2006 Toyota HIGHLANDER: complaints, problems and recalls

DT: CONSUMER WAS IN A CAR ACCIDENT ON AUGUST 17, 2005 AND SIDE/CURTAIN AIR BAGS DID NOT DEPLOY. IT WAS SIDE IMPACT AT 45 MPH. HAD NOT CONTACTED TOYOTA AT THIS POINT. *AK

Owner-reported narrative. 900 miles reported. Look up ODI 10133915 at NHTSA ↗

TOYOTA HIGHLANDER HYBRID-I HAVE LOST ABS BRAKES, STABILITY CONTROL AND POWER STEERING ALONG WITH THE HYBRID ENGINE ON TWO OCCASIONS WITH MY 2 WEEK OLD 2006 HIGHLANDER. I HAVE BROUGHT IT TO THE DEALER TWICE-THE FIRST TIME THEY FOUND "MALFUNCTION CODES" AND "REBOOTED" THE COMPUTER AND TOLD ME IT WAS OPERATING AS "DESIGNED," ONLY TO HAPPEN AGAIN 2 DAYS LATER. CURRENTLY, THEY ARE REPLACING A COMPUTER. DATE OF INCIDENT AND PURCHASE OF VEHICLE IS ACTUALLY 2006 BUT IS NOT AN OPTION BELOW. I AM CONCERNED IT WILL HAPPEN AGAIN AND RESULT IN AN ACCIDENT I…

Owner-reported narrative. 140 miles reported. Look up ODI 10139802 at NHTSA ↗

DRIVER SIDE AIRBAG HAS TO BE REPLACED IN 3 MONTH OLD TOYOTA HIGHLANDER. WARNING LIGHT DID ACTIVATE INDICATING PROBLEM. DEALERSHIP INDICATED UNTIL REPAIR IS DONE AIR BAG SHOULDN'T DEPLOY INADVERTENTLY BUT PROBABLY WON'T DEPLOY IN AN ACCIDENT. *NM

Owner-reported narrative. 4,985 miles reported. Look up ODI 10151088 at NHTSA ↗

FIRST STARTUP IN MORNINGS. SOMETIMES VEHICLE FAILS TO START ON FIRST ATTEMPT. SECOND ATTEMPT IT STARTS BUT FOR SEVERAL MILES AFTER, A STRONG ODOR OF GAS IN CABIN AREA. MUST ROLL WINDOW DOWN TO ALLOW VENTILATION. WIFE FIRST COMPLAINED ABOUT THIS ISSUE AND I ASSUMED IT WAS BECAUSE SHE WAS DEPRESSING THE ACCELERATOR WHILE TRYING TO START VEHICLE. IT WAS NOT UNTIL I ATTEMPTED ON SEVERAL OCCASION AND THE SAME THING HAPPENED. *NM

Owner-reported narrative. 5,000 miles reported. Look up ODI 10153518 at NHTSA ↗

2006-TOYOTA HIGHLANDER-3.3V-6 WITH 5-SPEED AUTO-ERRATIC SHIFTING AND HESITATION AT SLOW SPEED WHEN LETTING OFF ACCELERATOR AND THEN REAPPLYING TRANSMISSION IS IN BETWEEN GEARS AND HESITATES THEN SLAMS INTO GEAR AND TAKES OFF,GENERALLY A LOT FASTER THAN YOU WANTED TO. ALSO UNDER ACCELERATION IT SOMETIMES ACTS LIKE IT DON'T KNOW WHAT GEAR IT WANTS TO BE IN. FROM COMPLAINTS OF OTHER CUSTOMERS AND AFTER TALKING TO TECH. THIS IS A COMMON COMPLAINT WITH THIS ENGINE AND TRANS. PACKAGE SINCE 2004 AND STILL NO FIX. I WAS TOLD TOYOTA PROGRAMMED IT THIS W…

Owner-reported narrative. Look up ODI 10153930 at NHTSA ↗

WHEN I USE THE A/C AND TURN IT OFF A BAD ODOR COMES FROM THE VENT . THIS IS A NEW 2006 HIGHLANDER, THE NEXT DAY I BROUGHT IT TO THE DEALER HE SAID TAKE FOR SERVICE , THEY TOLD ME TO DRIVE IT FOR A FEW MORE DAYS . I PUT 1500 MILES AND THE ODOR IS STILL THERE . I TOOK IT FOR SERVICE AGAIN . THE MECHANIC SAID TO USE A DEODORIZER ON THE VENT. I AM NOT A SATISFIED CUSTOMER. I WANT THIS ISSUE RESOLVED. I PAID FOR THE HIGHLANDER NOT THE SMELL THAT CAME WITH IT. *NM

Owner-reported narrative. 5 miles reported. Look up ODI 10158668 at NHTSA ↗

2006-TOYOTA HIGHLANDER-3.3V-6 WITH 5-SPEED AUTOMATIC TRANSMISSION ERRATIC SHIFTING AND HESITATION AT SLOW SPEED WHEN LETTING OFF ACCELERATOR AND THEN REAPPLYING TRANSMISSION. VEHICLE STAYS IN BETWEEN GEARS AND HESITATES. ONCE IT GETS INTO GEAR THE VEHICLE LUNGES FORWARD, MAKING IT NECESSARY TO APPLY THE BRAKES HARD. THIS IS PARTICULARLY DANGEROUS IN STOP AND GO TRAFFIC. I GET NERVOUS WHEN TRYING TO MERGE INTO HIGHWAY TRAFFIC BECAUSE I DON'T KNOW HOW THE ACCELERATOR WILL RESPOND AT ANY GIVEN MOMENT. IT IS AN ACCIDENT WAITING TO HAPPEN. I …

Owner-reported narrative. 1,000 miles reported. Look up ODI 10164466 at NHTSA ↗

DT*: THE CONTACT STATED WHILE BRAKE PRESSURE WAS APPLIED AT 5 MPH INTO A PARKING SPACE, THE VEHICLE LURCHED FORWARD AND JUMPED OVER A CURB WITHOUT WARNING. THE CONTACT SHIFTED THE VEHICLE IN REVERSE AND THE VEHICLE SUDDENLY ACCELERATED BACKWARDS WHILE CONSTANT BRAKE PRESSURE WAS APPLIED. THE VEHICLE CRASHED INTO ANOTHER PARKED VEHICLE WHERE IT CAME TO A FINAL STOP. THE CONTACT WAS WEARING A SEAT BELT, BUT NO INJURIES WERE SUSTAINED. THERE WAS MODERATE DAMAGE TO THE REAR BUMPER AND RIGHT PASSENGER SIDE PANEL OF THE VEHICLE. THE POLICE WERE…

Owner-reported narrative. 4,500 miles reported. Look up ODI 10166873 at NHTSA ↗

Reported: 2009-06-15 (June 15, 2009)

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Reported: 2010-02-03 (February 3, 2010)

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Reported: 2010-02-03 (February 3, 2010)

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Reported: 2010-10-21 (October 21, 2010)

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

Reported: 2011-02-24 (February 24, 2011)

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2014-11-19 (November 19, 2014)

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Reported: 2016-06-02 (June 2, 2016)

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.