2007 Toyota FJ CRUISER: complaints, problems and recalls

THE VEHILE JUST STOPPED RUNNING AT 60 MPH ON THE HIGHWAY AND STEERING BRAKES FAILED AND COASTED TRYING TO START CAR NO START TRANSMISSION DAMAGED BY EXTENSIVE COAST TO STOP AND STARTER DAMAGEG BY TRYING TO START ON HUGHWAY. THIS WIL CAUSE DEATH OR INJURY--THIS IS A COCEPT VEHICLE PUT OUT TOO EARLY! *JB

Owner-reported narrative. 3,300 miles reported. Look up ODI 10161834 at NHTSA ↗

DT*: THE CONTACT STATED THE VEHICLE WAS RECALLED (NHTSA CAMPAIGN ID #06V235000) FOR BEAD DEFECT ON THE TIRES. AN AUTHORIZED SERVICE DEALER INSPECTED THE TIRES. THE RECALL NOTICE AND THE DEALER'S MECHANIC INFORMED THE CONTACT THAT ONLY THE DEFECTIVE TIRES WOULD BE REPLACED. THE CONTACT EXPRESSED CONCERNED ABOUT THE PROPER WEAR OF THE TIRES IF THEY WERE NOT ALL REPLACED.

Owner-reported narrative. 3,600 miles reported. Look up ODI 10164293 at NHTSA ↗

WHEN DRIVING MY BRAND NEW FJ CRUISER IT STALLED AND LOST ALL POWER. I WAS FORCED TO CALL A TOW TRUCK BECAUSE IT WAS ON A SECLUDED HIGHWAY IN THE MIDDLE OF THE NIGHT. AFTER GETTING IT TOWED TO A DEALERSHIP THEY STILL HAVE THE VEHICLE AND HAVE DIAGNOSED IT AS THE FUEL PUMP ASSEMBLY AND THEY ARE WAITING FOR PARTS TO BE DELIVERED. THE VEHICLE WAS BOUGHT IN 6/2006 AND HAS LESS THAN 5000 MILES ON IT. I WAS NOT GIVEN A REPLACEMENT VEHICLE AND WAS TOLD I SHOULD HAVE TAKEN IT TO THE DEALERSHIP I BOUGHT IT FROM IN SAN JOSE, CA. AFTER THREATENING NOT TO P…

Owner-reported narrative. 4,000 miles reported. Look up ODI 10165447 at NHTSA ↗

I PURCHASED AN FJ CRUISER TOYOTA IN MAY 2006, I DROVE APPROXIMATELY 3000 MILES,AND NOTICED THE TIRES WERE GETTING LOW AND THEN I WOULD ADD AIR AND AGAIN THEY WOULD LOSE AIR. I WENT TO WHEELWORKS AND REPLACED THE TIRES. I THINK THIS VEHICLE SHOULD BE IN THE RECALL. *JB

Owner-reported narrative. 3,000 miles reported. Look up ODI 10169404 at NHTSA ↗

WHILE TRAVELING A FREEWAY SPEED THE VEHICLE ENGINE SHUT OFF WITHOUT WARNING AND DISABLED THE POWER BRAKES AND STEERING. I VERIFIED THAT THE VEHICLE HAD 1/4 TANK OF GASOLINE AND ALL OF THE FUSES CHECKED OUT OK. CALLED TOYOTA ROADSIDE SERVICE AND THEY DISPATCHED A TOW TRUCK AND DROPPED OF VEHICLE AT THE NEAREST DEALER. *NM

Owner-reported narrative. 5,149 miles reported. Look up ODI 10171990 at NHTSA ↗

2007 TOYOTA FJ CRUISER WAS DRIVEN ON EDGE OF TERRA COTTA PIPE WHILE PULLING INTO A DRIVE WAY AND GOT STUCK. AFTER BEING PULLED OUT, VEHICLE SAT OVER NIGHT. VEHICLE WAS DRIVEN THE NEXT DAY. WHILE DRIVING ABOUT 10 MILES, VEHICLE ENGINE STARTED MAKING NOISE AND CHECK ENGINE LIGHT CAME ON. OWNER OF VEHICLE CALLED A MECHANIC WHO FOUND THAT THE FRAME HAD BEEN TWISTED AND THE RADIATOR WAS BUSTED WHICH CAUSED $15,500 WORTH OF BODY AND ENGINE DAMAGE. INSURANCE AND MANUFACTURER'S WARRANTY REFUSED TO COVER ENGINE DAMAGE. VEHICLE IS ADVERTISED AS EXTREMELY…

Owner-reported narrative. 15,695 miles reported. Look up ODI 10179117 at NHTSA ↗

TL *- THE CONTACT OWNS A 2007 FJ CRUISER. THE CONTACT STATED THAT THERE IS A RECALL ON THE INSTALLATION OF DUNLOP TIRES. THE CONTACT CURRENTLY HAS NO TIRE DAMAGE, BUT WASCONCERNED THAT A BULGE COULD DEVELOP AT ANY TIME AND CREATE A PROBLEM LATER. THE CONTACT WANTED ALL FIVE TIRES REPLACED AS STATED IN THE RECALL. THE CURRENT MILEAGES WAS 12000.*AK

Owner-reported narrative. 12,000 miles reported. Look up ODI 10181577 at NHTSA ↗

ENGINE ACCELERATES TO 1500 RPM WHEN I TAKE MY FOOT COMPLETELY OFF THE THROTTLE WHEN DRIVING AT SLOW SPEEDS (UNDER 1500 RPM). THIS CAUSES THE VEHICLE (MANUAL TRANSMISSION) TO SPEED UP INSTEAD OF SLOWING DOWN, EXACTLY THE OPPOSITE OF THE "ENGINE BRAKING" THAT ONE WOULD EXPECT. I FEEL THIS PRESENTS A MAJOR SAFETY HAZARD WHEN DRIVING IN TRAFFIC AND / OR ICY ROAD CONDITIONS. *JB

Owner-reported narrative. 21 miles reported. Look up ODI 10182004 at NHTSA ↗

Reported: 2006-06-26 (June 26, 2006)

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH EITHER BRIDGESTONE DUELER OR DUNLOP GRANDTREK TIRES, THERE IS A POSSIBILITY THAT THE INNER BEAD OF THE TIRE MAY HAVE BEEN DAMAGED. IF THE BEAD IS DAMAGED, A BULGE MAY DEVELOP ON THE SIDEWALL OF THE TIRE AND AIR MAY LEAK FROM THE AREA OF THE DAMAGED BEAD.

Consequence: IF THE TIRE LOSES AIR PRESSURE IT MAY LEAD TO A LOSS OF VEHICLE CONTROL AND INCREASE THE POSSIBILITY OF A CRASH.

Remedy: DEALERS WILL INSPECT ALL FIVE TIRES, INCLUDING THE SPARE TIRE, TO DETERMINE IF THEY ARE WITHIN THE AFFECTED TIRE-TO-WHEEL ASSEMBLY RANGE AND REPLACE ALL INVOLVED TIRES WITH NEW TIRES FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331. NOTE: DUE TO AN ERROR IN THE DOT SERIAL NUMBER SECTION OF THE TECHNICAL INSTRUCTIONS, A NUMBER OF VEHICLES WERE NOT INSPECTED CORRECTLY. TOYOTA RELAUNCHED THIS CAMPAIGN IN MID-AUGUST 2006.

Reported: 2009-06-15 (June 15, 2009)

TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."

Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.

Reported: 2010-02-03 (February 3, 2010)

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Reported: 2010-02-03 (February 3, 2010)

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

Reported: 2013-03-15 (March 15, 2013)

Toyota is recalling certain model year 2007 through 2013 FJ Cruiser passenger vehicles. The retractors for the front driver and passenger seat belts are mounted in the access door (rear door) panels of the vehicle. Due to insufficient strength of the access door panel, cracks may develop in the panel if the access door is repeatedly and forcefully closed over an extended period of time.

Consequence: If cracks occur in the panel around the lower retractor anchor, the seat belt retractor could become detached, which could increase the risk of injury to an occupant in the event of a crash.

Remedy: The safety recall began on June 6, 2013. Toyota will mail an interim letter to owners late in April 2013. Remedy notifications to the owners for the repair will begin in late May 2013. Owners may contact Toyota at 1-800-331-4331.

Reported: 2013-04-25 (April 25, 2013)

Toyota Motor Corporation (Toyota) is recalling certain model year 2007-2013 FJ Cruiser vehicles manufactured January 25, 2006 through February 23, 2013 and equipped with a Toyota Auxiliary Driving Lamp Kits mounted to the front bumper. These lamp assemblies include 55 watt bulbs and due to this wattage and mounting angle, the combination of the upper beam headlamps plus the auxiliary lamps are too bright and exceed the maximum light output allowed for an upper beam headlamp. Therefore, these vehicles fail to conform to Federal Motor Vehicle Safety Standard No. 108, "Lamps, reflective devices, and associated equipment."

Consequence: Light intensities above the maximum allowable limit could cause increased glare for oncoming traffic and increase the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace the 55 watt bulbs with 35 watt bulbs, free of charge. The recall began on June 6, 2013. Owners may contact Toyota at 1-800-331-4331.

Reported: 2014-11-19 (November 19, 2014)

Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.

Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.

Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.

Reported: 2016-06-02 (June 2, 2016)

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.