2010 Toyota HIGHLANDER HYBRID: complaints, problems and recalls

TL* THE CONTACT OWNS A 2010 TOYOTA HIGHLANDER HYBRID. THE CONTACT WAS DRIVING APPROXIMATELY 20 MPH, DURING BRAKING THERE WAS A DELAY IN THE RESPONSE TIME. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS ABLE TO CONTINUE IN OPERATION. ADDITIONALLY, WHEN IN AN IDLING POSITION THE VEHICLE WOULD SHAKE CAUSING A JERKING MOTION TO OCCUR. THE AUTHORIZED DEALER WAS NOTIFIED OF THE MALFUNCTIONS WHICH THERE WERE NO RESOLUTIONS. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE WAS 1,000.

Owner-reported narrative. 1,000 miles reported. Look up ODI 10331551 at NHTSA ↗

HYBIRD SYSTEM OVERRIDES ALL WHEEL DRIVE SYSTEM WHEN TIRES SLIP DISABLING THE SYSTEM, IN EFFECT RENDERING IT NONFUNCTIONAL, SO THAT THE GENERATOR IS NOT DAMAGED. COMBUSTION ENGINE WILL NOT TURN ON AND WHEN YOU HIT GAS NOTHING HAPPENS. I HAD TO BE TOWED OUT. SERVICE QUOTED AFTER EXAMINING "DID EXPERIENCE CONCERN TRAC/VCS CUTS POWER TO WHEEL WHEN SLIPPAGE OCCURS. UNFORTUNATLY, THERE IS NO WAY TO DISABLE THIS. EVERYTHING WORKS AS DESIGNED." MY 2006 HIGHLANDER HYBRID HAD SIMILAR INCIDENT ALMOST CAUSING ME TO BE RUN OVER AS POWER CUT OFF ON HIG…

Owner-reported narrative. 17,000 miles reported. Look up ODI 10377307 at NHTSA ↗

2010 TOYOTA HIGHLANDER HYBRID. CONSUMER STATES THAT VEHICLE IS SUPPOSE TO BE ALL WHEEL DRIVE, HOWEVER THE HYBRID SYSTEM IS NOT COMPATIBLE WITH THE ALL WHEEL DRIVE SYSTEM *TGW THE CONSUMER STATED WHEN THE VEHICLE WOULD SLIDE, THE HYBRID SYSTEM SHUT DOWN THE ALL-WHEEL DRIVE SYSTEM BECAUSE THE COMPUTER WAS TRYING TO PREVENT DAMAGE TO THE GENERATOR WHICH IS A PART OF THE HYBRID SYSTEM. *JB

Owner-reported narrative. Look up ODI 10382014 at NHTSA ↗

KEYLESS FOB RESULTED IN CAR BEING LEFT ON ALL NIGHT IN ENCLOSED GARAGE. THE DESIGN DEFECT IN NOT AUTOMATICALLY TURNING THE ENGINE OFF WHEN THE FOB LEAVES THE IMMEDIATE AREA IS WELL-KNOWN. THE ADDITIONAL PROBLEM IN THE TOYOTA HIGHLANDER HYBRID IS THAT THE GREEN POWER LIGHT GOES ON WHEN YOU TURN OFF THE CAR, LEADING THE DRIVER TO BELIEVE THAT THE POWER IS NOW ON, WHEN IN FACT IT IS OFF. THE DRIVER THEN STEPS ON THE BRAKE AND PRESSES POWER AGAIN, THINKING THAT THEY ARE NOW TURNING THE CAR OFF BECAUSE THE POWER BUTTON IS NO LONGER GREEN. THE HYBRID…

Owner-reported narrative. 1,000 miles reported. Look up ODI 10383059 at NHTSA ↗

MULTIPLE BATTERY FAILURES REQUIRING JUMP STARTS: SEVEN (7) TIMES SINCE I BOUGHT THIS SUV IN FEB 2011. THREE TIMES THERE WAS A POSSIBLE KNOWN CAUSE FOR THE BATTERY DRAIN: THE PASSENGER VANITY MIRROR LIGHT WAS LEFT ON FOR 15 MINUTES, 2 HOURS, AND AN UNKNOWN LENGTH OF TIME. NONE OF THESE THREE EPISODES WAS SIGNIFICANT ENOUGH TO CAUSE A COMPLETELY DEAD BATTERY IN ONE THAT HAS BEEN EVALUATED AS IN EXCELLENT CONDITION. I DRIVE IN THE MOUNTAINS ALL WINTER. GETTING STRANDED IN AN ISOLATED PLACE CAN BE DEADLY DUE TOO EXPOSURE, RISK OF COLLISION …

Owner-reported narrative. 21,000 miles reported. Look up ODI 10462357 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED WHILE DRIVING 40 MPH, THE VEHICLE STALLED. THE CONTACT TOWED THE VEHICLE TO A DEALER. THE DEALER PERFORMED A DIAGNOSTIC TEST. THE TEST SHOWED A DEFECTIVE COIL PACK WHICH CAUSED THE VEHICLE TO STALL. THE DEALER REPLACED THE COIL AS WELL AS THE BATTERY. THE FAILURE MILEAGE WAS 25,400.

Owner-reported narrative. 25,400 miles reported. Look up ODI 10496728 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 TOYOTA HIGHLANDER HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE WHEEL BEARING SENSOR NEEDED TO BE REPLACED. THE CONTACT MENTIONED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR THE SAME FAILURE ON THREE OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 77,000. *TR

Owner-reported narrative. 77,000 miles reported. Look up ODI 10514848 at NHTSA ↗

MY TOYOTA HIGHLANDER HYBRID HAS EXTREMELY POOR BRAKING IN SNOW / ICY CONDITIONS. EVEN AT EXTREMELY LOW SPEEDS (10 TO 15 MPH), THE CAR SKIDS FOR TENS OF FEET BEFORE COMING TO A HALT. THREE TIMES SO FAR, IT CAUSED DANGEROUS SITUATIONS BECAUSE THE CAR KEPT GOING DESPITE FULL ENGAGEMENT OF THE BRAKES. ONCE, I NARROWLY MISSED BEING HIT BY A 53' TRUCK BECAUSE MY CAR ROLLED INTO A MAJOR STREET, JUST BARELY GETTING BY BEFORE THE TRUCK CAME THROUGH. I HAVE ATTEMPTED TO TALK WITH THE DEALER - THE RESPONSE IS THAT HYBRID CARS BRAKE DIFFERENTLY. I HAV…

Owner-reported narrative. 34,000 miles reported. Look up ODI 10558524 at NHTSA ↗

Reported: 2013-01-16 (January 16, 2013)

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

Consequence: If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

Remedy: Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Reported: 2013-04-09 (April 9, 2013)

Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

Consequence: An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

Remedy: Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Reported: 2013-09-04 (September 4, 2013)

Toyota is recalling certain model year 2006-2010 Highlander hybrid vehicles manufactured February 16, 2005, through July 29, 2010; and model year 2006-2008 Lexus RX400h vehicles manufactured February 23, 2005, through December 2, 2008. The Intelligent Power Module (IPM) inside the inverter module may contain transistors that have higher operating temperatures than the solder can support and the transistors may be heat damaged by the solder. If this occurs, various warning lamps, including the malfunction indicator lamp, slip indicator light, brake system warning light, and master warning light, will be illuminated on the instrument panel.

Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. It is possible that the hybrid system will shut down while the vehicle is being driven, causing the vehicle to stall unexpectedly, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace the IPM free of charge. Owners may contact Toyota at 1-800-331-4331. Vehicles that had their IPM replaced under recall 11V-342 are not affected by this campaign.

Reported: 2015-10-22 (October 22, 2015)

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.