2005 Toyota SEQUOIA: complaints, problems and recalls

EXTREMELY HIGH IDLE SPEED FROM A COLD START (1500-1700 RPM) LEADS TO WHEEL SPIN AND LOSS OF CONTROL ON ICY/SNOWY SURFACES. I TURNED SIDEWAYS IN MY DRIVEWAY THIS MORNING WHILE BACKING OUT OF MY GARAGE. REAR WHEELS ARE SPINNING WHILE THE BRAKES ARE HOLDING THE FRONT WHEELS. I HAVE A BUSINESS PARTNER WHO ALSO HAS A 2005 SEQUOIA THAT BEHAVES IDENTICALLY. HE SLID OFF HIS DRIVEWAY INTO A LANDSCAPE BED, SUFFERING MINOR BODY DAMAGE. THE COLD START IDLE SPEED IS EXCESSIVE AND DANGEROUS. *AK

Owner-reported narrative. Look up ODI 10106120 at NHTSA ↗

I HAD OWNED A 2001 TOYOTA SEQUOIA FOR FOUR YEARS BEFORE RECENTLY TRADING IT IN FOR A 2005 MODEL. I OBVIOUSLY LOVE THE CAR BUT THERE IS AN UNFORTUNATE FLAW IN THE 2005 MODEL THAT DIFFERS FROM MY 2001 MODEL. WHEN THE VEHICLE IS STARTED COLD THE IDLE SPEED IS VERY HIGH - ABOUT 1500+ RPM. THE IDLE DOESN'T SLOW DOWN APPRECIABLY UNTIL THE CAR HAS WARMED UP - ABOUT 5 MINUTES DEPENDING ON THE WEATHER. THE PROBLEM WITH THE HIGH IDLE COMES WHEN TRYING TO DRIVE THE CAR ON AN ICY SURFACE. I CAME OUT OF MY GARAGE ON AN ICY MORNING, PUT THE CAR INTO FOR…

Owner-reported narrative. 600 miles reported. Look up ODI 10106462 at NHTSA ↗

UPON ACCELERATION VEHICLE CABIN FILLS WITH A SULFUR (ROTTEN EGG) SMELL. DEALERSHIP STATES THEY CANNOT DUPLICATE. UPON PICKUP THE VEHICLE EXHIBITED THE SAME PROBLEM WITHIN ONE BLOCK OF THE DEALERSHIP.

Owner-reported narrative. 4,300 miles reported. Look up ODI 10112287 at NHTSA ↗

WHEN THE VEHICLE IS BEING DRIVEN THE TRANSMISSION HESITATES, THEN JERKS FORWARD. THIS IS A DAILY OCCURRENCE.*AK *SB *M

Owner-reported narrative. 60 miles reported. Look up ODI 10119773 at NHTSA ↗

EXCESSIVE IDLE SPEED, BRAKE MUST BE DEPRESSED HARD TO STOP CAR FROM LURCHING FORWARD OR BACK DURING WARM-UP PERIOD WHEN CHANGING FROM PARK TO DRIVE OR REVERSE

Owner-reported narrative. 1 miles reported. Look up ODI 10122453 at NHTSA ↗

TURNING ON THE A/C AFTER STARTING THE ENGINE FROM A COLD START, THE A/C UNIT MAKES A GRINDING SOUND WHILE ENGAGING. THIS ONLY OCCURS WHILE ENGINE HAS NOT RUN FOR APPROXIMATELY 24 HRS. DEALER COULD NOT DUPLICATE THE PROBLEM AFTER SEVERAL ATTEMPTS.

Owner-reported narrative. Look up ODI 10124150 at NHTSA ↗

CAR IDLES AT A VERY HIGH RPM WHEN STARTED. CAUTION MUST BE USED TO FIRMLY DEPRESS THE BRAKE BEFORE SELECTING DRIVE OR REVERSE. MY CAR WILL DO 10 MPH WITHOUT TOUCHING THE ACCELERATOR. IT SEEMS TO TAKE FIVE MINUTES OR SO TO IDLE DOWN.

Owner-reported narrative. Look up ODI 10127317 at NHTSA ↗

ENGINE NOISE IS VERY LOUD. IT WOULD SEEM THAT THE SOUND INSULATION AROUND THE ENGINE IS MISSING, BUT IT IS NOT. THE RADIATOR FAN IS ESPECIALLY LOUD ON INITIAL ACCELERATION. MY FIRST 5000 MILE SERVICE WAS JUST COMPLETED AND AFTER MY COMPLAINT, THE DEALER PERFORMED A RECALL ON THE FAN WHICH WAS SUPPOSED TO REDUCE THE NOISE. IT IS NO BETTER. DURING HOT SUMMER DAYS, IT IS WORSE BECAUSE THE FAN RUNS FASTER (OR LOUDER) TO MAINTAIN PROPER ENGINE TEMPERATURE. (NOTE: I TRADED IN MY 2002 SEQUOIA WITH 80,000 MILES AND NEVER HEARD THE ENGINE ON THAT…

Owner-reported narrative. 5,000 miles reported. Look up ODI 10127318 at NHTSA ↗

Reported: 2007-01-19 (January 19, 2007)

ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.

Consequence: IN EXTREME CASES, IF THE VEHICLE IS CONTINUOUSLY OPERATED IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE AND COULD CAUSE A LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS. THE RECALL BEGAN ON FEBRUARY 28, 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2010-02-03 (February 3, 2010)

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Reported: 2014-11-19 (November 19, 2014)

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Reported: 2015-05-13 (May 13, 2015)

Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015 that they are recalling certain model year 2004 Sequoia vehicles manufactured August 18, 2003, to August 19, 2004, and 2003-2004 Tundra vehicles manufactured March 18, 2003, to August 25, 2004. On June 16, 2015, Toyota expanded the recall to include an additional 1,270,468 vehicles, including model year 2002-2003 and 2005-2007 Sequoia, 2005-2006 Tundra, 2003-2007 Corolla, 2003-2007 Corolla Matrix, 2003-2007 Pontiac Vibe and 2002-2007 Lexus SC vehicles. This is to address a safety defect in the passenger side frontal air bag inflator which may produce excessive internal pressure causing the inflator to rupture upon deployment of the air bag. This recall addresses both the passenger side frontal air bags that were originally installed in the vehicles, as well as replacement air bags that may have been installed as replacement service parts. A replacement air bag may have been installed, as one example, if a vehicle had been in a crash necessitating the replacement of the passenger side frontal air bag.

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-285 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the front passenger air bag. The recall began on July 13, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. Pontiac owners may call 1-800-762-2737. NOTE: This recall supersedes recall 14V-312 in its entirety.

Reported: 2015-05-13 (May 13, 2015)

Toyota Motor Engineering & Manufacturing (Toyota) notified the agency on May 13, 2015, that they are recalling 2005-2007 Lexus SC, Toyota Corolla, Corolla Matrix, Sequoia, and Pontiac Vibe, and 2005-2006 Toyota Tundra vehicles that were originally sold, or ever registered, in Florida, along the Gulf Coast, Puerto Rico, Hawaii, the U.S. Virgin Islands, Guam, Saipan and American Samoa. On June 16, 2015 Toyota expanded the recall to cover an additional 769,055 vehicles, including certain model year 2002-2004 Lexus SC, Toyota Sequoia, 2003-2004 Toyota Corolla Matrix, Toyota Corolla, Pontiac Vibe, and Toyota Tundra vehicles, as well the vehicles covered by the May 13, 2015 notification in the portions of Georgia, Alabama, Louisiana, Mississippi and Texas that were not previously included. The inflators in the front passenger air bags are susceptible to rupture in the event of a crash necessitating the deployment of the front passenger air bag.

Consequence: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.

Remedy: 2003-2004 Corolla and Corolla Matrix vehicles that are recalled under both 15V-043 and 15V-286 are under a Do Not Drive advisory. Owners of these vehicles are advised not to drive their vehicles until the recall remedy has been completed. Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the passenger side front air bag, free of charge. Owners may contact Toyota customer service at 1-800-331-4331. Toyota began the recall on July 13, 2015. Pontiac Vibe owners may contact GM at 1-800-762-2737. GM began the recall on June 29, 2015. NOTE: This recacll supersedes recall 14V-655 in its entirety. For vehicles located in the U.S. states not listed above, please see Toyota recall 15V-285 which covers all other U.S. states.

Reported: 2016-02-05 (February 5, 2016)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2006 Toyota Land Cruiser and Lexus LX470, 2005-2006 Toyota Tundra and Sequoia, 2004-2006 Toyota 4Runner and Lexus GX470 vehicles equipped with side curtain-shield-air bags. The affected vehicles have an air bag control module that may be improperly programmed, causing the side curtain-shield-air bags to deploy inadvertently.

Consequence: If the side curtain-shield-air bags deploy unexpectedly, it can increase the risk of occupant injury.

Remedy: Toyota will notify owners, and dealers will replace the air bag control module with one that has improved programming, free of charge. The recall began on December 1, 2016. Owners may contact Toyota customer service at 1-888-271-9371. Toyota's number for this recall is G0C and GLB.

Reported: 2016-06-02 (June 2, 2016)

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

Reported: 2018-12-12 (December 12, 2018)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2002-2005 Lexus SC and Toyota Sequoia, 2003-2005 Toyota Corolla and Tundra, and 2003-2007 Pontiac Vibe vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will notify the Pontiac Vibe owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator with an alternate inflator, or replace the air bag assembly that includes an alternate inflator, free of charge. The recall began January 23, 2019. Owners may contact Toyota customer service at 1-888-270-9371, Lexus customer service at 1-800-255-3987 or Pontiac customer service at 1-800-762-2737. Toyota's numbers for these recalls are J0A (Zone A Toyota), J0B (Zone B Toyota), J0C (Zone C Toyota), JLI (Zone A Lexus), JLJ (Zone B Lexus), and JLK (Zone C Lexus). Note: This recall includes vehicles that have had their air bag previously replaced under an earlier air bag campaign.

Reported: 2019-10-17 (October 17, 2019)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.