A NEW WHEEL HOUSE LINER THAT WILL BETTER PROTECT THE CAR'S FILLER NECK. JETTA VEHICLES WILL BE FITTED WITH A DIFFERENT METAL SHIELD DESIGNED TO ENHANCE ABRASION PROTECTION IN THE EVENT OF TIRE DISINTEGRATION. OWNER NOTIFICATION BEGAN JUNE 13, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.

Reported: 2008-04-07 (April 7, 2008)

VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.

Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.

Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.