2014 Thor Motor Coach WINDSPORT: complaints, problems and recalls

THE CORE ISSUE IS THAT THE PASSENGER WIPER BLADE WILL FLOP ALL THE WAY OVER AGAINST THE POST OF THE DRIVER SIDE WIPER BLADE CAUSING BOTH BLADES TO GET STUCK. I HAVE TO STOP AND GET OUT AND PHYSICALLY PULL THE WIPER BLADE UP WHILE THEY ARE RUNNING TO GET IT GOING AGAIN. THIS FIRST HAPPENED THE DAY I BROUGHT IT HOME FROM THE DEALERSHIP. IT WAS RAINING VERY HARD WITH HEAVY GUSTS OF WIND, AND I WAS ON THE INTERSTATE WITH THE WIPERS ON AND IT SEEMS LIKE A GUST OF WIND CAUGHT THE PASSENGER SIDE WIPER AND PEGGED IT AGAINST THE DRIVER SIDE WIPER, CA…

Owner-reported narrative. Look up ODI 10935749 at NHTSA ↗

2014 WINDSPORT. CONSUMER WRITES IN REGARDS TO TMC WINDSHIELD WIPER SYSTEM SAFETY RECALL. *LD THE CONSUMER STATED THE VEHICLE WAS REPAIRED. *JS

Owner-reported narrative. Look up ODI 11121388 at NHTSA ↗

Reported: 2013-04-25 (April 25, 2013)

Thor Motor Coach is recalling certain model year 2013-2014 Challenger, Four Winds 5000, Hurricane, Chateau, Chateau Sport, and Windsport; model year 2013 Palazzo and Four Winds Siesta and model year 2014 Majestic motorhomes manufactured February 13, 2013, through April 09, 2013. If the awning installation sequence was not completely followed, the awning motor may unknowningly become damaged. A damaged motor may lead to an unfurling of the awning.

Consequence: If motor damage occurs, it is possible that the awning can unfurl unexpectedly, either while the motorhome is at rest or while in transit, increasing the risk of personal injury or a vehicle crash.

Remedy: Thor Motor Coach will notify owners and Dometic staff will replace the affected motors with a design that is not subject to an out-of-sequence installation error. The recall began during May 2013. Owners may contact Thor at 1-877-855-2867 or Dometic at 1-888-447-0003 for more information. Owners are being instructed not to drive their vehicle until repairs can be performed.

Reported: 2015-11-10 (November 10, 2015)

Thor Motor Coach (Thor) is recalling certain model year 2011-2016 Thor Challenger, Thor Citation, Thor Hurricane, Thor Tuscany, Thor Windsport, 2011-2012 Thor Astoria, Thor Avanti, Thor Chateau, 2011-2014 Thor Daybreak, 2011-2015 Thor Outlaw, Thor Siesta, 2014-2015 Thor Miramar, 2012 Thor Four Winds, 2008-2011 Damon Astoria, Damon Daybreak, Damon Outlaw, Damon Tuscany, 2008-2012, Damon Challenger, 2008-2010 Damon Essence, 2009-2011 Damon Avanti, Four Winds Chateau, Four Winds Citation, Four Winds Four Winds, Four Winds Hurricane, Four Winds Siesta, Four Winds Windsport, 2009-2010 Four Winds Dorado, Four Winds Dutchmen, Four Winds Magellan, Four Winds Mandalay and 2009 Four Winds Fun Mover, and Four Winds Presidio motorhomes. The affected vehicles are equipped with certain Lippert-brand Coachstep Double and Triple Electric Steps. These steps use a bolt to attach the fan gear assembly to the steps. This bolt may fracture allowing the fan gear to disengage from the steps. As a result, the steps may not remain in the expected position and may be unstable.

Consequence: Unstable entry and exit steps increase the risk of injury.

Remedy: Thor will notify owners, and dealers will install a retainer bracket to reinforce the operating mechanism and replace all of the affected bolts, free of charge. The recall began on January 6, 2016. Owners may contact Thor customer service at 1-877-855-2867. Thor's number for this recall is RC000111.

Reported: 2016-03-07 (March 7, 2016)

Thor Motor Coach (TMC) is recalling certain model year 2014-2016 Hurricane and Windsport motor homes manufactured January 30, 2013, to March 6, 2015. In the affected motor homes, the vehicle exhaust is located near a storage compartment where heat may build-up, causing the compartment to melt.

Consequence: Heat build-up in the vehicle storage compartment increases the risk of fire.

Remedy: TMC will notify owners, and dealers will install a heat shield to prevent heat build-up in the storage compartment. The recall began on April 20, 2016. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000112.

Reported: 2017-03-13 (March 13, 2017)

Thor Motor Coach (TMC) is recalling certain 2014-2015 ACE, Hurricane, Challenger, Daybreak, Miramar, Outlaw, and Windsport motorhomes. These vehicles have windshield wiper systems that may have been improperly installed and secured, possibly causing the wipers to fail during use.

Consequence: Failure of the windshield wipers may impair the driver's visibility, increasing the risk of a crash.

Remedy: TMC has notified owners, and dealers will inspect and tighten the wiper arm securing nuts, free of charge. The recall began on May 5, 2017. Owners may contact TMC customer service at 1-877-855-2867.

Reported: 2017-09-07 (September 7, 2017)

Thor Motor Coach (TMC) is recalling certain 2014-2016 Ace, Challenger, Daybreak, Hurricane, Miramar, Outlaw, Windsport, Palazzo, Tuscany, and Tuscany XTE motorhomes. The windshield wipers may fail due to the system being incorrectly installed or secured.

Consequence: If the windshield wipers cannot be used, driver visibility would be reduced, increasing the risk of a crash.

Remedy: TMC will notify owners, and dealers will inspect the wiper system to verify it is installed correctly, repairing or replacing the system as necessary, free of charge. The recall began on September 27, 2017. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000146. Note: Although some of the vehicles included in this recall have previously been remedied under recalls 17V-096 or 17V-162, the vehicles may need additional repairs under this campaign.

Reported: 2017-11-22 (November 22, 2017)

Thor Motor Coach (Thor) is recalling various 2003-2018 recreational vehicles, equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. See a list of the affected trailer models at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V758-5764.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Consequence: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy: Thor will notify owners, instructing them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on January 15, 2018. Owners may contact Thor customer service at 1-877-500-1020, or Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.