2011 Tiffin ALLEGRO: complaints, problems and recalls

THE ALLEGRO RED HAS TWO DIESEL FUEL FILLING PORTS. IT IS A REAR ENGINE DIESEL AND I FILL UP AT TRUCK STOPS WHERE THEY HAVE A FUEL PUMP ON EITHER SIDE. MANY TRUCK DRIVERS USE BOTH PUMPS TO SHORTED THE FILL TIME. HOWEVER, THE PASSENGER'S SIDE FILL IS LOWER THAN THE DRIVER'S SIDE AND IF YOU USE BOTH PUMPS, YOU CAN OVERFLOW THE PASSENGER'S SIDE FILL AND SPILL DIESEL FUEL BECAUSE THE DRIVER'S SIDE PUMP DOES NOT KNOW THE TANK IS FILLED TO THE LEVEL OF THE PASSENGER SIDE OPENING. TIFFIN IS AWARE OF THE PROBLEM, BUT NO WARNINGS HAS BEEN POSTED TO O…

Owner-reported narrative. Look up ODI 10393468 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 TIFFIN ALLEGRO RV. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT SMELLED A BURNING ODOR AND MANEUVERED TO THE SIDE OF THE ROAD. SUDDENLY, THE REAR END OF THE VEHICLE ENGULFED INTO FLAMES, WHICH THE CONTACT STATED ORIGINATED FROM THE ENGINE AREA. THE FIRE DEPARTMENT EXTINGUISHED THE LARGE FLAMES AND THE VEHICLE WAS DECLARED AS DESTROYED. THE VEHICLE WAS TOWED TO AN IMPOUND FACILITY. THERE WAS NO PERSONAL INJURY. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE CONTACT DISCOVERED A RECALL WHICH COULD POSSIBLY HAVE …

Owner-reported narrative. 8,000 miles reported. Look up ODI 10428763 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 TIFFIN ALLEGRO RV. WHILE DRIVING APPROXIMATELY BETWEEN 20-40 MPH THE BRAKES OVERHEATED AND SMOKE EMITTED INSIDE OF THE VEHICLE. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD TO INSPECT THE VEHICLE AND THEN CONTINUED TO DRIVE WITH CAUTION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE FRONT AND REAR BRAKES WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 3,500. UPDATED 10/26/11 *BF UPDATED 11/03/11 *BF UPDATED 12/15/11 *BF THE CONSUMER ALSO STATED TH…

Owner-reported narrative. 3,500 miles reported. Look up ODI 10430633 at NHTSA ↗

A BRACKET HOLDING THE REAR SWAY BAR TO THE CHASSIS ON THE DRIVER SIDE IS MISSING ONE OF TWO BOLTS. THE BRACKET IS BENT AND HANGS USELESSLY FROM THE CHASSIS. THIS 2011 TIFFIN ALLEGRO WAS BUILT ON A FORD F53 CHASSIS. MULTIPLE REPORTS AT TIFFINRVNETWORK.COM ALERTED ME TO CHECK FOR THE PROBLEM. *TR

Owner-reported narrative. 5,600 miles reported. Look up ODI 10466315 at NHTSA ↗

TL* THE CONTACT OWNS A 2011 TRINITY MT3 (N/A) WITH KINGS ST5000 TIRES,(N/A) SIZE: 175/80/13. THE CONTACT STATED THAT HE NOTICED TWO SPLITS ON THE SIDE WALL OF THE DRIVER'S SIDE TIRE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE TIRE WAS REPLACED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE OF BOTH THE TIRE AND THE VEHICLE WAS 1,000.

Owner-reported narrative. 1,000 miles reported. Look up ODI 10537913 at NHTSA ↗

The contact owns a 2011 Tiffin RV with a Ford F53 chassis. The contact stated while driving approximately 4 MPH as the vehicle slowed for traffic the brakes failed. The contact crashed into the vehicle directly in front with no damage to the first vehicle. The contact's vehicle sustained damage to the front cap which was cracked and fractured. The contact stated no warning light was illuminated. The contact stated that the police were not called and no person involved sustained any injuries. The contact drove his vehicle home and did not take t…

Owner-reported narrative. 62,000 miles reported. Look up ODI 11467003 at NHTSA ↗

Reported: 2010-10-25 (October 25, 2010)

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO, ALLEGRO BUS, AND PHAETON RVS EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.

Consequence: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.

Remedy: TIFFIN IS WORKING WITH ATWOOD AND WILL REPLACE OR REPAIR THE STOVES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 28, 2010. OWNERS MAY CONTACT ATWOOD AT 1-574-266-4749 OR TIFFIN 1-256-356-8661.

Reported: 2011-02-08 (February 8, 2011)

TIFFIN MOTORHOMES IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy: TIFFIN MOTORHOMES IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.

Reported: 2011-11-10 (November 10, 2011)

TIFFIN MOTORHOMES, INC. (TIFFIN) IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO AND PHAETON RECREATIONAL VEHICLES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH A CUMMINS ISC, ISX, ISM, OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

Consequence: IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Remedy: TIFFIN IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR TIFFIN AT 1-256-356-8661.

Reported: 2012-03-19 (March 19, 2012)

TIFFIN IS RECALLING CERTAIN MODEL YEAR 2010 THROUGH 2012 ALLEGRO MOTORHOMES BUILT ON FORD F-53 AND F-59 STRIPPED CHASSIS. THE GEAR SHIFT CABLE MAY BREAK AT THE ATTACHMENT TO THE TRANSMISSION CONTROL SELECTOR ARM ASSEMBLY MOUNTED ON THE STEERING COLUMN. IF THE CABLE BREAKS, THE TRANSMISSION GEAR INDICATOR IN THE GEAR SHIFT DISPLAY IN THE INSTRUMENT PANEL WILL REMAIN IN THE FIRST GEAR POSITION REGARDLESS OF THE GEAR SELECTED. 

Consequence: AN INCORRECT GEAR INDICATION IN THE INSTRUMENT PANEL MAY PREVENT THE DRIVER FROM KNOWING IF THEY ARE IN PARK OR REVERSE, INCREASING THE RISK OF A CRASH.

Remedy: TIFFIN IS WORKING WITH FORD TO IDENTIFY AND NOTIFY OWNERS OF THE AFFECTED MOTORHOMES. FORD WILL REPLACE THE TRANSMISSION SELECTOR ARM ASSEMBLY AND THE GEAR SHIFT CABLE ASSEMBLY, FREE OF CHARGE. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661 OR FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Reported: 2014-05-22 (May 22, 2014)

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2009-2011 Allegro, 2010-2011 Bus and Breeze, and 2008-2011 Phaeton and Zephyr recreational vehicles, equipped with LED clearance lights made by Command Electronics, Inc. In the affected vehicles, moisture may enter the light and cause a short between two connections on the circuit board.

Consequence: A short in the circuit board increases the risk of a fire.

Remedy: Tiffin will notify owners, and dealers will install a one amp inline fuse into the front and rear circuits that will blow if there is a short in any of the clearance lights, free of charge. The recall began on July 31, 2014. Owners may contact Tiffin customer service at 1-256-356-8661.

Reported: 2015-12-28 (December 28, 2015)

Tiffin Motorhomes (Tiffin) is recalling certain model year 2007-2015 motorhomes manufactured May 1, 2007, to December 31, 2014, equipped with certain Coachstep Double and Triple Electric Steps. The bolt that attaches the fan gear assembly to the steps may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may become unstable.

Consequence: Unstable entry and exit steps increase the risk of injury.

Remedy: Dealers will install a retainer bracket on the double step assemblies and the Coachstep Linkage Assembly will be replaced and a retainer bracket will be installed on the trip step assemblies. The recall began on Ferbuary 10, 2016. Owners may contact Tiffin customer service at 1-256-356-8661, or Lippert customer service at 1-574-537-8900.

Reported: 2016-07-13 (July 13, 2016)

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain model year 2007-2011 Allegro, Allegro Bus, Phaeton, and Zephyr motorhomes, 2007-2010 Allegro Bay motorhomes, and 2010-2011 Allegro Breeze motorhomes. The windshield wiper arms on the affected vehicles may break off.

Consequence: If the windshield wiper arms break, the driver's visibility may be reduced, increasing the risk of a crash.

Remedy: Tiffin will notify owners, and dealers will replace the wiper blade arms, free of charge. The recall began on August 19, 2016. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIFF-100.

Reported: 2017-12-22 (December 22, 2017)

Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2009-2018 Allegro and Allegro RED, Bus and Phaeton vehicles, 2009-2010 Bay vehicles, 2011-2018 Breeze vehicles, and 2009-2015, and 2017-2018 Zephyr vehicles. These motorhomes are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Tiffin will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on February 5, 2018. Owners may contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. Owners may also contact Tiffin customer service at 1-256-356-8661.