2006 Volkswagen BEETLE: complaints, problems and recalls

DT*: THE CONTACT STATED WHILE ATTEMPTING TO APPLY BRAKE PRESSURE AT ALL SPEEDS, THE BRAKES WENT TO THE FLOOR AND WOULD NOT RETURN TO THE NORMAL UP POSITION. THE DRIVER HAD TO PULL UP ON THE BRAKE PEDAL TO APPLY BRAKE PRESSURE. ALSO, THE TRANSMISSION FAILS TO MAINTAIN ENGAGED WHEN INCLINED. ALTHOUGH THE DEALER WAS ALERTED NO INSPECTIONS HAVE BEEN MADE.

Owner-reported narrative. 8,800 miles reported. Look up ODI 10156154 at NHTSA ↗

A/C COMPRESSOR OR FAN MOTOR HOWLS VERY LOUDLY. TAKEN TO DEALER AND DEALER STATED AT FIRST THAT THEY COULD NOT DUPLICATE PROBLEM . INSISTED THEY LISTEN AGAIN SINCE SERVICE WRITER COULD HEAR NOISE WHEN WE DROVE IN. THEN STATED THAT CAR HAD TOO MUCH FREON IN UNIT AND THAT PROBLEM WAS FIXED. DROVE OUT OF LOT AND HOWLING WAS AS LOUD AS EVER. AFRAID COMPRESSOR OR FAN WILL BLOW OUT OF HOOD OF CAR. THE LONGER THE CAR IS DRIVEN THE LOUDER THE HOWL BECOMES. *JB

Owner-reported narrative. 4,000 miles reported. Look up ODI 10158450 at NHTSA ↗

ENGINE MAKES LOUD HUMMING NOISE WHEN A/C IS TURNED ON. *NM

Owner-reported narrative. 95 miles reported. Look up ODI 10158987 at NHTSA ↗

DUAL MASS FLYWHEEL BLEW APART AT 2200 MILES THEN AT 7,800 MILES ON A 2006 BEETLE TDI. I AM NOW ON BOTH TIMES HAPPENED DOWN SHIFTING FROM 5TH TO 4TH GEAR. HAVE DRIVEN MANUAL SHIFTS ALL MY LIFE NEVER HAD THIS HAPPEN. WAS TOLD BY DEALER THAT DMF HAS A HARD TIME HANDLING TORQUE. I WAS STILL LESS THAN 3000 RPM WHEN DROPPING INTO 4TH GEAR WHEN THE FLYWHEEL BROKE. THIS SHOULD NEVER HAPPEN AS IT SHOULD BE ABLE TO HANDLE THIS AMOUNT OF TORQUE AS A STANDARD OPERATING PROCEDURE. LUCKILY I WAS ABLE TO PULL OFF TO THE SIDE OF THE ROAD AS ALL MY TRANSMI…

Owner-reported narrative. 2,200 miles reported. Look up ODI 10161787 at NHTSA ↗

2006 VW BEETLE WITH 10,200 MILES...REAR ENGINE MOUNT FALLING APART. TRANS ENGINE MOUNT..BROKEN BOLTS. *JB

Owner-reported narrative. 10,200 miles reported. Look up ODI 10163820 at NHTSA ↗

MY 2006 BEETLE CONVERTIBLE CONTINUES TO HOWL WITH THE A/C FAN MOTOR ON. IT ACTUALLY SOUNDS LIKE A JET MOTOR TRYING TO LAND. THE DEALERSHIP SAYS THEY ARE AWARE OF THE PROBLEM AND THEY HAVE HAD 3 OTHERS COME IN WITH THE SAME COMPLAINT. IN FACT THEY SAID THEY REPLACED ONE CUSTOMERS CAR FAN AND IT WAS EVEN LOUDER THAN BEFORE. THEY CANNOT TELL ME WHEN THEY WILL HAVE A SOLUTION BUT VW IS "WORKING ON IT". I HAVE 9000 MILES ON MY CAR. I LIVE IN TEXAS. DOES THIS QUALIFY FOR THE LEMON LAW? THIS IS NOW OCT AND NO OTHER ATTEMPTS HAVE BEEN MADE TO REPA…

Owner-reported narrative. Look up ODI 10169746 at NHTSA ↗

DT*: THE CONTACT STATED THE VEHICLE ACCELERATED ON ITS OWN CAUSING AN ACCIDENT. AN ATTEMPT WAS MADE TO STOP THE VEHICLE BY DEPRESSING THE BRAKES BUT VEHICLE WOULD NOT RESPOND. THE VEHICLE RAN OVER TWO SPEED BUMPS AT 25 MPH THEN JUMPED A CURB AND CRASHED INTO AN APARTMENT BUILDING. A POLICE REPORT WAS FILED. UPDATED 10/25/2006 - A WITNESS STATED THAT THE BRAKE LIGHT WERE ULLIMINATED AND THAT HE HEARD A REVVING NOISE COMING FROM THE VEHICLE. *NM

Owner-reported narrative. 2,300 miles reported. Look up ODI 10170427 at NHTSA ↗

CHECK ENGINE LIGHT CAME ON. TOOK IN FOR SERVICE. MUST BE AN OXYGEN SENSOR THEY SAY. THEY ORDER ONE AND I GO BACK. NOT THE SENSOR. ENGINE COOLANT LEAKED ON WIRING HARNESS CAUSING WIRING DAMAGE. THEY REPLACE HARNESS HOWEVER DO NOT KNOW WHERE COOLANT IS COMING FROM. *NM

Owner-reported narrative. 4,700 miles reported. Look up ODI 10171549 at NHTSA ↗

Reported: 2006-02-09 (February 9, 2006)

CERTAIN PASSENGER VEHICLES EQUIPPED WITH 17-INCH WHEELS AND A 2.5L ENGINE FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE PRODUCED WITH A TIRE INFORMATION LABEL THAT LISTS AN INCORRECT FRONT TIRE SIZE. THE CORRECT FRONT TIRE SIZE SHOULD BE LISTED AS 225/45 R17. THE INFLATION PRESSURE IS CORRECT.

Consequence: A MISPRINTED LABEL COULD LEAD TO FITMENT OF IMPROPERLY SIZED REPLACEMENT TIRES.

Remedy: OWNERS WILL BE PROVIDED WITH A NEW TIRE INFORMATION LABEL AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 27, 2006. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.

Reported: 2007-02-20 (February 20, 2007)

ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.

Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.

Reported: 2010-12-10 (December 10, 2010)

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.