2003 Toyota AVALON: complaints, problems and recalls

WHEN THE STEERING WHEEL IS IN THE DRIVE POSITION, IT CAN'T BE SEEN FROM 40MPH AND UP. IN ORDER TO SET THE CRUISE CONTROL, THE DRIVER WOULD HAVE TO TAKE THE ATTENTION OFF OF THE ROAD BECAUSE THEY'RE UNABLE TO VIEW THE SPEEDOMETER DUE TO THE STEERING WHEEL OR THE DASHBOARD DESIGN. TS THE BRAKES NEEDED EXCESSIVE EFFORT IN ORDER TO STOP. UPON THE SECOND APPLICATION OF THE BRAKES, THE CRUISE CONTROL WAS DISENGAGED. SCC

Owner-reported narrative. Look up ODI 10001386 at NHTSA ↗

ON 4/01/03, I LEASED A 2003 TOYOTA AVALON XL FROM PRESTIGE TOYOTA OF RAMSEY, N.J. BY THE TIME I SIGNED ALL OF THE PAPERWORK AND TOOK POSSESSION OF THE CAR, IT HAD BECOME DARK OUTSIDE. THE DISPLAY OF GEAR POSITIONS (P, R, N, D, 2, L) WHICH WAS OBVIOUS IN DAYLIGHT, WAS NOW IMPOSSIBLE FOR ME TO DISTINGUISH. BY THE TIME I ARRIVED HOME, MY EYES WERE STRAINED FROM TRYING TO READ THE LETTERS, THUS CREATING A HAZARDOUS DRIVING EXPERIENCE. FROM DUSK TO DAWN, IT IS UNNERVING TO SEARCH FOR LETTERS ON THE DASH BOARD PANEL. WHILE ALL OTHER INDICATORS A…

Owner-reported narrative. Look up ODI 10014289 at NHTSA ↗

PROBLEMS WITH VIEWING GEAR SHIFT POSITIONS DURING NIGHT DRIVING. *MR WHEN THE CONSUMER HAD TOOK POSSESSION OF THE VEHICLE, THE INTERIOR HAD BECOME DARK. THE DISPLAY OF THE GEAR POSITION COULD BE SEEN IN THE DAYLIGHT HAD BECOME HARD TO SEE. (ILLUMINATION OF THE SELECTION LEVEL) THE PROBLEM PLACED A STRAIN ON THE CONSUMERS EYES. *SCC *JB

Owner-reported narrative. Look up ODI 10024094 at NHTSA ↗

THIS PERTAINS TO A NEW 2003 TOYOTA AVALON LXS BRAKING SYSTEM. AT RANDOM TIMES THE BRAKES APPEAR TO BE AUTOMATICALLY APPLIED. THEY BECOME EXTREMELY HOT AND CAUSE THE VEHICLE TO SHIMMY AND SEVEREL VIBRATE. AFTER THE FIRST INCIDENT IT WAS TAKEN TO THE DEALER, WHO MACHINED THE FRONT ROTORS AND SANDED THE PAD, THE SECOND INCIDENT OCCURRED IN JUNE 03. THE DEALER ROTATED THE TIRES. THE THIRD INCIDENT OCCURRED THE END OF JUNE 03. A REGIONAL SERVICE TECH WAS CALLED BY THE DEALER AND WHILE HE WAS IN THE VEHICLE THE CONDITION OCCURRED AGAIN. THEY REPLACE…

Owner-reported narrative. 2,650 miles reported. Look up ODI 10030665 at NHTSA ↗

WHEN DRIVING AND APPLYING BRAKES ENGINE WOULD START TO REV THIS WOULD CAUSE A HESITATION IN THE VEHICLE WHEN THE ACCELERATOR WAS DEPRESSED. HAD TAKEN TO DEALER AND THE PROBLEM HAD NOT BEEN RESOLVED.*AK

Owner-reported narrative. 52,000 miles reported. Look up ODI 10038252 at NHTSA ↗

THERE WAS FLUTTERING WHILE DRIVING AT HIGHWAY SPEEDS DUE TO WEAK SPRINGS IN THE SUN ROOF ASSEMBLY. *AK THE AIR DAM (WIND DEFLECTOR PART OF THE MOON ROOF) FLUTTERED AT HIGHWAY SPEEDS AND CAUSED A SHOCK WAVE/EXTREMELY LOUD NOISE IN THE VEHICLE. TOYOTA REFUSED TO CORRECT THE PROBLEM. *SCC *JB

Owner-reported narrative. 100 miles reported. Look up ODI 10040463 at NHTSA ↗

THE PAINT SEEMS TO BE CHIPPING VERY EASILY ON MY NEW AVALON WITH THE DESERT SAND MICA COLOR. YOU WOULD THINK I DROVE BEHIND GRAVEL TRUCKS THE WHOLE TIME I'VE HAD IT. AND I'VE ONLY HAD IT FOR 6 MONTHS, AND 8500 MILES. LOOKING AT IT YOU'D THINK IT HAD A LOT MORE MILES ON IT. *LA

Owner-reported narrative. 8,500 miles reported. Look up ODI 10041328 at NHTSA ↗

EXCESSIVE WIND NOISE FROM DRIVER SIDE WINDOW DURING HIGHWAY DRIVING. *LA

Owner-reported narrative. 1,000 miles reported. Look up ODI 10041609 at NHTSA ↗

Reported: 2010-07-29 (July 29, 2010)

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2000-2004 AVALON VEHICLES. DUE TO IMPROPER CASTING OF THE STEERING LOCK BAR, THERE IS A POSSIBILITY THAT A MINUTE CRACK MAY DEVELOP ON THE SURFACE OF THE LOCK BAR. SUCH A CRACK MAY EXPAND OVER A LONG PERIOD OF REPEATED LOCK AND UNLOCK OPERATIONS, AND EVENTUALLY THE LOCK BAR COULD BREAK.

Consequence: SHOULD THE STEERING LOCK BAR BREAK, THE STEERING WHEEL WOULD LOCK AND THE DRIVER WOULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE STEERING INTERLOCK DEVICE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 7, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Reported: 2015-01-28 (January 28, 2015)

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2003-2004 Toyota Corolla vehicles manufactured December 28, 2001, to May 2, 2004, 2003-2004 Toyota Corolla Matrix vehicles manufactured January 6, 2002, to April 29, 2004, 2003-2004 Avalon vehicles manufactured June 5, 2002, to December 20, 2004, and 2003-2004 Pontiac Vibe vehicles manufactured January 18, 2002, to April 27, 2004. Due to electrical noise, a component in the air bag control module may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence: Inadvertent deployment of the air bags or the seat belt pretensioners increases the risk of an injury or crash.

Remedy: Toyota will notify their owners. Pontiac Vibe owners will be notified by GM. Dealers will replace the air bag control module, free of charge. The recall began on August 24, 2015. Toyota owners may contact Toyota customer service at 1-800-331-4331. GM issued an interim notification to owners on March 27, 2015. The recall began on August 24, 2015. Pontiac owners may call 1-800-620-7668. Note: This recall supersedes recalls 13V-029 and 14V-147. Vehicles that had a noise filter installed as the remedy for one of those campaigns need to have the air bag control module replaced under this campaign.