2003 Suzuki GRAND VITARA XL-7: complaints, problems and recalls

THE BRAKES ON THE CAR FAILED, THE BRAKE PEDAL WAS PRESSED AND IT WENT ALL THE WAY TO THE FLOOR BUT THE CAR WILL NOT STOP. THE HAND BRAKE WAS PULLED AND THE CAR WAS DIRECTED OUT OF THE ROAD INTO THE GRASS TO MAKE IT STOP. *JB THE DISTANCE WAS MEASURED AND IT WAS 75 FEET FROM THE POINT WHERE THE BRAKE WAS APPLIED TO THE POINT THE CAR STOPPED. THE CAR WAS GOING 35-40 MPH. THE DRIVER FINALLY GOT THE CAR TO STOP BY PULLING THE HAND BREAK BUT THE CAR HIT THE BUMPER HIT THE REAR OF PICK UP TRUCK IN FRONT AND THE TOW HITCH OF THE PICK UP TRUCK C…

Owner-reported narrative. 1,300 miles reported. Look up ODI 10039280 at NHTSA ↗

I BOUGHT THIS VEHICLE FROM A SUZUKI DEALER ON LONG ISLAND, 14 MONTHS AFTER I BOUGHT A SUZUKI 2003 AERIO SX AWD, FROM THE SAME DEALER. THE AERIO HAD LOUD HUMMING IN THE REAR OF THE CAR. BROUGHT IT BACK 3 TIMES BEFORE THEY HAD A FACTORY REP TELL THEM THAT THE REAR DIFFERENTIAL WAS DEFECTIVE. THEY REPLACED IT, AND ALTHOUGH THE HUMMING WAS GONE, THERE WAS A TERRIBLE VIBRATION WHEVER I STEPPED ON THE GAS. BROUGHT IT BACK 2 TIMES BEFORE THEY SAID THAT THE ENGINE MOUNTS WERE DEFECTIVE. THEY ORDERED THE PARTS IN EARLY NOVEMBER, AND SAID THEY WERE ON BA…

Owner-reported narrative. 11,206 miles reported. Look up ODI 10052764 at NHTSA ↗

WHILE DRIVING 15 MPH ACCELERATOR PEDAL STUCK. AS A RESULT, VEHICLE LOST CONTROL AND COLLIDED INTO A WALL BARRIER. NO INJURIES REPORTED. *AK

Owner-reported narrative. 200 miles reported. Look up ODI 10055586 at NHTSA ↗

CONSUMER RECEIVED A RECALL NOTICE, AND MADE 3 SEPARATE APPOINTMENTS. ALL WERE CANCELLED BECAUSE PARTS WERE NOT AVAILABLE TO SERVICE VEHICLE. *AK

Owner-reported narrative. 9,850 miles reported. Look up ODI 10056141 at NHTSA ↗

BASED ON THE CONSEQUENCES OF NOT GETTING THE RECALL WORK PERFORMED, THE CONSUMER WANT THE WORK DONE OR ANOTHER SUZUKI GRAND VITARA. *PH PROBLEMS WITH ALARM SYSTEM AS WELL AS VEHICLE CUTTING OFF AND LOSS OF CONTROL. *MR

Owner-reported narrative. Look up ODI 10065072 at NHTSA ↗

FAILURE ON BRAKES, ACCELERATOR, ALARM, LIGHTS AND PROBLEMS WITH THE CARPET. *MR THE BRAKES AND ACCELERATOR WERE RECALLED. THE BRAKES MADE A LOUD NOISE WHEN TURNING THE STEERING WHEEL. THE ALARMED FAILED. THE VEHICLE HAS BEEN TAKEN TO THE DEALER ABOUT TEN TIMES IN REFERENCE TO THE ALARM. THE DOOR AJAR CHIME DID NOT WORK. THE CARPET WAS LOOSE. THE CONSUMER HAD TO WAIT TWO MONTHS BEFORE IT WAS FIXED. *NM

Owner-reported narrative. Look up ODI 10073461 at NHTSA ↗

PROBLEM WITH VEHICLE ACCELERATING BACKWARDS WHEN TRYING TO PARK. *MR THE VEHICLE HIT A STEEL BEAM. THE PROBLEM WAS DUE TO THE ACCELERATOR CABLE. (SUZUKI XL 7) *SC THE C ONSUMER STATED THE VEHICLE HAD JUST BEEN SERVICED FOR A RECALL REGARDING THE ACCELRATOR CABLE. *JB

Owner-reported narrative. Look up ODI 10089125 at NHTSA ↗

DT: THE BRAKES ARE SQUEAKING, AND THE TECHNICIAN CANNOT FIND THE CAUSE OF THE PROBLEM. THE BRAKE PADS WERE REPLACED AND WERE STILL SQUEAKING. THE FRONT SHOCKS WERE REPLACED, BUT THE TECHNICIAN SAID THE REAR SHOCKS NOT WORKING WELL, AND THIS WAS NORMAL. AIR CONDITIONER (A/C) WAS NOT COOLING. THE VEHICLE DOES NOT FEEL SAFE ANYMORE.*AK

Owner-reported narrative. Look up ODI 10124086 at NHTSA ↗

Reported: 2003-06-16 (June 16, 2003)

CERTAIN PASSENGER (111 MY 2002 ESTEEM, 777 MY 2002 AERIO, 2,368 MY 2003 AERIO) AND SPORT UTILITY (324 MY 2002 GRAND VITARA, 274 MY 2003 GRAND VITARA, 684 MY 2002 GRAND VITARA XL-7, AND 781 MY 2003 GRAND VITARA XL-7) VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, 'WINDSHIELD MOUNTING." THE WINDSHIELD MAY NOT BE PROPERLY SECURED TO THE VEHICLE BODY DUE TO INSUFFICIENT ADHESION BETWEEN THE PAINT APPLIED DURING THE SECOND-STAGE PAINTING PROCESS AND THE PAINT APPLIED DURING FINAL-STAGE PAINTING.

Consequence: IF THE WINDSHIELD IS NOT PROPERLY SECURED, IT MAY SEPARATE FROM THE VEHICLE DURING A CRASH WHICH COULD RESULT IN THE EJECTION OF UNBELTED OCCUPANTS, INCREASING THE RISK OF SEVERE INJURY OR DEATH.

Remedy: DEALERS WILL INSPECT THESE VEHICLES. VEHICLES THAT ARE FOUND TO HAVE INSUFFICIENT PAINT ADHESION WILL EITHER HAVE THE PROBLEM REMEDIED BY REPAINTING, OR WILL BE REPLACED, OR REPURCHASED AND DESTROYED. OWNER NOTIFICATION BEGAN ON JULY 8, 2003. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.

Reported: 2003-12-02 (December 2, 2003)

ON CERTAIN SPORT UTILITY VEHICLES, THE IGNITION SYSTEM WIRING HARNESS IS ROUTED UNDER THE INTAKE MANIFOLD. THE HARNESS CAN RUB AGAINST THE MANIFOLD DURING VEHICLE OPERATION AND ABRASION DAMAGE TO THE HARNESS CAN OCCUR.

Consequence: DAMAGE TO THE WIRING HARNESS CAN CAUSE A SHORT IN THE IGNITION CIRCUIT, WHICH CAN CAUSE THE IGNITION FUSE TO BLOW AND THE ENGINE TO STOP RUNNING. THIS CAN RESULT IN A LOSS OF CONTROL OF THE VEHICLE AND COULD CAUSE A CRASH.

Remedy: DEALERS WILL REPAIR ANY WIRING HARNESS DAMAGE AND WILL ADD ADDITIONAL INSULATION AND A PROTECTOR PLATE TO PREVENT THE WIRING HARNESS FROM BECOMING DAMAGED. OWNER NOTIFICATION BEGAN ON DECEMBER 16, 2003. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.

Reported: 2004-08-30 (August 30, 2004)

ON CERTAIN PASSENGER VEHICLES, UNDER AMBIENT TEMPERATURES BELOW -25 DEGREES CELSIUS, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. AS A RESULT, FUEL SYSTEM PRESSURE MAY INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.

Consequence: FUEL LOSS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PRESSURE REGULATOR, THE FUEL DELIVER HOSE AND REPLACE THE HOSE CLAMP WITH AN IMPROVED CLAMP. THE RECALL BEGAN ON SEPTEMBER 29, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.