2010 Suzuki GRAND VITARA: complaints, problems and recalls

EVERY MORNING I HEAD OFF TO WORK WHEN THE VEHICLE IS COLD, I START THE VEHICLE, I PUT INTO DRIVE AS I ACCELERATE TO ABOUT 10 MILES I HEAR A RATTLING SOUND FROM UNDERNEATH THE VEHICLE. THIS SOUNDS HAPPENS EVEN WHEN THE CAR IS WARM ACCELERATING FROM A STOPPED POSITION, SUCH AS BEING AT A STOPLIGHT. I HAD THE VEHICLE IN THE REPAIR SHOP AT THE DEALER WHERE I PURCHASED THE VEHICLE. THE DEALER'S SERVICE DEPARTMENT SAID IT WAS THE HEAT SHIELD FOR THE CATALYTIC CONVERTER. I LEFT THE VEHICLE OVERNIGHT, IN ORDER FOR THE SERVICE DEPARTMENT TO EXPERIENCE …

Owner-reported narrative. 13,859 miles reported. Look up ODI 10512927 at NHTSA ↗

ELECTRONIC STABILIZING SYSTEM ESP STOPPED WORKING, NEEDING SERVICED. BRAKE LIGHT ALWAYS ON WITH EPS LIGHT AS WELL. ON TOP OF A MAJOR PROBLEM WITH THE FLOOR BOARDS SWELLS AND SOAKS WITH WATER IN FRONT RIGHT PASSENGER AND BACK PASSENGER SIDE FLOORS, ITS WORST WHEN A/C IS RUNNING... ITS LIKE A SPONGE WHEN U TAKE YOUR HAND TO IT. *TR

Owner-reported narrative. 50,000 miles reported. Look up ODI 10522474 at NHTSA ↗

I WAS LEAVING TO GO TO WORK AT 9:45 PM AND HEADING UP MY STREET WHEN MY LIGHTS QUIT WORKING. I WAS NOT ABLE TO GO TO WORK DUE TO NO WORKING LIGHTS AND HAD TO CALL OUT OF WORK. THIS IS NOT OK I HAVE A LITTLE ONE AND WORK RESPONSIBILITIES. ITS A 2010 VEHICLE AT 36941 MLES THERE IS ABSOLUTELY NO REASON MY LIGHTS SHOULD BE GOING OUT. I JUST BOUGHT THIS CAR IN MARCH. *JS

Owner-reported narrative. 36,941 miles reported. Look up ODI 10538207 at NHTSA ↗

2010 SUZUKI GRAND VITARA. CONSUMER WRITES IN REGARDS TO TENSION ADJUSTER PULLEY RECALL NOTICE. *SMD THE CONSUMER STATED HE RECEIVED A RECALL STATING THE TENSION ADJUSTER PULLEY FOR THE DRIVE BELT WAS IMPROPERLY MANUFACTURED. THE CONSUMER PAID FOR THE PART AND HAD HIS LOCAL MECHANIC TO REPLACE THE DEFECTIVE PART. CUSTOMER SERVICE, INFORMED THE CONSUMER SUZUKI WOULD NOT REIMBURSE HIM FOR THE INCURRED COST. THE CONSUMER WAS ALSO INFORMED, THE PARTS WERE NOT AVAILABLE REGARDING THE AIR BAG RECALL. *JB UPDATED 01/21/15.*JB

Owner-reported narrative. Look up ODI 10557786 at NHTSA ↗

TL* THE CONTACT OWNS A 2010 SUZUKI GRAND VITARA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER'S SIDE AIR BAG WARNING LIGHT WOULD INTERMITTENTLY ILLUMINATE WHEN THERE WAS MOVEMENT IN THE SEAT. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE DRIVER SEAT CUSHION NEEDED TO BE REPLACED. THE CONTACT RECEIVED A NOTIFICATION FOR RECALL NHTSA CAMPAIGN NUMBER: 13V405000 (AIR BAGS) WHICH SPECIFIED THE FAILURE THAT THE VEHICLE WAS EXHIBITING BUT ON THE PASSENGER SIDE. THE MANUFACTURER WAS NOT MADE AWARE OF THE …

Owner-reported narrative. 26,276 miles reported. Look up ODI 10662010 at NHTSA ↗

I OWN 2 SUZUKI GRAND VITARA 2010 & 2007 AND I GOT A RECALL NOTICE FROM THE MANUFACTURE FOR TAKING THE CAR TO THE DEALER FOR FIXING THE AIR BAG ISSUE RECALL CALLED DV SO I CHECKED AND THE NEAREST AUTHORIZED DEALER IS A ONE OUR DRIVE SO I CALLED THE MANUFACTURE AND ASKED FOR HELP BECAUSE ITS THEIR PROBLEM AND THEY SHOULD SOME HOW HELP COSTUMERS TO GET THE CAR REPAIR BEFORE SOMEONE GETS HEART THE APPOINTMENT TAKES A 1/2 DAY OR MORE DEPEND OF THE DAY AND WHERE YOU LIVE. SO I HAVE TO LOOSE A DAY AND GAS MONEY AND MY TIME AND GO TO THE NEXT TOWN TO G…

Owner-reported narrative. Look up ODI 10662491 at NHTSA ↗

MY DRIVER SIDE LIGHT KEEPS BLOWING THRU LOW BEAM H7 HEADLAMP BULBS. THEY SEEM TO FRY EVERY 6 TO 10 MONTHS. *TR

Owner-reported narrative. 81,223 miles reported. Look up ODI 10680414 at NHTSA ↗

HAVING TROUBLE WITH LOW BEAM HEAD LAMP NOT WORKING HAVE REPLACE BULBS MORE THEN ONCE. OWNERS ON INTERNET ARE HAVING THE SAME PROBLEMS. DEALER WILL NOT FIX PROBLEM. I ALMOST GOT IN A ACCIDENT DUE TO SOMEONE THOUGHT I WAS A MOTOR CYCLE. MANY OWNERS HAVE COMPLAINED BUT NOTHING HAS BEEN DONE. OWNERS ALSO HAVE BEEN PULLED OVER AND BEEN GIVEN TICKETS FOR PROBLEM. PLEASE HELP. *TR

Owner-reported narrative. 80,000 miles reported. Look up ODI 10681649 at NHTSA ↗

Reported: 2010-09-01 (September 1, 2010)

SUZUKI IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 SX4, 2010 GRAND VITARA, AND 2009 THROUGH 2010 EQUATOR VEHICLES THAT WERE EQUIPPED WITH A GARMIN NUVI MODEL 750, 760, AND 765 NAVIGATION SYSTEM. THE BATTERIES CONTAINED IN THE AFFECTED GPS UNITS CAN OVERHEAT.

Consequence: OVERHEATED BATTERIES COULD RESULT IN A FIRE.

Remedy: SUZUKI WILL NOTIFY OWNERS AND THE REPAIRS WILL BE PERFORMED BY GARMIN TECHNICIANS BY REPLACING THE BATTERY AND INSERTING A SPACER ON TOP OF THE BATTERY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 24, 2010. OWNERS MAY CONTACT GARMIN DIRECTLY AT 1-866-957-1981 OR SUZUKI AT 1-887-697-8985. OWNERS MAY ALSO VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.

Reported: 2011-01-27 (January 27, 2011)

SUZUKI IS RECALLING CERTAIN MODEL YEAR 2009-2010 SUZUKI GRAND VITARA MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH 4-CYLINDER ENGINES; MODEL YEAR 2011 SUZUKI GRAND VITARA MULTIPURPOSE PASSENGER VEHICLES PRODUCED PRIOR TO OCTOBER 17, 2010; MODEL YEAR 2010 SUZUKI SX4 PASSENGER VEHICLES; AND 2011 SUZUKI SX4 PASSENGER VEHICLES PRODUCED PRIOR TO OCTOBER 14, 2010. THE TENSION ADJUSTER PULLEY FOR THE DRIVE BELT THAT OPERATES THE ALTERNATOR, WATER PUMP, AIR CONDITIONER COMPRESSOR AND POWER STEERING PUMP, HAS AN IMPROPERLY MANUFACTURED INTERNAL SPRING THAT CAN BREAK DUE TO REPEATED STRESS. IF THE SPRING BREAKS, THE DRIVE BELT WILL NOT BE ADJUSTED PROPERLY AND CAN SLIP, CAUSING A SQUEAKING NOISE. OR THE DRIVE BELT COULD COME OFF CAUSING THE DRIVER TO INCREASE TO STEER THE VEHICLE. THIS CAN ALSO CAUSE THE COOLANT TEMPERATURE INDICATION TO RISE, WHICH CAN LEAD TO THE ENGINE OVERHEATING, OR CAN CAUSE THE CHARGING LIGHT TO COME ON, WHICH CAN LEAD TO BATTERY DISCHARGE AND ENGINE STALL.

Consequence: IF THE DRIVE BELT COMES OFF, REQUIRING THE DRIVER TO USE INCREASED STEERING EFFORT, OR THE ENGINE STALLS, A VEHICLE CRASH COULD OCCUR

Remedy: DEALERS WILL REPLACE THE TENSION ADJUSTER PULLEY WITH AN IMPROVED PART. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 16, 2011. OWNERS MAY CONTACT SUZUKI AT 1-887-697-8985 OR VISIT SUZUKI'S WEBSITE AT HTTP://WWW.SUZUKIAUTO.COM.

Reported: 2013-09-06 (September 6, 2013)

Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2006-2011 Grand Vitara and 2007-2011 SX4 vehicles. In the affected vehicles, over time, the OCS sensor mat installed in the front passenger seat may fail due to repeated flexing of the mat from use of the seat. As a result, during a crash necessitating deployment, the air bag will deploy regardless of whether the front seat occupant is an adult or a child.

Consequence: Air bag deployment with a child in the front passenger side seat increases the risk of injury to that child.

Remedy: Suzuki will notify owners and dealers will replace the front passenger seat cushion assembly (which includes the OCS sensor mat) free of charge. Sufficient quantities of parts are not currently available to fix all of the affected vehicles. Owners will be notified of the recall in October 2013 and will receive a second notification when parts are available to have their vehicle repaired. The recall began on May 23, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's recall campaign number is VD.

Reported: 2017-02-09 (February 9, 2017)

Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2009-2013 Grand Vitara vehicles equipped with a manual transmission. The gear shift rear shaft on these vehicles may break, preventing the gears from being able to be changed.

Consequence: If the transmission cannot be shifted, it can increase the risk of a crash.

Remedy: Suzuki will notify owners, and dealers will replace the gear shift rear shaft, free of charge. The recall began March 2017. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's number for this recall is VZ.

Reported: 2019-03-07 (March 7, 2019)

Suzuki Motor of America, Inc. (Suzuki) is recalling certain 2010-2013 Kizashi and 2006-2013 Grand Vitara vehicles. The front passenger leather seat may shrink due to high humidity and high temperature. As a result, the occupant classification system (OCS) sensor mat may not accurately detect if an adult or child is occupying the seat.

Consequence: In the event of a crash necessitating airbag deployment, an incorrect classification may result in the passenger frontal air bag deploying even if there is a child in the front passenger seat, increasing their risk of injury.

Remedy: Suzuki will notify owners, and dealers will replace the seat bottom cushion, free of charge. Interim owner notification letters were mailed on May 3, 2019. All second letters notifying owners of the remedy were mailed by April 10, 2020. Owners may contact Suzuki customer service at 1-800-934-0934. Suzuki's numbers for this recall are 4011 and 4012.