2008 Toyota FJ CRUISER: complaints, problems and recalls

PURCHASE THE 2008 FJ CRUISER ON OCT. 13TH 2007 WITH LESS THAN 300 MILES ON THE VEHICLE I NOW HAVE A CRACKED WINDSHIELD. I DIDN'T HEAR ANYTHING HIT THE WINDOWS, BUT NOTICED THE 6 INCH LONG CRACK WHEN I OPENED THE DOOR THIS MORNING (OCT 18) TO DRIVE THE VEHICLE TO WORK. NOTE: I COULD NOT SHOW THE INCIDENT DATE CORRECTLY AS 2008 IS NOT AVAILABLE FOE SELECTING. *TR

Owner-reported narrative. Look up ODI 10206214 at NHTSA ↗

I BOUGHT A NEW 2008 TOYOTA FJ CRUISER ON 10/18/07 AND MY WINDSHIELD HAS BEEN CHIPPED THREE TIMES NOW(5/8/08). I HAVE TALKED TO SEVERAL OTHER OWNERS OF THIS VEHICLE AND ALL HAVE HAD THE SAME PROBLEM. IN SOME STATES INSURANCE WILL PAY FOR A NEW WINDSHIELD BUT NOT GA. *TR

Owner-reported narrative. 1,500 miles reported. Look up ODI 10227034 at NHTSA ↗

I OWN A 2008 TOYOTA FJ CRUISER AND HAVE DRIVEN BOTH ON AND OFF ROAD SINCE FEBRUARY OF 2008. I HAVE NOTICED A POPPING SOUND WHEN OPENING THE PASSENGER SIDE DOOR, WHEN THE DEALERSHIP WENT TO LOOK AT WHY THIS WAS HAPPENING THEY DISCOVERED THAT THE INNER FENDER APRON IN THE ENGINE BAY WAS BUCKLED AND TORN IN THE CRUMPLE ZONE EVEN THOUGH I HAVE NEVER STRUCK ANYTHING WITH MY VEHICLE, NOT THE GROUND, NOT ANOTHER CAR, NOTHING. THE RIPS RUN FROM THE TOP OF THE CRUMPLE ZONE TO APPROXIMATELY ONE HALF INCH FROM THE BOTTOM, THE TOP OF THE TEAR IS FOLDING F…

Owner-reported narrative. 15,047 miles reported. Look up ODI 10243311 at NHTSA ↗

2008 FJ CRUISER HAS TRAVELED APPROXIMATELY 150 MILES OFF ROAD ON ESTABLISHED TRAILS AND 15000 MILES ON PAVED ROADS. THERE ARE TEARS IN THE INNER FENDER APRONS IN THE CRUMPLE ZONE AND THE NOSE OF THE BODY APPEARS TO BE SAGGING DOWN. THE PASSENGER SIDE DOOR IS IMPINGED AND PAINT IS CHIPPING OFF WHEN IT IS OPENED. THE RIPS FORMED SPONTANEOUSLY, THERE HAS BEEN NO COLLISION OR IMPACT ON THE VEHICLE. THE TEARS ARE THROUGH METAL RUNNING FROM THE TOP OF THE CRUMPLE ZONE TO ABOUT A HALF INCH BEFORE THE BOTTOM OF THE CRUMPLE ZONE, THE TEAR IS ABOUT 6 INC…

Owner-reported narrative. 15,000 miles reported. Look up ODI 10244341 at NHTSA ↗

WHILE DRIVING THE VEHICLE, SIDE WALL BLOW OUT. VEHICLE PURCHASED NEW HAD 14,000 MILE ON IT. FRONT TIRE BLEW OUT REAR TIRE HAS "BUBBLE" IN SAME AREA. THE VEHICLE IS A 2008 TOYOTA FJ CRUISER. *TR

Owner-reported narrative. 14,000 miles reported. Look up ODI 10245574 at NHTSA ↗

2008 TOYOTA FJ CRUISER IS EXPERIENCING INNER FENDER BULGING. THIS STARTED OCCURRING SHORTLY AFTER BUYING THE VEHICLE. THE VEHICLE CURRENTLY HAS 4800 MILES. THIS PROBLEM HAS BEEN WELL DOCUMENTED AND IN MOST CASES DOES NOT STOP UNTIL THE INNER FENDER IS CRACKED ALL THE WAY THROUGH. OBVIOUSLY, THERE IS SOME SORT OF DESIGN FLAW. *TR

Owner-reported narrative. 4,800 miles reported. Look up ODI 10248777 at NHTSA ↗

JUST BOUGHT A BRAND NEW FJ CRUISER AND WITHIN 2 MONTHS THE WINDSHIELD IS CRACKED. IN TWO PLACES. THEY ARE IMPACT BUT I HAVE HEARD THIS IS A VERY BIG PROBLEM WITH THE SUVS. *TR

Owner-reported narrative. 7,000 miles reported. Look up ODI 10251250 at NHTSA ↗

HAD VEHICLE LIFTED BY TOYOTA AND PAID TOYOTA FOR THIS MODIFICATION. APPROX 10 MONTH LATER I SHOWING SIGN OF FENDERS BULGING AND TEARING. THEY HAD ME SIGN A WAVIER THAT WARRANTY MAY NOT COVER MODIFICATIONS AFTER ACCEPTING VEHICLE. YET THERE HAVING VEHICLES LIFTED AND PUT ON THERE LOT TO SELL. I HAVE TALKED TO MANY OTHERS WHO HAVE THIS PROBLEM SOME LIFTED SOME NOT. ALSO TOYOTA HAVE A UPGRADED THE PARTS TO FIX PROBLEM .WHICH I HAVE PICTURES OF. THE PROBLEM IS FRAME FLEXES TO MUCH AND RIPS IN WRINKLE ZONES ON VEHICLE FOR FRONTAL CRASHES. I USES …

Owner-reported narrative. 9,512 miles reported. Look up ODI 10252695 at NHTSA ↗

Reported: 2009-06-15 (June 15, 2009)

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Reported: 2010-02-03 (February 3, 2010)

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Reported: 2010-02-03 (February 3, 2010)

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Reported: 2011-03-04 (March 4, 2011)

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 FJ CRUISER, LAND CRUISER, TACOMA, SEQUOIA AND TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEM (TPMS)." WHEN FACTORY-INSTALLED WHEELS AND TIRES WERE REPLACED WITH TOYOTA AUTHORIZED ACCESSORY WHEELS AND LT TIRES PRIOR TO FIRST SALE, THE TIRE PRESSURE MONITORING SYSTEMS WERE NOT RE-CALIBRATED CORRECTLY AND THEREFORE DO NOT START ILLUMINATING THE LOW TIRE PRESSURE WARNING TELLTALE AT THE REQUIRED MINIMUM ACTIVATION PRESSURE.

Consequence: FAILURE TO WARN OF TIRE DEFLATIONS IS A NON-COMPLIANCE WITH FMVSS 138 AND COULD LEAD TO TIRE FAILURE INCREASING THE RISK OF A CRASH.

Remedy: FOR THE LAND CRUISER, SEQUOIA, TACOMA AND TUNDRA VEHICLES, THE DEALER WILL RE-CALIBRATE THE TIRE PRESSURE MONITORING SYSTEM ON AFFECTED VEHICLES AND INSTALL AN UPDATED TIRE AND LOADING INFORMATION LABEL AT NO CHARGE. FOR THE FJ CRUISER VEHICLES, THE TPMS CANNOT BE RESET SO THE ELECTRONIC CONTROL UNIT (ECU) FOR THE TPMS WILL BE REPLACED. TOYOTA IS CURRENTLY DEVELOPING THE REMEDY ECU. IF AN OWNER IS NOT CERTAIN WHETHER HIS OR HER VEHICLE IS EQUIPPED WITH THESE ACCESSORIES, PLEASE CONTACT ANY TOYOTA DEALER FOR AN INSPECTION AT NO CHARGE. THE SAFETY RECALL BEGAN ON MARCH 31, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2013-03-15 (March 15, 2013)

Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.

Consequence: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.

Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.

Reported: 2013-04-25 (April 25, 2013)

Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."

Consequence: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.

Reported: 2014-08-04 (August 4, 2014)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2014 FJ Cruiser and Tacoma vehicles equipped with accessory wheels and tires installed by Toyota or dealers prior to the vehicle's first sale. The affected vehicles may list incorrect spare tire size and/or cold tire inflation information on the tire placard. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard No. 110, "Tire Selection and Rims for Passenger Cars."

Consequence: If the spare tire is inflated to the incorrect pressure provided on the placard, tire failure may occur while it is being driven on, increasing the risk of a crash.

Remedy: For the involved vehicles, overlay stickers to correct the tire placard will either be mailed to owners or provided to dealers for placement over the incorrect information on the placard. The recall is expected to begin in September 2014. Owners may contact Toyota customer service at 1-800-331-4331.

Reported: 2014-11-19 (November 19, 2014)

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Reported: 2016-06-02 (June 2, 2016)

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.